NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
44 reportsClear category filter115,144 miles · Apr 2, 2013
Air BagsElectrical SystemFire
TL* THE CONTACT OWNS A 1999 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SMOKE BEGAN TO FILL THE CABIN OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE AND SAW THAT SMOKE WAS BELLOWING FROM BENEATH THE STEERING COLUMN. THE SMOKE DISAPPEARED AFTER SOME TIME. THE CONTACT THEN ATTEMPTED TO RESTART THE VEHICLE AND …
Read full complaint
TL* THE CONTACT OWNS A 1999 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SMOKE BEGAN TO FILL THE CABIN OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE AND SAW THAT SMOKE WAS BELLOWING FROM BENEATH THE STEERING COLUMN. THE SMOKE DISAPPEARED AFTER SOME TIME. THE CONTACT THEN ATTEMPTED TO RESTART THE VEHICLE AND THE AIR BAG DEPLOYED INDEPENDENTLY. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION AND THE CONTACT WAS AWAITING THE RESULTS. THE FAILURE AND CURRENT MILEAGE WAS 115,144.
NHTSA ODI #10505399
87,000 miles · Aug 31, 2012
Electrical SystemEngineVehicle Speed Control
THE VW VEHICLE IS PROGRAMMED TO CRIPPLE THE ENGINE PERFORMANCE AND SPEED IN CASE OF AN EPC FAULT. ANY FAULT CAUSING A RICH OR LEAN CONDITION WILL CAUSE THIS "LIMP MODE". THIS IS A SAFETY ISSUE ESPECIALLY PEOPLE ON THE HIGHWAY GOING 65-75MPH AND A 80,000 POUND TRACTOR TRAILER BEHIND THEM AS ONE PERSON EXPERIENCED. THERE AR…
Read full complaint
THE VW VEHICLE IS PROGRAMMED TO CRIPPLE THE ENGINE PERFORMANCE AND SPEED IN CASE OF AN EPC FAULT. ANY FAULT CAUSING A RICH OR LEAN CONDITION WILL CAUSE THIS "LIMP MODE". THIS IS A SAFETY ISSUE ESPECIALLY PEOPLE ON THE HIGHWAY GOING 65-75MPH AND A 80,000 POUND TRACTOR TRAILER BEHIND THEM AS ONE PERSON EXPERIENCED. THERE ARE TOO MANY NON-VITAL COMPONENT FAILURES TO LIST THAT CAN CAUSE THIS FAULT. I REFER TO NON-VITAL MEANING THE COMPONENT FAILURE WILL NOT HARM THE DRIVER OF THE CAR. THE FAULT LIGHT INDICATION ISN'T ENOUGH? NOW THEY HAVE THE RIGHT TO FORCE YOU INTO A REPAIR SHOP AND BUY MORE VW PARTS. I FEEL THAT THIS IS A MONEY MAKING SCAM ENDANGERING OUR LIVES. WE DO NOT PUT A HALT ON THIS NOW- SOON ANY FAULT WILL CRIPPLE OUR CARS. IT'S NOT JUST VW (HYUNDAI DID A SIMILAR "LIMP MODE"). *TR
NHTSA ODI #10473134
160,000 miles · Jan 20, 2012
Electrical SystemElectronic Stability Control (esc)Fuel System, Gasoline
1999.5 VOLKSWAGEN JETTA GLS VR6, ALWAYS GETTING DTC CODES OF P1117, P0140, P1198, P1472, P1435, P0102, P0343, P1421.. THAT ALWAYS SAYS ABOUT OPEN OR SHORT CIRCUIT CONDITIONS AND POOR ELECTRICAL CONNECTIONS, AND SHORT TO GROUNDS FOR ELECTRICAL, WHICH IS ALL ELECTRICAL PROBLEMS, IF YOU SEARCH ONLINE THEM CODES YOU WILL SEE NUMER…
Read full complaint
1999.5 VOLKSWAGEN JETTA GLS VR6, ALWAYS GETTING DTC CODES OF P1117, P0140, P1198, P1472, P1435, P0102, P0343, P1421.. THAT ALWAYS SAYS ABOUT OPEN OR SHORT CIRCUIT CONDITIONS AND POOR ELECTRICAL CONNECTIONS, AND SHORT TO GROUNDS FOR ELECTRICAL, WHICH IS ALL ELECTRICAL PROBLEMS, IF YOU SEARCH ONLINE THEM CODES YOU WILL SEE NUMEROUS PEOPLE WITH THE SAME PROBLEMS, AND AS WELL AS ALOT OF US HAVE TO BUY THE PARTS THAT IS LISTED AND PROBLEMS STILL AREN'T FIXED, WHICH TELLS US ITS AN ELECTRICAL ISSUE, NOT ISSUES WITH THE PARTS, WHICH CAUSES OUR #43 FUSE BLOW ALOT, AND ALOT OF HESITATION AND STALLING, I CANT EVEN TURN AROUND A CORNER OR TO GET OFF THE HIGHWAY WITHOUT STALLING, PLEASE FIX THESE PROBLEMS, ITS HAPPENING TO WAY TO MANY OF US AND IT IS ALSO AN SAFETY ISSUE. *TT
NHTSA ODI #10444637
123,000 miles · Jul 23, 2007
Electrical System
TL*THE CONTACT OWNS A 1999 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE WIRING HARNESS SET OVERHEATED, MELTED 10-15 WIRES TOGETHER, AND SHORTED OUT THE ELECTRICAL SYSTEM. HE PAID OVER $3,000 TO REPLACE THE WIRING HARNESS SET. THE CONTACT HAS PICTURES. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 123…
Read full complaint
TL*THE CONTACT OWNS A 1999 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE WIRING HARNESS SET OVERHEATED, MELTED 10-15 WIRES TOGETHER, AND SHORTED OUT THE ELECTRICAL SYSTEM. HE PAID OVER $3,000 TO REPLACE THE WIRING HARNESS SET. THE CONTACT HAS PICTURES. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 123,000.
NHTSA ODI #10197215
Mileage unknown · Jul 27, 2005
Electrical System
1999 VOLKSWAGEN DEVELOPED A MAJOR PROBLEM WITH WIRING AND ELECTRICAL FAILURE.***NO ANSWER REQUIRED***.*MR THE CONSUMER HAD DIFFICULTY STARTING THE VEHICLE. ONCE THE VEHICLE WAS STARTED SMOKE BEGAN TO EMIT FROM THE VEHICLE. UPON INSPECTING THE VEHICLE, THE CONSUMER WAS TOLD THE STARTED SOLENOID SHORTED OUT AND BURNED THE MAIN …
Read full complaint
1999 VOLKSWAGEN DEVELOPED A MAJOR PROBLEM WITH WIRING AND ELECTRICAL FAILURE.***NO ANSWER REQUIRED***.*MR THE CONSUMER HAD DIFFICULTY STARTING THE VEHICLE. ONCE THE VEHICLE WAS STARTED SMOKE BEGAN TO EMIT FROM THE VEHICLE. UPON INSPECTING THE VEHICLE, THE CONSUMER WAS TOLD THE STARTED SOLENOID SHORTED OUT AND BURNED THE MAIN POWER WIRES FROM THE STARTED ALL THE WAY THROUGH THE COMPLETE MAIN WIRING HARNESS AS WELL AS THE ENGINE MANAGEMENT AND FUEL INJECTOR HARNESS AND MELTED THE IGNITION SWITCH. THE VEHICLE SHOWED SMOKE DAMAGE. *JB
NHTSA ODI #10131294
Mileage unknown · Jan 5, 2005
Electrical System
THE SPEEDOMETER, ODOMETER AND TACHOMETER HAD BECOME INOPERATIVE. *SC THE CONSUMER WAS REFUSED SERVICE BECAUSE THE VEHICLE WAS OUT OF WARRANTY. *TC
NHTSA ODI #10109156
Mileage unknown · Sep 24, 2004
Electrical System
HAZARDS WILL CEASE TO FLASH AFTER BEING ON FOR APPROXIMATELY A MINUTE. MUST TURN OFF THEN ON AGAIN, BUT STILL STOPS WORKING. I HAVE NOT REPAIRED THE PROBLEM, YET.*AK
NHTSA ODI #10093150
Mileage unknown · Sep 13, 2004
Electrical SystemEngine And Engine CoolingStructure
UPON STARTING VEHICLE THE CONSUMER NOTICED THAT THE ENGINE RAN FOR A FEW SECONDS THEN STALLED. *AK THE CONSUMER WAS TOLD THAT NOTHING WAS WRONG WITH THE VEHICLE. THE PROBLEM WAS ONGOING. A "TOO RICH CODE," AND THE PURGE VALVE WAS REPLACED. THE REPAIR ATTEMPTS FOR THE VACUUM LEAKS, OXYGEN SENSORS, THE RICH RUNNING OF THE …
Read full complaint
UPON STARTING VEHICLE THE CONSUMER NOTICED THAT THE ENGINE RAN FOR A FEW SECONDS THEN STALLED. *AK THE CONSUMER WAS TOLD THAT NOTHING WAS WRONG WITH THE VEHICLE. THE PROBLEM WAS ONGOING. A "TOO RICH CODE," AND THE PURGE VALVE WAS REPLACED. THE REPAIR ATTEMPTS FOR THE VACUUM LEAKS, OXYGEN SENSORS, THE RICH RUNNING OF THE ENGINE, MASS AIR FLOW SENSOR AND CONNECTOR. THE CONSUMER WAS INFORMED THAT THE PART WAS OUT OF STOCK. THERE WAS A VACUUM LEAK AND THE INTAKE BOOT HAD COME OFF, THE DOOR HINGES WERE LOOSE, AND NOISE HAD COME FROM THE STARTER MOTOR DUE TO AN INTERNAL SHORT. *SC
NHTSA ODI #10081601
600,450 miles · Aug 27, 2004
Electrical System
BATTERY EXPLOSION. *AK
NHTSA ODI #10088667
58,000 miles · Aug 3, 2004
Electrical System
WHILE DRIVING AT ANY SPEED VEHICLE SHUT DOWN. *AK
NHTSA ODI #10087104
Official recalls
6May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Apr 23, 2003
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
Consequence & remedy
Consequence: UNDER INFLATED TIRES CAN AFFECT VEHICLE HANDLING, AND DRIVING WITH SUBSTANTIALY UNDER INFLATED TIRES PUTS THE CONSUMER AT A RISK FOR A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS, OR A DEALER CAN INSTALL THE LABEL IF THE OWNER WISHES. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-893-5298.
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Sep 17, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES DO NOT COMPLY WITH THE HEAD INJURY CRITERION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE UPPER RETAINER CLIP NEAR THE BP1 IMPACT LOCATION IS DESIGNED TO BREAK WHEN IMPACTED BY THE HEAD FORM. IN SOME CASES, THE MATERIAL OF THE TRIM PART MAY BE MORE IMPACT RESISTANT AS A RESULT OF VARIATIONS IN THE MOLDING PROCESS.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE CLIP FROM BREAKING ON IMPACT AND RESULT IN LESS DEFORMATION IN THE IMPACTED AREA AND A HIGHER DECLERATION OF THE HEAD FORM, INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REMOVE THE TRIM COVER FROM EACH OF THE B PILLARS AND INSTALL A NEW COVER.
Feb 5, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SOUND ABSORBING MAT ATTACHED TO THE INSIDE OF THE B-PILLAR SIDE TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED. SURFACE AND EDGES OF THE MAT COULD HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. IT COULD IGNITE WHEN EXPOSED TO THE EXHAUST GAS OF THE SEAT BELT PRE-TENSIONER IGNITER IN THE EVENT OF A SEVERE FRONT OR SIDE COLLISION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE MATTING MATERIALS FROM INSIDE THE B-PILLAR ON BOTH SIDES OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99007 · Passenger Compartment Fire
Opened Jan 29, 1999 · Closed Feb 8, 1999
Status: closed (inferred from source dates) · Unknown Or Other
IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION.A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.
Illustration