IllustrationI WAS PARKED IN MY GARAGE. WHEN I STARTED THE CAR, THE DRIVER HEADREST EXPLODED FORWARD. IF THIS HAD HAPPENED WHILE DRIVING IT COULD HAVE CAUSED AN ACCIDENT FROM THE SUDDEN MOVEMENT AND LOUD NOISE STARTLING ME.
2012 Volkswagen Routan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Volkswagen Routan do not stand out strongly from the model-year median of 63.
About this comparison →How this year compares
Owner complaints by model year
Compare all Routan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
325–50K
1050–75K
1275–100K
8100–150K
4150K+
45 reports with mileage · 18 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports2 injury reports
Seats complaints
2 reportsWHILE DRIVING ON A CITY STREET ROADS MAY HAVE HAD A LITTLE ICE ON THEM. FELT A SHARP SENSATION TO MY OUTER ANKLE AREA (I BELIEVE AT THE TIME I WAS IN THE PROCESS OF BREAKING TO COME TO A STOP. SHORTLY AFTER FELT THE SAME SENSATION TO MY ANKLE SHARP, BURNING, NOTICED THE SENSATION FELT ELECTRICAL FELT WARM SENSATION NEAR HIP AREA…
Read full complaint
WHILE DRIVING ON A CITY STREET ROADS MAY HAVE HAD A LITTLE ICE ON THEM. FELT A SHARP SENSATION TO MY OUTER ANKLE AREA (I BELIEVE AT THE TIME I WAS IN THE PROCESS OF BREAKING TO COME TO A STOP. SHORTLY AFTER FELT THE SAME SENSATION TO MY ANKLE SHARP, BURNING, NOTICED THE SENSATION FELT ELECTRICAL FELT WARM SENSATION NEAR HIP AREA... I BELIEVE THE SENSATION WAS ELECTRICAL CURRENTS THAT PENETRATED TO MY ANKLE. UPON THIS THOUGHT I IMMEDIATELY TURNED OFF MY SEAT WARMER, NOTICED THE HEEL OF MY BOOT MAY HAVE BEEN SITTING IN A WET AREA ON MY FLOOR MAT FROM THE MELTED SNOW ON MY BOOTS AND MY BOOTS HAD A METAL CLASP ON IT AT THE EXACT LOCATION THE PAINFUL SHARP ELECTRICAL SENSATION FELT ON MY ANKLE. PAIN DID NOT OCCUR AGAIN ONCE THE SEAT WARMER WAS TURNED OFF. NOTICED DULL TINGLING SENSATION IN MY MIDDLE FINGER SHORTLY AFTER THE SECOND EPISODE ALONG WITH WHAT FELT A LITTLE LIKE INDIGESTION.
Official recalls
112V147000 · Suspension:rear
Apr 5, 2012
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012 ROUTAN VEHICLES, MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.
Consequence & remedy
Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: VOLKSWAGEN WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.