VW TOURAGE- SEVERAL TIMES WHEN STARTING FROM A STOP THE ENGINE LOSES POWER AS THE VEHICLE BEGINS TO ACCELERATE. THIS HAS PLACED ME IN SITUATION WHERE ON COMING TRAFFIC NARROWLY STOPPED BEFORE COLLIDING WITH ME. I HAVE HAD THE VEHICLE IN THE SHOP AND WILL BE TAKING IT AGAIN NEXT MONDAY;HOWEVER, THEY HAVE NOT FOUND THE PROBLEM. TH…
Read full complaint
VW TOURAGE- SEVERAL TIMES WHEN STARTING FROM A STOP THE ENGINE LOSES POWER AS THE VEHICLE BEGINS TO ACCELERATE. THIS HAS PLACED ME IN SITUATION WHERE ON COMING TRAFFIC NARROWLY STOPPED BEFORE COLLIDING WITH ME. I HAVE HAD THE VEHICLE IN THE SHOP AND WILL BE TAKING IT AGAIN NEXT MONDAY;HOWEVER, THEY HAVE NOT FOUND THE PROBLEM. THE DEALER HAS SUGGESTED IT HAS SOMETHING TO DO WITH A SAFETY DEVIVE THAT IS SOME WAY CONNECTED TO THE BRAKING SYSTEM.*AK
NHTSA ODI #10066214
Mileage unknown · Jan 27, 2004
Engine And Engine CoolingVehicle Speed Control
2004 VW TOUAREG V8. THESE VEHICLES EXHIBITS FREQUENT BUT INCONSISTENT DELAY IN THROTTLE RESPONSE. THIS ISSUE ARISES MOST OFTEN IN HEAVY TRAFFIC WHEN THE DRIVER COMES TO A ROLLING STOP. WHEN SHIFTING INPUTS FROM THE BRAKE TO THE THROTTLE THE VEHICLE WILL FREQUENTLY EXHIBIT A 1-2 SECOND DELAY BEFORE THERE IS ANY RESPONSE FROM …
Read full complaint
2004 VW TOUAREG V8. THESE VEHICLES EXHIBITS FREQUENT BUT INCONSISTENT DELAY IN THROTTLE RESPONSE. THIS ISSUE ARISES MOST OFTEN IN HEAVY TRAFFIC WHEN THE DRIVER COMES TO A ROLLING STOP. WHEN SHIFTING INPUTS FROM THE BRAKE TO THE THROTTLE THE VEHICLE WILL FREQUENTLY EXHIBIT A 1-2 SECOND DELAY BEFORE THERE IS ANY RESPONSE FROM THE ENGINE. THIS HAS TWO DANGEROUS CONSEQUENCES. FIRST, THE DRIVER MAY INCREASE THE THROTTLE PRESSURE WAITING FOR A RESPONSE, THEN GETTING MORE THEN EXPECTED ACCELERATION WHEN THE ENGINE FINALLY RESPONDS. SECOND, THE DRIVER COULD BE LEFT SITTING IN AN ONCOMING LANE WAITING FOR THE ENGINE TO RESPOND AND TAKE THE VEHICLE SAFELY ACROSS THE INTERSECTION. I HAVE REPORTED THIS TO TWO DIFFERENT VW DEALERS, ONE OF WHICH TURNED THE COMPLAINT TO VW. THERE HAS BEEN NO ACTION TAKEN, OR FURTHER RESPONSE FROM VW. *JB
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Consequence & remedy
Consequence: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.
Remedy: DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.
ON CERTAIN SPORT UTILITY VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT MAY HAVE BEEN INSUFFICIENTLY RIVETED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE BELT BUCKLE. OWNER NOTIFICATION BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN SPORT UTILITY VEHICLES, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED DURING ASSEMBLY. AN IMPROPERLY ROUTED TPMS WIRING HARNESS MAY CONTACT THE PARKING BRAKE CABLE SPRING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE TPMS WIRING CIRCUIT COULD BE INTERRUPTED, RESULTING IN AN INOPERATIVE TPMS, AND CAUSING A SHORT-TO-GROUND CONDITION THAT COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE TPMS WIRING HARNESS ROUTING AND, IF NECESSARY, CORRECT THE WIRING HARNESS ROUTING. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT VWOA AT 1-800-893-5298.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE06022 · Srs Warning Light Illumination
Opened Jun 19, 2006 · Closed Oct 30, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags:side/window
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05042 · Exterior Door Handle Malfunction
Opened Aug 11, 2005 · Closed Dec 21, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) DATED JUNE 10, 2005, DESCRIBING A CONDITION OF EXTERIOR DOOR HANDLE STICKS IN THE OPENED POSITION AFTER THE DOOR IS OPENED.VW DESCRIBED THE CAUSE OF THE PROBLEM TO BE A POTENTIAL FOR INCREASED FRICTION BETWEEN THE DOOR HANDLE AND THE LOCK CYLINDER HOUSING . . . BECAUSE SOME GUIDE NUBS THAT WERE MOLDED INTO THE PLASTIC DOOR HANDLE . . . WERE SLIGHTLY HIGHER THAN SPECIFIED.IN ADDITION TO THE TSB, VW HAS INTRODUCED PRODUCTION CHANGES (LUBRICATION, DELETION OF THE GUIDE NUBS, INTRODUCTION OF A LOW FRICTION GUIDE SURFACE ON THE LOCK CYLINDER HOUSING) TO ADDRESS THE PROBLEM.VW REPORTS THAT THE FAILURE OCCURS PREDOMINANTLY IN THE VERY EARLY LIFE STAGE OF THE VEHICLE.ODI EXAMINATION OF VW'S WARRANTY DATA SHOWS FEWER CLAIMS AS THE VEHICLE AGES.THE ONE INJURY RESULTED WHEN THE UNLATCHED DOOR HIT THE OCCUPANT'S HAND.A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO MONITOR COMPLAINTS ANDRESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2004 Volkswagen Touareg Problems, Complaints & Recalls | Skip That Year
Illustration