NHTSA owner reports · September 18, 2026 snapshot.
Seats complaints
13 reportsClear category filter200,000 miles · Dec 22, 2015
Seats
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 70 MPH, THE SEAT HEATER BURNED A HOLE IN THE PASSENGER SEAT AND THE PASSENGER'S COAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 02/23/16*LJ THE CONS…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 70 MPH, THE SEAT HEATER BURNED A HOLE IN THE PASSENGER SEAT AND THE PASSENGER'S COAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 02/23/16*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED. UPDATED 03/30/16.*JB
NHTSA ODI #10811662
75,000 miles · Jun 9, 2014
Seats
I STARTED THE CAR AND IMMEDIATELY TURNED ON MY DRIVER'S HEATED SEAT. WITHIN 2 MINS, SMOKE STARTED APPEARING ON MY LEFT SIDE. I REALIZED MY SEAT WAS STARTING TO CATCH FIRE, SO I QUICKLY TURNED OFF THE VEHICLE. LUCKILY, MY CLOTHES DID NOT CATCH FIRE. HOWEVER, MY HEATED SEAT BURNED A HOLE COMPLETE THROUGH THE LEATHER. THIS IS …
Read full complaint
I STARTED THE CAR AND IMMEDIATELY TURNED ON MY DRIVER'S HEATED SEAT. WITHIN 2 MINS, SMOKE STARTED APPEARING ON MY LEFT SIDE. I REALIZED MY SEAT WAS STARTING TO CATCH FIRE, SO I QUICKLY TURNED OFF THE VEHICLE. LUCKILY, MY CLOTHES DID NOT CATCH FIRE. HOWEVER, MY HEATED SEAT BURNED A HOLE COMPLETE THROUGH THE LEATHER. THIS IS A MAJOR SAFETY ISSUE. *TR
NHTSA ODI #10597025
100,000 miles · Mar 26, 2014
SeatsFireInjury
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THE THAT FRONT PASSENGER'S SIDE HEATED SEAT WAS ACTIVATED WHEN A HIGH VOLTAGE OF HEAT PENETRATED THROUGH THE LEATHER SEAT CUSHION UNEXPECTEDLY. THE FRONT SEAT PASSENGER SUFFERED FROM A BURN TO THE RIGHT LEG. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THE THAT FRONT PASSENGER'S SIDE HEATED SEAT WAS ACTIVATED WHEN A HIGH VOLTAGE OF HEAT PENETRATED THROUGH THE LEATHER SEAT CUSHION UNEXPECTEDLY. THE FRONT SEAT PASSENGER SUFFERED FROM A BURN TO THE RIGHT LEG. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOTIFIED AND ACCEPTED RESPONSIBILITY FOR THE REPAIR EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10574964
Mileage unknown · Oct 21, 2011
SeatsFire
ON 10/20/11, I STARTED MY CAR AND TURNED ON THE DRIVER SEAT HEATER TO 2, TO WARM THE SEAT. I PROCEEDED TO DRIVE TO A 9 AM APPOINTMENT WITHIN 2 MILES FROM MY HOME. AFTER DRIVING JUST A COUPLE BLOCKS, I SMELLED A SLIGHT BURNING SMELL, BUT THOUGHT IT NORMAL SINCE I HAD NOT USED THE SEAT HEATER IN QUITE SOME TIME; IT WAS JUST LIKE…
Read full complaint
ON 10/20/11, I STARTED MY CAR AND TURNED ON THE DRIVER SEAT HEATER TO 2, TO WARM THE SEAT. I PROCEEDED TO DRIVE TO A 9 AM APPOINTMENT WITHIN 2 MILES FROM MY HOME. AFTER DRIVING JUST A COUPLE BLOCKS, I SMELLED A SLIGHT BURNING SMELL, BUT THOUGHT IT NORMAL SINCE I HAD NOT USED THE SEAT HEATER IN QUITE SOME TIME; IT WAS JUST LIKE TURNING THE HEAT ON IN A HOME AFTER SEVERAL MONTHS OF NON-USE. WITHIN A FEW SHORT BLOCKS, I FELT A STING IN MY LEFT LEG AND THOUGHT IT COULD HAVE BEEN A PINE NEEDLE, SO I SHIFTED MY BODY POSITION TO ALLEVIATE THE ISSUE. AFTER A COUPLE MORE SHORT BLOCKS, ANOTHER STINGING SENSATION. AT THE NEXT STOP SIGN, I REACHED DOWN WITH MY HAND TO FEEL WHAT COULD BE CAUSING THE STINGING OF MY LEG. I FELT A HOT SPOT IN THE LEFT SIDE OF MY SEAT AND TURNED OFF THE SEAT HEATER SINCE MY SEAT HAD WARMED ENOUGH TO BE COMFORTABLE, BUT I DID NOT THINK MY SEAT WAS BURNING, SO I CONTINUED ON TO MY APPOINTMENT. I WENT IN TO MY APPOINTMENT AND CAME OUT TO MY CAR AN HOUR AND A HALF LATER. I NOTICED WHAT LOOKED LIKE A SMALL CIGARETTE BURN IN THE SEAT AND A HORRIBLE SMELL IN THE CAR. I RETURNED HOME AND TOLD MY BOYFRIEND ABOUT THE INCIDENT. *TR
NHTSA ODI #10432321
81,500 miles · Apr 25, 2011
SeatsFire
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THE DRIVER SIDE SEAT WARMER IGNITED A FIRE AND BURNED THROUGH THE SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE REPAIR. THE MANUFACTURER WAS CONTACT WHO STATED THAT THEY WOULD DISCUSS THE REPAIRS WITH THE DEALER AND GIVE HIM A RETURN CA…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THE DRIVER SIDE SEAT WARMER IGNITED A FIRE AND BURNED THROUGH THE SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE REPAIR. THE MANUFACTURER WAS CONTACT WHO STATED THAT THEY WOULD DISCUSS THE REPAIRS WITH THE DEALER AND GIVE HIM A RETURN CALL ON THE REPAIR COSTS. THE FAILURE MILEAGE WAS 81,500.
NHTSA ODI #10397390
94,800 miles · Oct 12, 2010
Seats
SMALL HOLE HAS BURNED INTO THE DRIVERS SIDE SEAT WHEN HEATED SEATS ACTIVATED. WHEN THE SEAT IS ACTIVATED, IT BURNS THROUGH TO MY SKIN, MAKING HEAT FEATURE NOT USABLE. *TR
NHTSA ODI #10360125
67,158 miles · Jul 15, 2010
SeatsInjury
I DROVE ON A COLD DAY TO A MEETING AND AS A RESULT I GOT A 2ND DEGREE BURN ON LEFT BUTTOCK AFTER LEAVING SEAT HEATER ON NUMBER FIVE FOR ONE HOUR AND TWENTY MINUTE DRIVE. I AM A PARTIAL PARAPLEGIC THUS, I WAS UNAWARE OF TEMPERATURE AND UNAWARE OF INCREASED TEMPERATURE. *TR
NHTSA ODI #10343491
139,200 miles · Feb 11, 2010
SeatsFireInjury
I OWN A 2005 VOLKSWAGEN PASSAT GLS. THE FACTORY INSTALLED SEAT HEATER MALFUNCTIONED THE OTHER DAY PRODUCING SMOKE, BURNING MY BUTTOCK (AND FINGER WHEN I REACHED DOWN) AND BURNING TWO PEA SIZED HOLES ON THE DRIVER'S SEAT. THE LOCAL VW DEALER WAS AWARE OF THE ISSUE. I ALSO CALLED THE DISTRICT VW OFFICE AT 1-800-822-8987 AND…
Read full complaint
I OWN A 2005 VOLKSWAGEN PASSAT GLS. THE FACTORY INSTALLED SEAT HEATER MALFUNCTIONED THE OTHER DAY PRODUCING SMOKE, BURNING MY BUTTOCK (AND FINGER WHEN I REACHED DOWN) AND BURNING TWO PEA SIZED HOLES ON THE DRIVER'S SEAT. THE LOCAL VW DEALER WAS AWARE OF THE ISSUE. I ALSO CALLED THE DISTRICT VW OFFICE AT 1-800-822-8987 AND NOTIFIED THEM OF THE PROBLEM. APPARENTLY VW IS COVERING THE COST OF REPAIR ON SOME BUT NOT ALL VWS. I WAS TOLD THE 2005 PASSAT IS NOT COVERED UNDER ANY KIND OF EXTENDED WARRANTY. HOWEVER, THE DISTRICT OFFICE IS INVESTIGATING THE ISSUE AND PROMISED TO GET BACK TO ME BY DAY'S END TOMORROW. TO ME THIS IS A SAFETY ISSUE. OTHER THEN MINOR BURNS TO MY BUTTOCKS AND FINGERS, I WAS ABLE TO SAFELY PULL OVER AND TURN OFF THE SEAT HEATER. THE HEAT AND SMOKE WENT RIGHT AWAY. WHEN I ASKED ABOUT THE SAFETY, THE VW DEALER'S SERVICE DEPARTMENT SUGGESTED I NOT USE THE HEATERS UNTIL THEY ARE REPAIRED. I ASKED ABOUT DISABLING THEM VIA A FUSE OF SOMETHING BUT THEY SAID UNFORTUNATE THE FUSE CONTROLLED OTHER FUNCTIONS IN THE CAR. HOWEVER, I BELIEVE THIS IS A SAFETY ISSUE WITH THE 2005 PASSAT GLS. I'M OKAY BUT OTHERS MAY NOT BE SO LUCKY. ALSO, I'M CONCERNED HOW THE VW DEALER'S SERVICE DEPARTMENT SUGGESTED I JUST NOT USE IT AGAIN. WHAT IF SOMEONE ELSE USES THE CAR AND I FORGET TO TELL THEM? THE REPAIR BILL WAS ESTIMATED AT $900+ FOR THE DRIVER'S SEAT ONLY. *TR
NHTSA ODI #10308686
70,000 miles · Jan 4, 2010
SeatsFire
TL*THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE HEATED SEATS ON THE DRIVER SIDE OF THE VEHICLE CAUGHT FIRE. HE WAS ABLE TO EXTINGUISH THE FIRE. THE DEALER STATED THAT THEY WOULD NOTIFY THE CONTACT IF THERE WAS A RELATED RECALL AND HE HAS NOT RECEIVED A RESPONSE FROM THE DEALER. THE FAILURE MILEAGE WAS 7…
Read full complaint
TL*THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE HEATED SEATS ON THE DRIVER SIDE OF THE VEHICLE CAUGHT FIRE. HE WAS ABLE TO EXTINGUISH THE FIRE. THE DEALER STATED THAT THEY WOULD NOTIFY THE CONTACT IF THERE WAS A RELATED RECALL AND HE HAS NOT RECEIVED A RESPONSE FROM THE DEALER. THE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #10297964
160,000 miles · Nov 4, 2009
Seats
SEAT HEATER REMAINED ON AFTER SWITCHED TO THE OFF POSITION. HEAT INCREASED TO UNCOMFORTABLE LEVEL, IN-DASH SWITCH BECAME TOO HOT TO TOUCH, AND SMELL OF BURNING PLASTIC FILLED COCKPIT (NO SMOKE THOUGH). *TR
NHTSA ODI #10290955
Official recalls
3Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Illustration