MY WIFE AND I WERE DRIVING ON THE HIGHWAY GOING ABOUT 70 MPH. I STARTED TO HEAR A STRANGE NOISE AND BEGAN TO PULL OVER. AS I SWITCHED LANES THERE WAS A LOUD EXPLOSION AND THE FRONT RIGHT PORTION OF THE CAR WAS SCRAPING ALONG THE GROUND. I GOT THE CAR TO SLOW DOWN AND PULLED OVER. WHEN WE GOT OUT TO LOOK WHAT WE SAW AMAZED US. TH…
Read full complaint
MY WIFE AND I WERE DRIVING ON THE HIGHWAY GOING ABOUT 70 MPH. I STARTED TO HEAR A STRANGE NOISE AND BEGAN TO PULL OVER. AS I SWITCHED LANES THERE WAS A LOUD EXPLOSION AND THE FRONT RIGHT PORTION OF THE CAR WAS SCRAPING ALONG THE GROUND. I GOT THE CAR TO SLOW DOWN AND PULLED OVER. WHEN WE GOT OUT TO LOOK WHAT WE SAW AMAZED US. THE ENTIRE STEEL BELTED RADIAL HAD BLOWN OUT OF ONE SECTION OF THE TIRE. IT RIPPED THROUGH ALL THE LAYERS OF THE TIRE ALL AT ONCE. I FEEL VERY UNEASY ABOUT THE OTHER 3 THAT REMAIN. *NM
NHTSA ODI #10157529
Mileage unknown · Jul 24, 2001
Service Brakes, HydraulicTires
AT 30000 MILES STEERING WHEEL SHAKES WHEN APPLYING BRAKES.ASKED DEALER TO CHECK ON ALIGHMENT PROBLEMS. DEALER NO ALIGNMENT NEEDED, BUT BRAKES WERE WORN DOWN 50% & ALSO NEEDED NEW ROTORS. DEALER INSISTED CAR OKAY TO DRIVE AND ADVISED TO COME BACK. 35000 SERVICE TO HAVE NEW BRAKES AND ROTORS INSTALLED, APROX. $600. AFTER…
Read full complaint
AT 30000 MILES STEERING WHEEL SHAKES WHEN APPLYING BRAKES.ASKED DEALER TO CHECK ON ALIGHMENT PROBLEMS. DEALER NO ALIGNMENT NEEDED, BUT BRAKES WERE WORN DOWN 50% & ALSO NEEDED NEW ROTORS. DEALER INSISTED CAR OKAY TO DRIVE AND ADVISED TO COME BACK. 35000 SERVICE TO HAVE NEW BRAKES AND ROTORS INSTALLED, APROX. $600. AFTER SERVICE, I DROVE HOME ABOUT 50 MILES AND PROBLEM GOT WORSE, INCLUDING A LOUD RUMBLING NOISE. I CALLED DEALER, AND THEY REFERRED ME TO A DEALER CLOSER TO MY HOME, 3 DAYS AND 300 MILES LATER, 2ND DEALER ASKED HOW MANY TIMES I HAD CHANGED THE BRAKES, BECAUSE I NOW, NEEDED ROTORS, AND WORSE, ALL MY TIRES WERE "CUPPED. " I ALSO NEEDED A WHOLE NEW SET OF TIRES...I ASKED 2ND DEALER IF IT WAS SAFE TO DRIVE MY CAR. THEY SAID IT WAS OK TO DRIVE, BUT RECOMMENDED CHANGING BRAKES, ROTORS AND TIRES @ A COST OF $1,100. DEALER ALSO EXPLAINED THAT THE LACK OF ROTATING A BALANCING TIRES COULD HAVE CONTRIBUTED TO THE UNEVEN WEAR (AKA: CUPPED TIRES). I WAS ALSO TOLD THAT THE LOUD RUMBLING NOISE, WOULD EVENTUALLY GO AWAY, SINCE THE TIRES HAD BEEN ROTATED. THE 2ND DEALER INVOICED THE 1ST DEALER FOR THIS SERVICE CHARGE. 3 DAYS LATER, I WENT TO GOODYEAR TIRE SHOP (FOR 3RD OPINON) BECAUSE I THOUGHT THE TIRES MAY BE DEFECTIVE. GOODYEAR ADVISED ME THAT CUPPED TIRES RESULT FROM UNEVEN WEAR (USUALLY RECOMMEND ROTATING & BALANCING TIRES EVERY 10K MI.), IF NOT, PROBLEMS W/BRAKES & ROTORS. GOODYEAR COULDN'T DETERMINE WHY THE PROBLEM OCCURRED @ ONLY 30K MI. SUCH A PROBLEM COULD OCCUR AT ABOUT 60K MILES, BUT NOT ROTORS. GOODYEAR BALANCED & ROTATED MY TIRES & ALSO DISCOVERED THAT THE DRIVER'S SIDE TIRE WAS RUBBING AGAINST THE WHEELWELL, CAUSING A LARGE GASH IN THE WHEELWELL. IN THE INTEREST OF CONSUMER PROTECTION, I SEEK YOUR PROFESSIONAL ASSISTANCE IN BRINGING A POSITIVE RESOLVE TO THIS MATTER. MY CAR HAS SPENT A LOT OF TIME @ DEALER SERVICE SHOP. VOLKSWAGEN MUST BE HELD ACCOUNTABLE FOR BAD CRAFTSMANSHIP & POOR SERVICE ADVICE. PLEASE HELP!
NHTSA ODI #749031
Mileage unknown · Nov 15, 2000
Electrical SystemEngine And Engine CoolingExterior Lighting
OIL LIGHT CAME ON 2000 MILES AFTER OILCHANGE/BURNING OR LEAKING EXCESSIVE OIL,AND OIL LEVEL LOW. PASSENGER'S WINDOW MOTOR STOPPED WORKING, RESULTING IN WINDOW FALLING DOWN,. ALSO, ENGINE REVVED HIGH/ LIGHT SWITCH ON INTERIOR LIGHT FELL OFF/ FRONT RIGHT MICHELIN TIRE BLEWOUT, AND HAD TO REPLACE BATTERY. DEALER KEPT REPAIRING PR…
Read full complaint
OIL LIGHT CAME ON 2000 MILES AFTER OILCHANGE/BURNING OR LEAKING EXCESSIVE OIL,AND OIL LEVEL LOW. PASSENGER'S WINDOW MOTOR STOPPED WORKING, RESULTING IN WINDOW FALLING DOWN,. ALSO, ENGINE REVVED HIGH/ LIGHT SWITCH ON INTERIOR LIGHT FELL OFF/ FRONT RIGHT MICHELIN TIRE BLEWOUT, AND HAD TO REPLACE BATTERY. DEALER KEPT REPAIRING PROBLEMS. CONSUMER CONTACTED VW CO, AND WAS TOLD THEY WOULD GET BACK TO HER, BUT NEVER DID. CONSUMER FELT VEHICLE WAS A LEMON. PLEASE ADD ADDITIONAL INFORMATION. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
Consequence & remedy
Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALY UNDER INFLATED TIRES PUTS THE CONSUMER AT A RISK FOR A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES DO NOT COMPLY WITH THE HEAD INJURY CRITERION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE UPPER RETAINER CLIP NEAR THE BP1 IMPACT LOCATION IS DESIGNED TO BREAK WHEN IMPACTED BY THE HEAD FORM. IN SOME CASES, THE MATERIAL OF THE TRIM PART MAY BE MORE IMPACT RESISTANT AS A RESULT OF VARIATIONS IN THE MOLDING PROCESS.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE CLIP FROM BREAKING ON IMPACT AND RESULT IN LESS DEFORMATION IN THE IMPACTED AREA AND A HIGHER DECLERATION OF THE HEAD FORM, INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REMOVE THE TRIM COVER FROM EACH OF THE B PILLARS AND INSTALL A NEW COVER.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99007 · Passenger Compartment Fire
Opened Jan 29, 1999 · Closed Feb 8, 1999
Status: closed (inferred from source dates) · Unknown Or Other
IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION.A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.
1999 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration