After buying the vehicle on 7/9/21, the car started having problems with the cooling system. I took it to a repair shop and they said the cooling system was overfilled. The air problem continued. I took it back to the dealership who said they fixed it but it continued. I contacted the prior Manufactuer service center who informe…
Read full complaint
After buying the vehicle on 7/9/21, the car started having problems with the cooling system. I took it to a repair shop and they said the cooling system was overfilled. The air problem continued. I took it back to the dealership who said they fixed it but it continued. I contacted the prior Manufactuer service center who informed me the computer chip was recommended to be replaced when the dealer had it serviced but they declined, causing all the electrical and cooling issues. I called the dealer and they said they had the alarm disconnected also which was why the computer system wasn't working. The alarm system doesn't work and I have had to replace the key fob 3 times. I took it to another repair shop who diagnosed the following as permanent failure codes: 6 CEM codes, 1 ECM code, 6 SRS codes, 2 DIM codes, 11 CEM-HS codes, passenger and driver door codes, 4 climate control codes, 1EPS code, 4 SWM codes, DD11, all of which are safety hazards.
NHTSA ODI #11428519
123,000 miles · Oct 21, 2014
Air BagsSeatsSuspensionCrashInjury
I WAS DRIVING MY 2008 VOLVO S40 STOPPED IN TRAFFIC WHEN I WAS IN MAJOR/SEVERE REAR END COLLISION. THE FORCE OF THE IMPACT (70+ MPH) PUSHED ME INTO A VEHICLE AHEAD WHICH CAUSED SEVERE FRONTAL DAMAGE THAT WENT ALL THE WAY PAST MY RADIATOR. PROPERTY DAMAGES OVER $17K AND AIRBAGS FAILED TO DEPLOY RESULTING IN INJURIES. *TR
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY VULCANIZED (CURED) AND DOES NOT MEET SPECIFICATIONS. IF THE POWER STEERING RETURN HOSE FAILS, A SUDDEN RUPTURE OF THE HOSE CAN OCCUR.
Consequence & remedy
Consequence: THIS CAN RESULT IN A RAPID DRAINAGE OF THE POWER STEERING FLUID IN THE SYSTEM AND A COMPLETE LOSS OF POWER ASSISTANCE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE STEERING RETURN LINE HOSE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 13, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2008 Volvo S40 Problems, Complaints & Recalls | Skip That Year
Illustration