RELIABLE INTERNET AUTOMOTIVE SOURCES HAVE LISTED EXCESSIVE WEAR OF THE INTERMEDIATE (BALANCE SHAFT) VALVE TIMING CHAIN SPROCKET IN EARLY 2001 24-VALVE VR6 ENGINES. THE INADEQUATELY HARDENED SPROCKET TEETH WILL VEER EXCESSIVELY, SUCH THAT CHAIN "JUMPEDS" A TOOTH AND SINCE THE VR6 IS AN "INTERFERENCE" VALVE-TRAIN ENGINE, THE ENGI…
Read full complaint
RELIABLE INTERNET AUTOMOTIVE SOURCES HAVE LISTED EXCESSIVE WEAR OF THE INTERMEDIATE (BALANCE SHAFT) VALVE TIMING CHAIN SPROCKET IN EARLY 2001 24-VALVE VR6 ENGINES. THE INADEQUATELY HARDENED SPROCKET TEETH WILL VEER EXCESSIVELY, SUCH THAT CHAIN "JUMPEDS" A TOOTH AND SINCE THE VR6 IS AN "INTERFERENCE" VALVE-TRAIN ENGINE, THE ENGINE WILL ESSENTIALLY BE IRREPARABLY DAMAGED. *TR
ON CERTAIN MINIVANS EQUIPPED WITH CHILD RESTRAINT ANCHORAGES (TETHER ANCHORAGES) FOR USE IN CONJUNCTION WITH CHILD RESTRAINTS INSTALLED IN THE THREE REARMOST SEATING POSITIONS, THE "SAFETY FIRST" PORTION OF THE OWNER'S MANUAL DELIVERED WITH THESE VEHICLES INCORRECTLY INSTRUCTS OWNERS TO GUIDE THE TETHER STRAP UNDERNEATH THE SEAT'S HEAD RESTRAINT AND TO RAISE THE HEAD RESTRAINT SLIGHTLY, IF NECESSARY.
Consequence & remedy
Consequence: IF THE OWNER FOLLOWS THESE INSTRUCTIONS, THE HEAD RESTRAINT COULD ACCIDENTALLY SEPARATE FROM THE SEAT IN THE EVENT OF A CRASH AND CAUSE INJURY TO ANY CHILD OCCUPANT SEATED IN THE TETHERED CHILD SEAT.
Remedy: OWNERS WILL BE SENT A NEW "SAFETY FIRST" BOOKLET THAT WILL CONTAIN CORRECTED USE INSTRUCTIONS. OWNER NOTIFICATION BEGAN NOVEMBER 30, 2002. OWNERS WHO DO NOT RECEIVE THE FREE BOOKLET WITHIN A REASONABLE TIME SHOULD CONTACT VWOA AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08002 · Engine Cooling Fan Blade Fracture
Opened Jan 4, 2008 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
THE SUBJECT VEHICLES ARE BUILT ON A VOLKSWAGEN EUROVAN CHASSIS AND ARE CLASS C MOTOR HOMES. ON SEPTEMBER 5, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AS RQ 07-002 AFTER RECEIVING FOUR CONSUMER REPORTS OF FAN BLADE FAILURE ON MODEL YEAR 2002 WINNEBAGO RIALTA AND VISTA VEHICLES.AS A RESULT OF ADDITIONAL INFORMATION RECEIVED FROM VOLKSWAGEN IN RESPONSE TO RQ 07-002, THE INVESTIGATION WAS UPGRADED TO ENGINEERING ANALYSIS (EA) 08-002.THE SCOPE OF THE EA INVESTIGATION WAS ALSO EXPANDED TO COVER MODEL YEARS 2001 THROUGH 2004 RIALTA AND VISTA, 2002 THROUGH 2004 SUNSTAR, AND 2001 THROUGH 2003 EUROVAN.ALL OF THESE VEHICLES UTILIZE THE SAME ENGINE COOLING FAN.HOWEVER, THE WINNEBAGO VEHICLES ARE LARGER AND HEAVIER THAN THE EUROVAN.AS A CONSEQUENCE, THE COOLING FAN WOULD OPERATE MORE FREQUENTLY IN THE WINNEBAGO VEHICLES COMPARED TO THE EUROVAN FOR THE SAME ON-ROAD OPERATING CONDITIONS.ANALYSIS OF THE AVAILABLE DATA CONCERNING THE PROBLEM EXPERIENCE INDICATES THAT IT PREDOMINATELY AFFECTS THE MY 2002 WINNEBAGO MODELS.WINNEBAGO ACCOUNTS FOR 79% OF ALL THE REPORTS, BUT REPRESENTS ONLY 23% OF THE TOTAL SUBJECT VEHICLE POPULATION.THE MAJORITY OF THE WINNEBAGO REPORTS ARE FOR THE MODEL YEAR 2002 (64%).THE DATA SHOW A DECLINING REPORT TREND, PARTICULARLY FOR THE 2002 WINNEBAGO.REPORTS ON THE 2002 WINNEBAGO REACHED A HIGH OF 11 REPORTS IN CALENDAR YEAR 2005, DROPPING TO THREE REPORTS IN 2006,TWO REPORTS IN 2007, AND ONE REPORT IN 2008.AN EXISTING SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
RQ07002 · Engine Cooling Fan Blade Fracture
Opened Sep 5, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION BASED ON FOUR REPORTSALLEGING FAILURE OF AN ENGINE COOLING FAN IN THE SUBJECT VEHICLES.THREE OF THE COMPLAINANTS ALLEGED THE FAN DISINTEGRATED AND TWO OF THE THREE ALLEGED THE RADIATOR WAS DAMAGED AS A RESULT.THE FOURTH COMPLAINANT ALLEGED THAT HIS VEHICLE EXPERIENCED VIOLENT SHAKING AND OVERHEATING.WHEN THE VEHICLE WAS INSPECTED, IT WAS NOTED THAT PIECES OF THE FAN WERE MISSING.ALL FOUR VEHICLES WERE CLASS C MOTOR HOMES BUILT ON A VOLKSWAGEN EUROVAN CHASSIS.TWO OF THE VEHICLES ARE RIALTA MODELS AND TWO ARE VISTA MODELS.BASED ONADDITIONAL INFORMATION RECEIVED FROM VOLKSWAGEN ODI IS UPGRADING THIS INVESTIGATION TOENGINEERING ANALYSIS EA 08-002 FOR FURTHER STUDY.
2001 Volkswagen Eurovan Problems, Complaints & Recalls | Skip That Year
Illustration