CAR HAS BEEN SITTING FOR 2 MONTHS IN THE DRIVEWAY. I JUST HAD EVERYTHING TUNED AND BATTERY WORKING BEFORE I PARKED IT. I STARTED IT ONCE IN BETWEEN THAT TIME AND IT WORKED. I WENT OUT THE OTHER DAY AND THE CAR WOULD NOT START. I KNOW IT'S NOT THE STARTER. IT IS THE SEAT BELT SYSTEM WHERE THE CAR WON'T START UNLESS THE SEAT BELT …
Read full complaint
CAR HAS BEEN SITTING FOR 2 MONTHS IN THE DRIVEWAY. I JUST HAD EVERYTHING TUNED AND BATTERY WORKING BEFORE I PARKED IT. I STARTED IT ONCE IN BETWEEN THAT TIME AND IT WORKED. I WENT OUT THE OTHER DAY AND THE CAR WOULD NOT START. I KNOW IT'S NOT THE STARTER. IT IS THE SEAT BELT SYSTEM WHERE THE CAR WON'T START UNLESS THE SEAT BELT IS CONNECTED. THE CAR STILL WON'T START SO I AM UPSET. PLEASE MAKE THIS WORK OUT FOR ME. *TR
NHTSA ODI #10188302
Mileage unknown · Jul 11, 2006
Electrical System
1991 VOLKSWAGEN JETTA HAD MECHANICAL PROBLEMS. THE MECHANIC REPLACED THE GENERATOR AND BELT, HOWEVER THE PROBLEM RECURRED. *KB THE CONSUMER HAD THE SAME PROBLEM FIXED AT A LOCAL INDEPENDENT REPAIR SHOP AND NO MORE PROBLEMS HAVE DEVELOPED. *JB
NHTSA ODI #10162641
Mileage unknown · Jul 31, 2000
Electrical SystemSeat Belts
GATES 7280 BELT SPECED FOR APLICATION ALTERNATOR FOR JETTA W/AC BELT TO LONG AND TO LARGE WEARS OUT ALMOST IMEDIATLY AND DERAILES AND HAS DERAILED OTHER BELT WITH IT. IT IS TO LONG AND TO LARGE ITS CORDS ARE VISIBLE ABOVE THE THE DRIVE PULLEY!!!. *AK
NHTSA ODI #726310
Mileage unknown · Jul 16, 2000
Electrical SystemSeat BeltsSteering
VW BULLETIN 139202 I LOST ALL MY BELTS ON THE HIGHWAY AND LOST POWER STEERING CAUSE BELTS FLUNG INTO THE V NOTCH OF OTHER BELTS NO INJURIES.NO BELTS WILL LAST ON THIS VEHICLE DUE EITHER TO POOR GEOMETRY OF THE ALTERNATOR BELT OR TO MUCH HOSREPOWER DRAW FROM THE ALTERNATOR. THE ALTERNATOR BELT HAS GONE 10 TIMES IN THE 20000 M…
Read full complaint
VW BULLETIN 139202 I LOST ALL MY BELTS ON THE HIGHWAY AND LOST POWER STEERING CAUSE BELTS FLUNG INTO THE V NOTCH OF OTHER BELTS NO INJURIES.NO BELTS WILL LAST ON THIS VEHICLE DUE EITHER TO POOR GEOMETRY OF THE ALTERNATOR BELT OR TO MUCH HOSREPOWER DRAW FROM THE ALTERNATOR. THE ALTERNATOR BELT HAS GONE 10 TIMES IN THE 20000 MILES SINCE PURCHASE.I FELT THIS WAS A NUISANCE PROBLEM UNTIL I LOST MY POWER STEERING AND NOW I FEAR THIS CAR WILL KILL ME. *AK
AN ENGINE PREHEATING TUBE MAY NOT BE PROPERLY SUPPORTED DUE TO A MISSING SUPPORT BRACKET, CAUSING THE PREHEATING TUBE TO CHAFE AGAINST THE RIGHT FRONT METAL BRAKE LINE. THIS CAN DAMAGE THE HYDRAULIC LINE, CAUSING BRAKE FLUID LEAKAGE AND DIMINISHED BRAKING IN ONE BRAKE CIRCUIT.
Consequence & remedy
Consequence: DIMINISHED BRAKING CAN RESULT IN INCREASED STOPPINGDISTANCES AND A POSSIBLE ACCIDENT.
Remedy: DEALERS WILL INSTALL A PREHEATING TUBE SUPPORT BRACKET TO ENSURE PROPER POSITIONING RELATIVE TO THE RIGHT FRONT METAL BRAKE LINE.
THE VENTURI TUBE LOCATED IN THE THROTTLE VALVE HOUSING CAN BECOME LOOSE AND FALL AGAINST THE THROTTLE PLATE.
Consequence & remedy
Consequence: THE VENTURI TUBE CAN PARTIALLY BLOCK THE THROTTLE PLATEAND PREVENT IT FROM RETURNING TO ITS FULL IDLE POSITION, RESULTING IN UNWANTEDENGINE SPEED WHEN THE VEHICLE IS PLACED IN A FORWARD OR REVERSE GEAR.
Remedy: REPLACE THE PRESS-FIT VENTURI TUBE WITH A THREAD TYPE TUBE.
THE LOCK NUT OF THE CRUISE CONTROL ROD FOR THE OPERATING SERVO MAY NOT HAVE BEEN PROPERLY TORQUED DURING MANUFACTURE.
Consequence & remedy
Consequence: INADEQUATE TORQUE OF THE LOCK NUT COULD ALLOW THE RODADJUSTMENT TO CHANGE. THIS COULD INCREASE THE ENGINE IDLE SPEED, AND POSSIBLYINCREASE STOPPING DISTANCE WITH A POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: CHECK AND ASSURE PROPER LOCK NUT TORQUE ON THE CRUISE CONTROL ROD.
Illustration