NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
507 reportsMileage unknown · Mar 19, 2002
Engine And Engine Cooling
THE ENGINE STARTS TO STALL WHEN YOU ACCELERATE AT HIGHER SPEEDS. EVERY TIME TAKEN TO THE DEALER, HE SAYS THE AIR FILTER IS SOAKED W/WATER. HE HAS NO EXPLAINATION. FINALLY ADMITTED THAT THERE ARE "SEVERAL" CARS THROUGHOUT THE COUNTRY W/THIS PROBLEM. HIS LAST SOLUTION (FROM VW) WAS TO REMOVE THE SNOW GRILL (WHICH MAKES NO SENSE &…
Read full complaint
THE ENGINE STARTS TO STALL WHEN YOU ACCELERATE AT HIGHER SPEEDS. EVERY TIME TAKEN TO THE DEALER, HE SAYS THE AIR FILTER IS SOAKED W/WATER. HE HAS NO EXPLAINATION. FINALLY ADMITTED THAT THERE ARE "SEVERAL" CARS THROUGHOUT THE COUNTRY W/THIS PROBLEM. HIS LAST SOLUTION (FROM VW) WAS TO REMOVE THE SNOW GRILL (WHICH MAKES NO SENSE & DID NOT CORRECT THE PROBLEM). IT IS TERRIFYING TO TRY & PASS A CAR ON A 2 LANE ROAD OR IN THE MIDDLE OF A 5 LANE EXPRESSWAY & HAVE YOUR CAR START TO STALL . THE AIRBAG DEFAULT LIGHT HAS ALSO COME ON TWICE. PLEASE HELP. *AK
NHTSA ODI #759531
Mileage unknown · Mar 18, 2002
Engine And Engine Cooling
EVERY PASSAT OWNER I HAVE TALKED TO (5) INDICATED THIS PART HAD FAILED. RECALL? NO SAFETY DEFECT LISTED. *AK
NHTSA ODI #759498
Mileage unknown · Mar 14, 2002
Suspension
THERE IS A NOISE IN FRONT, UNDERNEATH VEHICLE WHILE WHEELS ARE IN MOTION. DEALERSHIP IS AWARE OF PROBLEM.*AK
NHTSA ODI #8005710
Mileage unknown · Feb 26, 2002
Service Brakes, Hydraulic
WHILE DRIVING, A LOUD GRINDING NOISE WOULD BE COMING FROM THE FRONT WHEELS. DEALER NOTIFIED AND INFORMED CONSUMER THAT FRONT ROTORS AND CALIPERS NEEDED TO BE REPLACED. *AK *JG
NHTSA ODI #8004591
Mileage unknown · Jan 22, 2002
Engine And Engine Cooling
CAR WOULDN'T START, TOWED TO DEALER, WAS TOLD IT WAS A CARBON BUILDUP ON THE VALVES. SOLUTION OIL CHANGE, TUNE UP, CHANGE THERMOSTAT, FUEL CLEANER. COST $946 NOT COVERED UNDER WARANTY. *AK
NHTSA ODI #757181
Mileage unknown · Jan 12, 2002
Engine And Engine CoolingUnknown Or Other
EMISSIONS WORKSHOP LIGHT COMES ON, THEN ENGINE CHECK LAMP SHOWS ON DASH. DEALER REPLACED AIR PUMP, SAID THAT A HOSE WAS LOOSE AND NEVER FOUND THE PROBLEM. VW OF AMERICA WAS CONTACTED ALONG WITH THE CUSTOMER SERVICE REP AT THE DEALER. WE HAD TO TRADE THE CAR BECAUCE THE PROBLEM COULD NOT BE REPAIRED. I HAVE NOT CONTACTED AN A…
Read full complaint
EMISSIONS WORKSHOP LIGHT COMES ON, THEN ENGINE CHECK LAMP SHOWS ON DASH. DEALER REPLACED AIR PUMP, SAID THAT A HOSE WAS LOOSE AND NEVER FOUND THE PROBLEM. VW OF AMERICA WAS CONTACTED ALONG WITH THE CUSTOMER SERVICE REP AT THE DEALER. WE HAD TO TRADE THE CAR BECAUCE THE PROBLEM COULD NOT BE REPAIRED. I HAVE NOT CONTACTED AN ATTORNEY AT THIS TIME. WHY IS VW ALLOWED TO SELL CARS THAT THEY CANNOT REPAIR? I WOULD LIKE TO BE COMPENSATED FOR OUR FINANCIAL LOSS AS WELL AS FOR OUR TIME AND TROUBLE.*AK
NHTSA ODI #756742
Mileage unknown · Jan 7, 2002
Visibility
MY SUNROOF SHATTERED OUTWARD WITH EXPLOSIVE FORCE, NO WARNING, NO COLLISION.*AK
NHTSA ODI #756517
Mileage unknown · Dec 5, 2001
SeatsSuspensionVisibility
SUN ROOF LEAKS - DRAINS CLEANED BY DEALER TWICE - STILL LEAKING. DRIVER'S SEAT BACK MOVES FORWARD WHEN BRAKE APPLIED. DEALER CLAIMS THIS IS NORMAL. SEAT BACK CAN BE MOVED BY HAND. CAR HAS VIBRATION AND STEERING WHEEL SHAKES AT MOST SPEEDS. DEALER CLAIMS TIRES ARE THE PROBLEM. HOWEVER, TIRES HAVE BEEN INSPECTED TWICE (AT MY EXPE…
Read full complaint
SUN ROOF LEAKS - DRAINS CLEANED BY DEALER TWICE - STILL LEAKING. DRIVER'S SEAT BACK MOVES FORWARD WHEN BRAKE APPLIED. DEALER CLAIMS THIS IS NORMAL. SEAT BACK CAN BE MOVED BY HAND. CAR HAS VIBRATION AND STEERING WHEEL SHAKES AT MOST SPEEDS. DEALER CLAIMS TIRES ARE THE PROBLEM. HOWEVER, TIRES HAVE BEEN INSPECTED TWICE (AT MY EXPENSE) BY INDEPENDENT DEALERS WHO STATE TIRES ARE O.K. WHEELS REBALANCED, FRONT END ALIGNED, (ALL AT MY EXPENSE) AND PROPLEM PERSISTS. VW REFUSES TO HELP CLAIMING PROBLEM IS RELATED TO TIRES.*AK
NHTSA ODI #755324
Mileage unknown · Dec 3, 2001
EquipmentPower Train
TIRE JACK IS WEAK. CONSUMER JACKED UP VEHICLE TO CHANGE TIRE, AND JACK BENT/ TWISTED, CAUSING IT TO FALL FROM UNDER VEHICLE.ALSO, AXLE OF VEHICLE FELL TO GROUND. CONTACTED DEALER, AND DEALER URGED CONSUMER TO CALL THE MANUFACTURER'S CUSTOMER SERVICE. MANUFACTURER TOLD CONSUMER TO TAKE JACK TO DEALER FOR INSPECTION. *AK
NHTSA ODI #899786
Mileage unknown · Nov 21, 2001
Engine And Engine Cooling
VEHICLE HAS STALLED NUMEROUS TIMES AT ANY SPEED. VEHICLE TAKEN TO DEALER EVERY TIME VEHICLE STALLED, COULD NOT REMEDY PROBLEM. *AK
NHTSA ODI #899359
NHTSA investigations
7EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration