IllustrationWOULD LIKE TO KNOW IF THERE IS ANY RECALLS ON MY JETTA. I CHECK ENGINE LIGHT COMES ON. I TOOK IT TO 4 REPAIR SHOP AND NO ONE COULD FIND WHATS WRONG WITH IT. I'VE PAID OVER 1200 ON OTHER REPAIRS. WHAT CAN I DO . *TR THANKS CHRISTINA
1999 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 1999 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
1325–50K
2650–75K
2175–100K
18100–150K
4150K+
88 reports with mileage · 261 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports9 fire reports21 injury reports
Fuel System, Gasoline complaints
11 reports1999.5 VOLKSWAGEN JETTA GLS VR6, ALWAYS GETTING DTC CODES OF P1117, P0140, P1198, P1472, P1435, P0102, P0343, P1421.. THAT ALWAYS SAYS ABOUT OPEN OR SHORT CIRCUIT CONDITIONS AND POOR ELECTRICAL CONNECTIONS, AND SHORT TO GROUNDS FOR ELECTRICAL, WHICH IS ALL ELECTRICAL PROBLEMS, IF YOU SEARCH ONLINE THEM CODES YOU WILL SEE NUMER…
Read full complaint
1999.5 VOLKSWAGEN JETTA GLS VR6, ALWAYS GETTING DTC CODES OF P1117, P0140, P1198, P1472, P1435, P0102, P0343, P1421.. THAT ALWAYS SAYS ABOUT OPEN OR SHORT CIRCUIT CONDITIONS AND POOR ELECTRICAL CONNECTIONS, AND SHORT TO GROUNDS FOR ELECTRICAL, WHICH IS ALL ELECTRICAL PROBLEMS, IF YOU SEARCH ONLINE THEM CODES YOU WILL SEE NUMEROUS PEOPLE WITH THE SAME PROBLEMS, AND AS WELL AS ALOT OF US HAVE TO BUY THE PARTS THAT IS LISTED AND PROBLEMS STILL AREN'T FIXED, WHICH TELLS US ITS AN ELECTRICAL ISSUE, NOT ISSUES WITH THE PARTS, WHICH CAUSES OUR #43 FUSE BLOW ALOT, AND ALOT OF HESITATION AND STALLING, I CANT EVEN TURN AROUND A CORNER OR TO GET OFF THE HIGHWAY WITHOUT STALLING, PLEASE FIX THESE PROBLEMS, ITS HAPPENING TO WAY TO MANY OF US AND IT IS ALSO AN SAFETY ISSUE. *TT
COMPLAINT REGARDING RECALL WORK APPOINTMENT. ***NO ANSWER REQUIRED***. *MR THE CONSUMER WAS TOLD THE WORK WOULD BE COMPLETED, HOWEVER THE DEALER CALLED THE CONSUMER AND TOLD HIM THERE WERE NO MORE PARTS AVAILABLE. THE CIGARETTE LIGHTER DID NOT WORK. *JB
MAJOR GAS LEAK ON RECENTLY PURCHASED (USED) 1999 VOLKSWAGEN JETTA, ALSO NEEDED REPAIR TO LEFT FRONT SHOCK TOWER, CAUSES AND REASONS FOR NEED OF REPAIR UNKNOWN. *NLM
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE THE ELECTRICAL WINDOWS. WHICH IT CAUSES THE WINDOWS NOT TO OPEN OR CLOSE. DEALER WAS CONTACTED AND STATED THAT IT WAS DESIGN PROBLEM. TS
INTAKE MANIFOLD PLUGGS UP WITH A BUILD UP OF CARBON AND OIL SLUDGE TO THE POINT WHERE CAR CANNOT SAFELY REACH FREEWAY SPEEDS TO MERGE ONTO FREEWAY. VW HAS PAID FOR THE REPAIR ONCE AT 40000 MILES AFTER I COMPLAINED OF THE 1600.00 REPAIR BILL. SINCE THEN I HAVE HAD TO HAVE IT REPAIRED 3 MORE TIMES AT MY EXSPENCE. IT IS NOW NEEDS T…
Read full complaint
INTAKE MANIFOLD PLUGGS UP WITH A BUILD UP OF CARBON AND OIL SLUDGE TO THE POINT WHERE CAR CANNOT SAFELY REACH FREEWAY SPEEDS TO MERGE ONTO FREEWAY. VW HAS PAID FOR THE REPAIR ONCE AT 40000 MILES AFTER I COMPLAINED OF THE 1600.00 REPAIR BILL. SINCE THEN I HAVE HAD TO HAVE IT REPAIRED 3 MORE TIMES AT MY EXSPENCE. IT IS NOW NEEDS TO BE DONE AGAIN AS I CANNOT REACH SAFE SPEEDS TO SAFLY MERGE ONTO FREEWAYS AND AM SCARED OF BEING HIT FROM REAR. THE PROBLEMS IS FROM EGR GASES AND CCV OIL MIST MIXING AT THE BEGINNING OF THE INTAKE MANIFOLD WHICH CREATES SLUDGE THAT BUILDS UP AND PLUGS UP THE AIR FLOW TO THE CYLS.*AK
ENGINE TRANSMISSION LIGHT FAILED AFTER 3 MONTHS, BOTH WINDOWS HAVE FALLEN DOWN INTO DOOR, FRONT BUMPER HAS BEEN TORN OFF, ANTENA AND OTHER PLASTIC OBJECTS AROUND CAR HAVE FALLEN OFF,ABS SYSTEM LIGHT IS ON AGAIN, COVER FOR GAS TANK WILL NOT OPEN (I HAD TO PRY IT OPEN), CUP HOLDERS AND MIRROR COVERS HAVE BROKEN, INSIDE OF CAR STA…
Read full complaint
ENGINE TRANSMISSION LIGHT FAILED AFTER 3 MONTHS, BOTH WINDOWS HAVE FALLEN DOWN INTO DOOR, FRONT BUMPER HAS BEEN TORN OFF, ANTENA AND OTHER PLASTIC OBJECTS AROUND CAR HAVE FALLEN OFF,ABS SYSTEM LIGHT IS ON AGAIN, COVER FOR GAS TANK WILL NOT OPEN (I HAD TO PRY IT OPEN), CUP HOLDERS AND MIRROR COVERS HAVE BROKEN, INSIDE OF CAR STARTED TO BUBBLE AFTER 6 MONTHS, BECAUSE OF THE PLASTIC. ALL THE SERVICE DEPARTMENT IN SAN ANTONIO COULD SAY WAS THAT I DID NOT KNOW HOW TO MANAGE CAR. I DIDN'T KNOW I HAD TO TAKE A CLASS IN OPENING THE GAS COVER. ODDLY ENOUGH, MOST OF THESE THINGS STARTED TO BREAK AFTER MY TWO YEAR WARRANTY EXPIRED. ALL THEY HAD TO SAY WAS THAT "WHEN IT RAINS IT POURS". I WOULD NEVER RECOMMEND THIS CAR TO ANYONE
VEHICLE WOULD RUN OUT OF FUEL, WHILE GAS GAUGE WOULD REGISTER A 1/4 TANK OF FUEL LEFT. PROBLEM WAS DUE TO A DEFECT IN FUEL SENDING UNIT. DEALER WAS NOTIFIED, AND REPAIRS WERE MADE AT CONSUMER'S COST. ASKING NHTSA TO LOOK INTO THIS PROBLEM. *AK CONSUMER IS REQUESTING REIMBURSEMENT FOR REPLACEMENT COSTS OF THE SENDING UNIT. …
Read full complaint
VEHICLE WOULD RUN OUT OF FUEL, WHILE GAS GAUGE WOULD REGISTER A 1/4 TANK OF FUEL LEFT. PROBLEM WAS DUE TO A DEFECT IN FUEL SENDING UNIT. DEALER WAS NOTIFIED, AND REPAIRS WERE MADE AT CONSUMER'S COST. ASKING NHTSA TO LOOK INTO THIS PROBLEM. *AK CONSUMER IS REQUESTING REIMBURSEMENT FOR REPLACEMENT COSTS OF THE SENDING UNIT. *SLC
THIS IS NOT AN ISOLATED PROBLEM. THE RELAY 109 HAS BEEN BROUGHT TO VW'S ATTENTION SEVERAL TIMES. THEY HAVE ISSUED A TECH TIP ON THEIR WEBSITE TO DEALERS. MY DEALER REPLACED THE WRONG PART AND CHARGED ME FOR IT. NOW I HAVE TO WAIT FOR THEM TO TEST IT BEFORE THEY REFUND MY MONEY. THIS HAPPENED TO ME SEVERAL TIMES ON THE HIGHWAY, I…
Read full complaint
THIS IS NOT AN ISOLATED PROBLEM. THE RELAY 109 HAS BEEN BROUGHT TO VW'S ATTENTION SEVERAL TIMES. THEY HAVE ISSUED A TECH TIP ON THEIR WEBSITE TO DEALERS. MY DEALER REPLACED THE WRONG PART AND CHARGED ME FOR IT. NOW I HAVE TO WAIT FOR THEM TO TEST IT BEFORE THEY REFUND MY MONEY. THIS HAPPENED TO ME SEVERAL TIMES ON THE HIGHWAY, IN TRAFFIC. WHEN YOU ARE STALLED IN THE MIDDLE LANE ON A ROAD AND YOU SEE CARS COMING YOU HOPE THEY SEE YOU AND DON'T RUN THROUGH THE BACK OF YOU. THIS IS A SERIOUS PROBLEM AND VW IS IGNORING IT. IN REGARDS TO THE FUEL INJECTION, THEY ARE GOING THROUGH THESE TOO. THE TDI ENGINE IS GETTING CLOGGED (THEY DON'T KOW WHY) AND CAUSE THE FUEL INJECTOR TO FAIL. MY DEALERSHIP HAS HAD MINE FOR A WEEK. PART IS ON BACK ORDER. VW IS NOT RESPONSIVE.*AK
FUEL IS LEAKING INTO THE PASSENGER COMPARTMENT. THE DEALER HAS ISNPECTED THE VEHICLE . MANUFACTURER HAS BEEN NOTIFIED. *AK
Official recalls
606V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V096000 · Exterior Lighting:brake Lights:switch
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
03V156000 · Equipment:other:labels
Apr 23, 2003
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
Consequence & remedy
Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALY UNDER INFLATED TIRES PUTS THE CONSUMER AT A RISK FOR A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.
02V026000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
99V251000 · Structure:frame And Members
Sep 17, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES DO NOT COMPLY WITH THE HEAD INJURY CRITERION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE UPPER RETAINER CLIP NEAR THE BP1 IMPACT LOCATION IS DESIGNED TO BREAK WHEN IMPACTED BY THE HEAD FORM. IN SOME CASES, THE MATERIAL OF THE TRIM PART MAY BE MORE IMPACT RESISTANT AS A RESULT OF VARIATIONS IN THE MOLDING PROCESS.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE CLIP FROM BREAKING ON IMPACT AND RESULT IN LESS DEFORMATION IN THE IMPACTED AREA AND A HIGHER DECLERATION OF THE HEAD FORM, INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REMOVE THE TRIM COVER FROM EACH OF THE B PILLARS AND INSTALL A NEW COVER.
99V022000 · Structure:frame And Members
Feb 5, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99007 · Passenger Compartment Fire
Opened Jan 29, 1999 · Closed Feb 8, 1999
Status: closed (inferred from source dates) · Unknown Or Other
IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION.A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.