NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
30 reportsClear category filter45,000 miles · Dec 21, 2020
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE AFTER BEING PARKED OVERNIGHT, HE NOTICED A FUEL ODOR. THE CONTACT STATED THAT THE FUEL TANK WAS HALF EMPTY AFTER BEING REFILLED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC AND WAS INFORMED THAT THE SEAM IN THE F…
Read full complaint
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE AFTER BEING PARKED OVERNIGHT, HE NOTICED A FUEL ODOR. THE CONTACT STATED THAT THE FUEL TANK WAS HALF EMPTY AFTER BEING REFILLED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC AND WAS INFORMED THAT THE SEAM IN THE FUEL TANK WAS FRACTURED WHICH CAUSED THE FUEL LEAK. THE FUEL TANK WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
NHTSA ODI #11384369
49,000 miles · Aug 19, 2016
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT SMELLED FUEL INSIDE AND OUTSIDE THE VEHICLE. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED FUEL LEAKING UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPA…
Read full complaint
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT SMELLED FUEL INSIDE AND OUTSIDE THE VEHICLE. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED FUEL LEAKING UNDER THE REAR PASSENGER SIDE OF THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 08V156000 (FUEL SYSTEM), BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 49,000. UPDATED 11/01/16*LJ
NHTSA ODI #10897203
134,000 miles · Jul 29, 2014
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THERE WAS A FUEL ODOR COMING FROM THE HOOD OF THE VEHICLE. THE CONTACT LIFTED THE HOOD AND NOTICED THAT FUEL WAS LEAKING FROM THE FUEL PIPE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED. THE VIN WAS UNAVAILABLE. …
Read full complaint
TL* THE CONTACT OWNS A 2000 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THERE WAS A FUEL ODOR COMING FROM THE HOOD OF THE VEHICLE. THE CONTACT LIFTED THE HOOD AND NOTICED THAT FUEL WAS LEAKING FROM THE FUEL PIPE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 134,000.
NHTSA ODI #10617171
Mileage unknown · Nov 27, 2011
Electrical SystemFuel System, GasolineFire
THE CAR WAS PARKED. I ATTEMPTED TO START THE ENGINE, BUT IT DID NOT TURN OVER. I TRIED A SECOND TIME AND NOTICED WHITE SMOKE COMING FROM UNDER THE ENGINE HOOD. BY THE TIME I WENT INSIDE TO CALL FOR ROAD SERVICE AND RETURNED TO THE PARKING LOT, THERE WERE FLAMES SHOOTING FROM UNDER THE HOOD. THE CAR WAS DESTROYED. *TR
NHTSA ODI #10437421
106,000 miles · Jul 5, 2011
Fuel System, Gasoline
MAKE:VOLKSWAGEN MODEL: PASSAT YEAR:2000 STREAMING GASOLINE LEAK INBOARD OF THE REAR QUARTER PANEL ON THE PASSENGER SIDE WHEN THE ENGINE STARTS. AFTER OPERATING FOR A TIME (20 MIN OR MORE) THE LEAK STOPS AND DOES NOT REAPPEAR UNTIL THE CAR HAS BEEN SITTING FOR SEVERAL DAYS WITHOUT RUNNING. THIS CONDITION WAS FIRST REPORTED TO V…
Read full complaint
MAKE:VOLKSWAGEN MODEL: PASSAT YEAR:2000 STREAMING GASOLINE LEAK INBOARD OF THE REAR QUARTER PANEL ON THE PASSENGER SIDE WHEN THE ENGINE STARTS. AFTER OPERATING FOR A TIME (20 MIN OR MORE) THE LEAK STOPS AND DOES NOT REAPPEAR UNTIL THE CAR HAS BEEN SITTING FOR SEVERAL DAYS WITHOUT RUNNING. THIS CONDITION WAS FIRST REPORTED TO VW HILEY ABOUT 3 YEARS AGO. THEY CHECKED IT OUT AND COULD FIND NOTHING. I HAD SEEN OCCASIONAL LEAKS SINCE BUT THIS TIME SCARED ME BECAUSE IT WAS SO MUCH THAT MY GAS GAUGE MOVED AS A RESULT. I WAS HEADED TO WORK WHICH IS ABOUT 20 MINUTES AWAY. BY THE TIME I GOT THERE THE LEAK HAD STOPPED. TODAY IS JULY 5TH 2011. IT WAS SITTING SINCE JULY 1ST 2011. *KB
NHTSA ODI #10410581
50,000 miles · Jun 29, 2011
Fuel System, Gasoline
STREAMING GASOLINE LEAK INBOARD OF THE REAR QUARTER PANEL ON THE PASSENGER SIDE WHEN THE ENGINE STARTS. AFTER OPERATING FOR A TIME (20 MIN OR MORE) THE LEAK STOPS AND DOES NOT REAPPEAR UNTIL THE CAR HAS BEEN SITTING FOR SEVERAL DAYS WITHOUT RUNNING. THIS CONDITION HAS BEEN IN EXISTENCE FOR ABOUT FIVE YEARS, BUT NEITHER THE VW…
Read full complaint
STREAMING GASOLINE LEAK INBOARD OF THE REAR QUARTER PANEL ON THE PASSENGER SIDE WHEN THE ENGINE STARTS. AFTER OPERATING FOR A TIME (20 MIN OR MORE) THE LEAK STOPS AND DOES NOT REAPPEAR UNTIL THE CAR HAS BEEN SITTING FOR SEVERAL DAYS WITHOUT RUNNING. THIS CONDITION HAS BEEN IN EXISTENCE FOR ABOUT FIVE YEARS, BUT NEITHER THE VW DEALER WHERE I BOUGHT THE CAR, NOR AN INDEPENDENT GARAGE WAS ABLE TO FIND IT (BY THE TIME I GOT IT INTO THE SHOP, THE LEAK WAS GONE AND THE GAS HAD EVAPORATED). IT HAS GRADUALLY WORSENED, THOUGH, AND LAST WEEK I TOOK IT TO THE NEAREST VW DEALER. WHEN THEY DETECTED THE STRONG ODOR OF GAS, THEY PARKED IT IN AN ISOLATED AREA. THE NEXT DAY THEY CALLED AND TOLD ME THAT THE "ROLLOVER" VALVE WAS DEFECTIVE AND THAT THE CAR NEEDED A NEW GAS TANK. IT IS CURRENTLY IN THE SHOP AT DREW VOLKSWAGEN IN LA MESA, CA, AWAITING PARTS. WHEN IT OCCURS, THIS IS A VERY SUBSTANTIAL LEAK WITH GAS STREAMING ONTO THE GROUND.
NHTSA ODI #10409956
133,602 miles · Sep 22, 2010
Fuel System, Gasoline
GASOLINE IS LEAKING FROM UNDER THE PASSENGER REAR SIDE OF MY 2000 VOLKSWAGEN PASSAT GLS V6; THE GASOLINE IS DRIPPING FROM THE HEAT SHIELD IN FRONT OF THE REAR TIRE. NOTE THAT THE FUEL DOOR / FILLER NECK IS ON THAT SIDE. SEE THE EXCERPT (FOLLOWING) FROM HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2000/VOLKSWAGEN/PASSAT/FUEL+SYSTEM …
Read full complaint
GASOLINE IS LEAKING FROM UNDER THE PASSENGER REAR SIDE OF MY 2000 VOLKSWAGEN PASSAT GLS V6; THE GASOLINE IS DRIPPING FROM THE HEAT SHIELD IN FRONT OF THE REAR TIRE. NOTE THAT THE FUEL DOOR / FILLER NECK IS ON THAT SIDE. SEE THE EXCERPT (FOLLOWING) FROM HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2000/VOLKSWAGEN/PASSAT/FUEL+SYSTEM COMPLAINT NUMBER: 10280791: SIMILAR TO OTHER REPORTS, THERE IS APPARENTLY A COMMON DEFECT WITH OLDER VW PASSATS (MINE IS A 2000) FUEL LINES LEAKING GAS WHEN PRESSURIZED BY THE FUEL PUMP. THE GAS LEAK OCCURS IN THE RUBBER FUEL LINE NEAR THE GAS TANK AND FILTER. THE LEAK WAS VISIBLE IN FRONT OF THE REAR WHEEL ON THE PASSENGER SIDE. MECHANICS, INCLUDING THE DEALER HAVE TROUBLE LOCATING THE LEAK SINCE IT APPEARS TO BE INTERMITTENT AND ONLY WHEN THE CAR IS FIRST STARTED FOR A MINUTE OR SO. THE LEAK IS SIGNIFICANT AND TYPICALLY INVOLVES ABOUT A CUP OF GAS. IT IS A FIRE HAZARD THAT SHOULD BE PART OF A RECALL, BUT APPARENTLY IS NOT. THIS PROBLEM SEEMS TO BE RELATED TO THE FOLLOWING RECALL FOR VOLKSWAGENS EQUIPPED WITH THE 1.8T (TURBO) MOTOR OR 4MOTION (AWD): 2000 VOLKSWAGEN PASSAT RECALL ID FROM NHTSA: 08V156000. *TR
NHTSA ODI #10356922
68,000 miles · Jun 8, 2010
Fuel System, Gasoline
PREVIOUSLY REPAIRED FUEL LEAK HAS RECURRED, ~18 MONTHS LATER. LEAK CAN BE SEEN WHEN VEHICLE HAS BEEN SITTING FOR SEVERAL HOURS AND IS THEN BACKED OUT OF GARAGE DOWN INCLINED DRIVEWAY. FUEL IS LEAKING FROM PASSENGER REAR WHEEL AREA. *TR
NHTSA ODI #10335220
90,000 miles · Aug 18, 2009
Fuel System, Gasoline
SIMILAR TO OTHER REPORTS, THERE IS APPARENTLY A COMMON DEFECT WITH OLDER VW PASSATS (MINE IS A 2000) FUEL LINES LEAKING GAS WHEN PRESSURIZED BY THE FUEL PUMP. THE GAS LEAK OCCURS IN THE RUBBER FUEL LINE NEAR THE GAS TANK AND FILTER. THE LEAK WAS VISIBLE IN FRONT OF THE REAR WHEEL ON THE PASSENGER SIDE. MECHANICS, INCLUDING THE…
Read full complaint
SIMILAR TO OTHER REPORTS, THERE IS APPARENTLY A COMMON DEFECT WITH OLDER VW PASSATS (MINE IS A 2000) FUEL LINES LEAKING GAS WHEN PRESSURIZED BY THE FUEL PUMP. THE GAS LEAK OCCURS IN THE RUBBER FUEL LINE NEAR THE GAS TANK AND FILTER. THE LEAK WAS VISIBLE IN FRONT OF THE REAR WHEEL ON THE PASSENGER SIDE. MECHANICS, INCLUDING THE DEALER HAVE TROUBLE LOCATING THE LEAK SINCE IT APPEARS TO BE INTERMITTENT AND ONLY WHEN THE CAR IS FIRST STARTED FOR A MINUTE OR SO. THE LEAK IS SIGNIFICANT AND TYPICALLY INVOLVES ABOUT A CUP OF GAS. IT IS A FIRE HAZARD THAT SHOULD BE PART OF A RECALL, BUT APPARENTLY IS NOT SINCE THE DEALER CHARGED ME FOR THE DIAGNOSIS AND REPAIR. *TR
NHTSA ODI #10280791
120,000 miles · Jul 31, 2009
Fuel System, Gasoline
2000 VW PASSAT 1.8T HAD FUEL LEAK. THE CAR HAD A FUEL LEAK IN THE GARAGE WHICH COULD HAVE CAUSED AFIRE. THIS IS A SERIOUS PROBLEM. I DID SOME READING AND THOUGHT IT WOULD BE COVERED BY A RECALL. HOWEVER, THE VW DEALER CHARLES MAUND VOLKSWAGAN INDICATED THAT IT WAS NOT COVERED BY ANY RECALL. *TR
NHTSA ODI #10278967
NHTSA investigations
7EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration