DT*: THE CONTACT STATED THE WINDSHIELD WIPER LINKAGES ARE OUT OF SYNC AND LOCK TOGETHER WHICH CAUSES A LOSS OF VISIBILITY. THIS PROBLEM OCCURRED ON BOTH THE DRIVER AND PASSENGER SIDE WINDSHIELD WIPER LINKAGE ARMS. AFTER THE FIRST INCIDENT THE CONTACT CALLED THE MANUFACTURER'S CUSTOMER SERVICE DEPARTMENT. THEY INSTRUCTED THE C…
Read full complaint
DT*: THE CONTACT STATED THE WINDSHIELD WIPER LINKAGES ARE OUT OF SYNC AND LOCK TOGETHER WHICH CAUSES A LOSS OF VISIBILITY. THIS PROBLEM OCCURRED ON BOTH THE DRIVER AND PASSENGER SIDE WINDSHIELD WIPER LINKAGE ARMS. AFTER THE FIRST INCIDENT THE CONTACT CALLED THE MANUFACTURER'S CUSTOMER SERVICE DEPARTMENT. THEY INSTRUCTED THE CONTACT TO OPEN THE HOUSING ON THE WINDSHIELD WIPER LINKAGE ARM AND TIGHTEN THE BOLT. THE CONTACT DID AS INSTRUCTED ON THE DRIVER'S SIDE AND THIS CORRECTED THE PROBLEM. AFTERWARDS, THE PROBLEM RETURNED TO THE PASSENGER SIDE LINKAGE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP, AND THEY PERFORMED THE SAME REPAIR THAT WAS INSTRUCTED BY MANUFACTURER'S CUSTOMER SERVICE DEPARTMENT. HOWEVER, THE PROBLEM RECURRED. *AK THE ENGINE WOULD HESITATE WHEN THE CONSUMER ATTEMPTED TO ACCELERATE. THE DEALER REPLACED THE OXYGEN SENSOR. UPDATED 01/25/06. *JB
NHTSA ODI #10147051
44,594 miles · Oct 1, 2004
Electrical SystemPower TrainVisibility
WHEN ACCELERATING VEHICLE WOULD DOWN SHIFT GEARS. THE DEALERSHIP WILL BE NOTIFIED. *AK THE DEALER HAVE NOT BEEN ABLE TO DUPLICATE THE PROBLEM. THE TRANSMISSION JERKING OCCURRED, THE ENGINE LIGHT WOULD COME ON. THERE WOULD BE A BURNING OIL SMELL, THE GEAR SHIFTER WOULD NOT RELEASE AND WOULD STICK INTERMITTENTLY, THE STEER…
Read full complaint
WHEN ACCELERATING VEHICLE WOULD DOWN SHIFT GEARS. THE DEALERSHIP WILL BE NOTIFIED. *AK THE DEALER HAVE NOT BEEN ABLE TO DUPLICATE THE PROBLEM. THE TRANSMISSION JERKING OCCURRED, THE ENGINE LIGHT WOULD COME ON. THERE WOULD BE A BURNING OIL SMELL, THE GEAR SHIFTER WOULD NOT RELEASE AND WOULD STICK INTERMITTENTLY, THE STEERING WHEEL SQUEAKED AND WAS UNABLE TO BE DUPLICATED, THE WINDSHIELD WIPERS WOULD SQUEAK, AND THE SPEAKER WAS ERRATIC. *SC TRHE BATTERY WAS REPLACED, THE TAIL LIGHTS WERE OUT, THE WINDSHIELD WAS REPLACED. *JB
NHTSA ODI #10091894
Mileage unknown · May 31, 2003
Visibility
WHILE PARKED IN THE DRIVEWAY, A WATER BALLOON HIT THE SUN ROOF OF THE CAR AND IT SHATTERED. *TT
NHTSA ODI #10020803
Mileage unknown · Feb 5, 2002
Visibility
WHILE VEHICLE WAS PARKED, THE SUNROOF CAME LOOSE AND FELL INTO THE PASSENGER'S COMPARTMENT. WHEN THIS OCCURRED, GLASS SHATTERED AND SPREAD THROUGHOUT PASSENGER'S COMPARTMENT, DEALERSHIP HAS EXAMINED VEHICLE, AND WAS MAKING NECESSARY REPAIRS. *AK. CONSUMER STATES THAT VOLVO PURCHASED THE VEHICLE BACK FROM HIM. *YD
NHTSA ODI #8003539
Mileage unknown · Sep 6, 2001
Visibility
WHILE DRIVING ON A GRATED ROAD, CONSUMERS SON HIT A POTHOLE, AND ALL OF A SUDDEN THE SUNROFF SHATTERED INTO PIECES, DAMAGING THE VEHICLE AS WELL AS ANOTHER MOTORIST VEHICLE.*JB
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: SEDAN AND WAGON PASSENGER VEHICLES. A DIODE IN THE ELECTRONIC CLIMATE CONTROL SYSTEM MAY HAVE A REDUCED SERVICE LIFE.
Consequence & remedy
Consequence: IF THE DIODE FAILS, THE HEATER FAN STOPS OPERATING AND THE DEFROSTER FUNCTION IS AFFECTED.
Remedy: DEALERS WILL INSTALL AN ADAPTER WITH A DIODE FITTED TO THE HEATER FAN MOTOR. OWNER NOTIFICATION BEGAN JUNE 11, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02026 · Volvo S40/V40 My 2000-2001
Opened Sep 10, 2002 · Closed Nov 21, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
IN A NOVEMBER 6, 2003 SAFETY DEFECT REPORT, VOLVO INDICATED THAT THEY WILL CONDUCT A SAFETY-RELATED DEFECT RECALL OF THE 2000 MODEL YEAR (MY) SUBJECT VEHICLES (ABOUT 36,000 VEHICLES).VOLVO WILL ALSO CONDUCT A SERVICE CAMPAIGN OF ABOUT 31,000 2001 MY SUBJECT VEHICLES.ODI INVESTIGATED BOTH THE 2000 AND 2001 MY VEHICLES AND DETERMINED THAT THE 2001 MY VEHICLES EXPERIENCED SUBSTANTIALLY LOWER RATES OF FAILURES BASED ON THE NUMBER OF OWNER REPORTS AND WARRANTY CLAIMS SUBMITTED TO ODI.ODI BELIEVES THAT THE PROPOSED ACTION IS SUFFICIENT TO RESOLVE THIS INVESTIGATION'S SAFETY ISSUES. FOR THE CRASHES, IN ADDITION TO THE 22 SUBMITTED BY VOLVO, ODI FOUND 10 ADDITIONAL CRASH ALLEGATIONS IN THE OWNER REPORTS, FIELD REPORTS, AND WARRANTY CLAIMS SUBMITTED BY VOLVO.OF THESE 32 CRASHES, ODI BELIEVES THAT 10 ARE CLEARLY RELATED TO THE ALLEGED DEFECT, AND 5 APPEAR TO BE RELATED.OF THE 17 REMAINING CASES, TWO DID NOT INVOLVE A CRASH AND THE OTHER 15 COULD NOT BE DIRECTLY CONNECTED TO THE ALLEGED DEFECT.ODI WILL SUPPLEMENT THIS RESUME WITH A CLOSING REPORT AND ADDITIONAL TECHNICAL DETAILS CONCERNING THE DEFECT.
2001 Volvo S40 Problems, Complaints & Recalls | Skip That Year
Illustration