TAKATA RECALL I WENT IN TO GET THE REPAIR A WEEK LATER AN AIRBAG FAULT CAME ON AND STILL ON. THEN TWICE WHILE I WAS DRIVEING ON HIGHWAY CAR CUTS OFF COMPLETELY THEN I HAVE TO PULL OVER WITH IT JUST ROLLING. THE STEERING SOMETIMES COMES ON AND SAYS DEFECTIVE THEN THE SUN ROOF OPEN CLOSES BY ITSELF. ALOT OF ELECTRICAL PROBLEMS ALW…
Read full complaint
TAKATA RECALL I WENT IN TO GET THE REPAIR A WEEK LATER AN AIRBAG FAULT CAME ON AND STILL ON. THEN TWICE WHILE I WAS DRIVEING ON HIGHWAY CAR CUTS OFF COMPLETELY THEN I HAVE TO PULL OVER WITH IT JUST ROLLING. THE STEERING SOMETIMES COMES ON AND SAYS DEFECTIVE THEN THE SUN ROOF OPEN CLOSES BY ITSELF. ALOT OF ELECTRICAL PROBLEMS ALWAYS HAVE TO GET SOMETHING FIX JUST PRAY THAT I DONT GET INTO AN ACCIDENT. THE HEATED SEATS DONT WORK NOMORE FOR SOME REASON ON DAY THEY WAS GOOD NOW NO AND ITS NOT THE FUSE.
NHTSA ODI #11041069
100,000 miles · Nov 28, 2015
Air BagsSeatsVisibility/wiper
I HAVE AN AIR BAG LIGHT ON AND I GET A WARNING SIGN THAT IT SHOULD BE SERVICED. WIPERS ARE NOT THAT EFFECTIVE AND I KEEP ON HAVING FOGY WINDOWS SO I HAVE TO KEEP ON ADJUSTING THE HEAT.
NHTSA ODI #10807254
88,725 miles · Jun 21, 2010
Seats
SEAT POSITION MOTOR INSTALLED ON 2006 VOLKSWAGEN PASSAT 3.6L. FRONT SEAT WILL NOT RECLINE UP AND DOWN. *TR
NHTSA ODI #10339333
Mileage unknown · Feb 15, 2006
SeatsInjury
LTR FM (PA) OWNER OF A 2006 PASSAT DEFECTIVE SEATING QUESTION WHY VEHICLE HAS NOT BEEN RECALLED DOT. *TS THE CONSUMER STATED THE HEATER SEATS BURNED HIM. *JB
NHTSA ODI #10150865
Mileage unknown · Feb 2, 2006
Seats
THERE IS A MANUFACTURER'S DEFECT IN MATERIAL FOR THE LEATHER SEATS AND HEADREST. VOLKSWAGEN IS NOT WILLING TO HONOR THE WARRANTY FOR THE LIMITED NEW VEHICLE. I WANTED TO A INDEPENDENT AUTO INTERIOR SPECIALIST, WHO SAID IT NEEDS TO BE REPLACED. YET, VOLKSWAGEN SAID IT'S NORMAL AND SAID THE OTHER VEHICLES ARE THE SAME. HOWEVER,…
Read full complaint
THERE IS A MANUFACTURER'S DEFECT IN MATERIAL FOR THE LEATHER SEATS AND HEADREST. VOLKSWAGEN IS NOT WILLING TO HONOR THE WARRANTY FOR THE LIMITED NEW VEHICLE. I WANTED TO A INDEPENDENT AUTO INTERIOR SPECIALIST, WHO SAID IT NEEDS TO BE REPLACED. YET, VOLKSWAGEN SAID IT'S NORMAL AND SAID THE OTHER VEHICLES ARE THE SAME. HOWEVER, WHEN ASKED TO SEE THE OTHER VEHICLES THERE WAS NONE AVAILABLE. *NM
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Beetle, Beetle Convertible, 2012-2014 Passat, 2017 Passat Wagon, and 2006-2007 Passat Sedan vehicles. The driver's side frontal air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Dealers will replace the driver's side front air bag module, free of charge. Owner notification letters were mailed December 4, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69EG, 69GQ, and 69E6.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2006-2007 Volkswagen Passat sedan and wagon vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the front driver air bag inflator with an alternate inflator, free of charge. The recall began on April 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q8. Note: This recall partially supersedes recall 16V-079.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2016 Volkswagen CC, 2006-2010 Passat and Passat Wagon vehicles. Interruption of electrical power to the fuel pump control module may cause the fuel pump to fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine will stall, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel pump control module, free of charge. The recall began June 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20AE.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2006 Volkswagen Passat sedans and wagons, 2005-2013 Audi A3, and 2006-2009 Audi A4 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. The recall began March 2017. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.
ON CERTAIN '6' GENERATION PASSENGER VEHICLES, THE WIPER MOTOR MAY FAIL DURING HEAVY RAIN DUE TO EXCESSIVE MOISTURE ENTERING THE WIPER MOTOR. IF THIS HAPPENS, THE WIPERS CAN BECOME INOPERATIVE.
Consequence & remedy
Consequence: THIS COULD LEAD TO REDUCED VISIBILITY INCREASING THE RISK OF A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A SPECIAL COVER AND SEALING KIT. THE RECALL BEGAN ON JANUARY 12, 2007. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.0L ENGINE WITH 147 KW MAY HAVE A VACUUM LINE THAT MAY FRACTURE AND BECOME DISCONNECTED AT LOW AMBIENT TEMPERATURES.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE POWER ASSIST CAN BECOME INOPERATIVE, AND THE DRIVER WILL EXPERIENCE INCREASED EFFORT TO APPLY THE BRAKES POSSIBLY INCREASING VEHICLE STOPPING DISTANCE. THIS COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED VACUUM LINE. THE RECALL BEGAN ON JANUARY 12, 2007. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
ON CERTAIN PASSENGER VEHICLES, THE LEFT AND RIGHT TIE ROD SECURING NUT MAY BE INSUFFICIENTLY TORQUED.
Consequence & remedy
Consequence: AN INSUFFICIENTLY TIGHTENED TIE ROD NUT MAY LOOSEN, RESULTING IN SEPARATION OF A TIE ROD. THIS CAN CAUSE A LOSS OF STEERING CONTROL, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT AND INSTALL NEW LEFT AND RIGHT TIE ROD SECURING NUTS AT THE PROPER TORQUED SPECIFICATION. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
2006 Volkswagen Passat Problems, Complaints & Recalls | Skip That Year
Illustration