FOLLOWING APPROXIMATELY TWO DOZEN VISITS TO THE DEALERSHIP FOR A CORRECTION, NOTHING WAS FOUND. AT ONE POINT AN AIR FLOW SENSOR WAS REPLACED, BUT THE IT DID NOT CORRECT THE PROBLEM. OFTEN TIMES A HESITATION WILL OCCUR WHEN I'M ACCCELERATING INTO TRAFFIC OR ATTEMPTING TO CLIMB A HILL OR MOUNTAIN. IN ADDITION, WHEN SHIFTING INT…
Read full complaint
FOLLOWING APPROXIMATELY TWO DOZEN VISITS TO THE DEALERSHIP FOR A CORRECTION, NOTHING WAS FOUND. AT ONE POINT AN AIR FLOW SENSOR WAS REPLACED, BUT THE IT DID NOT CORRECT THE PROBLEM. OFTEN TIMES A HESITATION WILL OCCUR WHEN I'M ACCCELERATING INTO TRAFFIC OR ATTEMPTING TO CLIMB A HILL OR MOUNTAIN. IN ADDITION, WHEN SHIFTING INTO GEAR THE TRANSMISSION WILL JERK AND SHIFTING INTO GEAR VERY ROUGHLY WHILE CLIMBING A HILL/MOUNTAIN.
NHTSA ODI #710351
Mileage unknown · Apr 27, 1999
Fuel System, GasolineFuel System, Other
DUE TO A DEFECTIVE FUEL PUMP SENDING UNIT GAS GAUGE BECAME INOPERATIVE. IT COULD NOT INDICATE HOW MUCH FUEL WAS IN THE VEHICLE, WHICH MAY RESULT IN STALLING, ETC. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #837141
Mileage unknown · Jul 15, 1998
Fuel System, Gasoline
WHILE DRIVING VEHICLE OR COMING TO A STOP, THE VEHICLE WOULD START TO SMOKE FOR NO REASON. ITS AN INTERMITTENT PROBLEM. SMOKE WOULD BE COMING FROM INSIDE STEERING COLUMN. TOOK VEHICLE TO DEALER & MECHANIC COULD NOT LOCATE PROBLE. WAS INFORMED IT WAS TEST DRIVEN, BUT ODOMETER SHOWED IT WAS NOT DONE. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR BRAKE LINE ON THE PASSENGER SIDE WAS ROUTED TOO CLOSE TO THE CORNER OF THE FUEL TANK. THE LINE COULD BE DAMAGED BY CHAFING AGAINST THE FUEL TANK.
Consequence & remedy
Consequence: REPEATED CHAFING COULD EVENTUALLY RESULT IN A LEAKING BRAKE LINE CAUSING DIMINISHED BRAKING IN ONE BRAKE CIRCUIT INCREASING THE VEHICLE'S STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE AND REPLACE ANY DAMAGED LINES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BOLTS SECURING THE FRONT HOOD LATCH CAN LOOSEN OVER TIME. THE LATCH WOULD MOVE CAUSING DISENGAGEMENT OF THE HOOD STRIKER FROM THE LATCH.
Consequence & remedy
Consequence: UNEXPECTED OPENING OF THE HOOD COULD OCCUR OBSTRUCTING THE DRIVER'S VIEW OF THE ROAD WHILE DRIVING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE HOOD LATCH AND SECURING BOLTS AND REPLACE THEM IF NECESSARY.
IMPROPER MATERIAL WAS USED IN MANUFACTURING THE RADIATOR FAN MOTOR SHAFT CAUSING THE SHAFT TO WEAR AND BECOME NOISY.
Consequence & remedy
Consequence: A WORN AND NOISY FAN MOTOR SHAFT CAN SEIZE RENDERINGTHE FAN MOTOR INOPERATIVE, EVENTUALLY CAUSING THE ENGINE TO OVERHEAT AND STALL. A STALLED VEHICLE IN TRAFFIC CAN INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE COMPLETE COOLING FAN ASSEMBLY ON VEHICLE HAVING THE POTENTIAL SHAFT MATERIAL PROBLEM. DEALERS WILL INSTALL A NEW FAN BLADE INCLUDING A NEW LOCK NUT ON VEHICLE WITH LOOSE FAN BLADE LOCK NUTS.
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence & remedy
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Consequence: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
Remedy: OWNERS WILL BE PROVIDED WITH A NEW JACK.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE98037 · Hood Latch Failure
Opened Jul 1, 1998 · Closed Jul 20, 1998
Status: closed (inferred from source dates) · Structure
ODI HAS RECEIVED THREE REPORTS, INCLUDING THE PETITIONERS, REGARDING ALLEGED HOOD LATCH FAILURES.ALL OF THE ODI REPORTS INDICATE THE HOOD FLEW UP WHILE DRIVING.FOLLOWING A TELEPHONE INQUIRY, VOLKSWAGEN PROVIDED ODI WITH SOME LIMITED INFORMATION REGARDING SIX ADDITIONAL REPORTS OF HOOD FLY-UP FOR MODEL YEARS 1995 AND 1996.THIS INVESTIGATION WAS OPENED TO FURTHER STUDY THIS ISSUE.DEFECT DESCRIPTION:IT IS POSSIBLE THAT ON SOME OF THE AFFECTED VEHICLES THE BOLTS SECURING THE FRONT HOOD LATCH MAY LOSE THEIR SPECIFIED FASTENING TORQUE OVER TIME.SHOULD THIS HAPPEN, THE LATCH COULD MOVE OUT OF ITS DESIGN POSITION AND CAUSE DISENGAGEMENT OF THE HOOD STRIKER FROM THE LATCH.IN SOME VEHICLES THE LATCH MAY NOT HAVE BEEN PROPERLY ALIGNED DURING PRODUCTION.REPEATED OPENING AND CLOSING OF THE HOOD WITH AN IMPROPERLY ALIGNED LATCH COULD RESULT IN DAMAGE TO THE LATCH.EITHER CONDITION COULD RESULT IN UNEXPECTED OPENING OF THE HOOD AND COULD OBSTRUCT A PORTION OF THE DRIVER'S VIEW OF THE ROAD WHILE DRIVING, AND RESULT IN AN ACCIDENT.REMEDY: VOLKSWAGEN OF AMERICA, INC. WILL INITIATE A VOLUNTARY SAFETY RECALL INSTRUCTING ITS AUTHORIZED DEALERS TO CHECK THE HOOD LATCH AND SECURING BOLTS AND REPLACE THEM IF NECESSARY.
DP98006 · Hood FLY-UP
Opened Jun 11, 1998 · Closed Jul 1, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1995 Volkswagen Jetta Problems, Complaints & Recalls | Skip That Year
Illustration