I HAD CHECKED BEFORE HAND IF MY HEATER CORE WAS UNDER THE CURRENT RECALL FOR 93 CORRADOS, BUT IT WASN'T. NOW MY HEATER CORE IS HAVING PROBLEMS AND LEAKING INTO THE PASSENGER SIDE OF MY VEHICLE. I CANNOT AFFORD TO PAY FOR THE $600 THE DEALER IS ASKING FOR PUTTING IN A $60 PRODUCT. THEREFORE I HAVE NO CHOICE BUT TO EXCHANGE THE…
Read full complaint
I HAD CHECKED BEFORE HAND IF MY HEATER CORE WAS UNDER THE CURRENT RECALL FOR 93 CORRADOS, BUT IT WASN'T. NOW MY HEATER CORE IS HAVING PROBLEMS AND LEAKING INTO THE PASSENGER SIDE OF MY VEHICLE. I CANNOT AFFORD TO PAY FOR THE $600 THE DEALER IS ASKING FOR PUTTING IN A $60 PRODUCT. THEREFORE I HAVE NO CHOICE BUT TO EXCHANGE THE HEATER CORE MYSELF WHICH IS GOING TO BE A MAJOR PAIN.
NHTSA ODI #712362
Mileage unknown · Feb 17, 1999
Engine And Engine Cooling
PRESSURE LIGHT KEPT COMING ON THE COOLING SYSTEM. THE COOLING SYSTEMS HOSES CAME OFF. RECALL #98V295000. DOES NOT AFFECT THIS VEHICLE, BUT HAS THE SAME TYPE OF PROBLEM. *AK
NHTSA ODI #834930
Mileage unknown · Feb 9, 1999
Engine And Engine Cooling
NO SUMMARY PROVIDED BY CONSUMER. *AK
NHTSA ODI #701117
Mileage unknown · Feb 8, 1999
Electrical SystemEngine And Engine CoolingVisibility
THERE HAVE BEEN A SEVERAL SMALL DEFECTS, BUT THE LAST TWO WERE MAJOR. THEY WERE THE FAILURE OF THE IGNITION CONTROL MODULE IN OCT 1998 ($1,440), AND THE HEATER CORE RUPTURED IN JAN 1999 ($440). THE COOLING SYSTEM STILL SEEMS NOT TO BE OPERATING CORRECTLY BECAUSE IT OPERATES BETWEEN 215 AND 230 DEG F IN 25 TO 35 DEG F AMBIENT T…
Read full complaint
THERE HAVE BEEN A SEVERAL SMALL DEFECTS, BUT THE LAST TWO WERE MAJOR. THEY WERE THE FAILURE OF THE IGNITION CONTROL MODULE IN OCT 1998 ($1,440), AND THE HEATER CORE RUPTURED IN JAN 1999 ($440). THE COOLING SYSTEM STILL SEEMS NOT TO BE OPERATING CORRECTLY BECAUSE IT OPERATES BETWEEN 215 AND 230 DEG F IN 25 TO 35 DEG F AMBIENT TEMPERATURES. ALSO, THERE IS STILL A SMALL LEAK IN THE COOLING SYSTEM NEAR THE TOP DRIVERS SIDE OF THE RADIATOR WHICH HAS NOT BEEN LOCATED PRECISELY YET. IN SPITE OF THESE NIGGLING PROBLEMS, I STILL GREATLY ENJOY DRIVING MY CORRADO AND WOULD LIKE TO KEEP IT FOR ANOTHER 5 YEARS. *AK
NHTSA ODI #703040
Mileage unknown · Jan 7, 1999
Engine And Engine Cooling
EXPERIENCING PROBLEM WITH VEHICLE WATER PUMP LEAKING. DEALER/MANUFACTURER NOTIFIED. DEALER INFORMED OF NO RECALL ON VEHICLE. MANUFACTURER ALSO INFORMED CONSUMER OF NO KNOWLEGE OF RECALL OF VW/ COOLANT SYSTEM, NHTSA # 98V-295 000. COULD I RECEIVED SOME HELP IN THIS MATTER? *AK
NHTSA ODI #833188
Mileage unknown · Dec 21, 1998
Engine And Engine CoolingFire
FAN MOTOR DEFECTIVE CAUSING WIRING TO OVERHEAT AND CATCH FIRE WHEN MOTOR SHORTED OUT.
NHTSA ODI #543083
Mileage unknown · Jul 12, 1998
Engine And Engine Cooling
ENGINE CYLINDER BLOCK CONSUMED OIL AND AN OVERHAUL WAS DONE AT 49000 MILES.
NHTSA ODI #538275
Mileage unknown · Jul 1, 1998
Engine And Engine Cooling
VEHICLE STARTED TO MAKE NOISE FROM THE ENGINE. CONSUMER CONTACTED DEALER. THE ENGINE COOLING FAN WAS GONE BAD. PLEASE PROVIDE FURTHER DETAILS. *AK
NHTSA ODI #824877
Mileage unknown · May 30, 1998
Engine And Engine Cooling
CLYINDER HEAD GASKET FAILURES ON EARLY VOLKSWAGON VR6 ENGINES ARE ALMOST GUARNATEED. FAILURE RESULTS IN OVERHEATED ENGINE.
NHTSA ODI #536379
Mileage unknown · May 6, 1998
Engine And Engine Cooling
HAD RECEIVED RECALL NOTICE (#95V178000), ENGINE COOLING FAN. THE RECALL WAS DONE OVER A YEAR AGO, BUT THE PART HAD FAILED. CONTACTED DEALERSHIP & DEALER REFUSED TO REPAIR IT AGAIN DUE TO 1 YR EXPIRATION. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH VR6 ENGINES. A COOLANT SYSTEM COMPONENT SUCH AS THE THERMO SWITCH, RADIATOR FAN, OR WATER PUMP, CAN MALFUNCTION CAUSING THE COOLANT TEMPERATURE AND COOLANT SYSTEM PRESSURE TO INCREASE SIGNIFICANTLY. OVER TIME, EXCESSIVE PRESSURE CAN CAUSE LEAKAGE OF COOLANT FROMTHE SYSTEM, INCLUDING LEAKAGE FROM THE HEAT EXCHANGER.
Consequence & remedy
Consequence: LEAKAGE OF HOT COOLANT FROM THE HEAT EXCHANGER CAN CAUSE INJURY TO THE FEET OF THE DRIVER OR STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISION.
Remedy: DEALERS WILL INSTALL IN THE COOLANT INLET HOSE TO THE HEATER CORE, A PRESSURE REDUCER WITH A 5MM DIAMETER SECURED BY A SPRING TENSIONED HOSE CLAMP. ALSO A NEW RELAY THAT WILL CHANGE THE OPERATION OF THE SECONDARY ELECTRICAL COOLANT PUMP WILL BE INSTALLED. DEALERS WILL ALSO PERFORM A FUNCTIONAL CHECK OF THE COOLING SYSTEM TO MAKE SURE THAT ALL COOLING SYSTEM COMPONENTS OPERATE PROPERLY.
IMPROPER MATERIAL WAS USED IN MANUFACTURING THE RADIATOR FAN MOTOR SHAFT CAUSING THE SHAFT TO WEAR AND BECOME NOISY.
Consequence & remedy
Consequence: A WORN AND NOISY FAN MOTOR SHAFT CAN SEIZE RENDERINGTHE FAN MOTOR INOPERATIVE, EVENTUALLY CAUSING THE ENGINE TO OVERHEAT AND STALL. A STALLED VEHICLE IN TRAFFIC CAN INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE COMPLETE COOLING FAN ASSEMBLY ON VEHICLE HAVING THE POTENTIAL SHAFT MATERIAL PROBLEM. DEALERS WILL INSTALL A NEW FAN BLADE INCLUDING A NEW LOCK NUT ON VEHICLE WITH LOOSE FAN BLADE LOCK NUTS.
AN ENGINE COMPARTMENT ELECTRICAL WIRING HARNESS MAY HAVE BEEN ROUTED TOO CLOSE TO A SHEET METAL EDGE. THE WIRING CAN BECOME DAMAGED DURING NORMAL VEHICLE OPERATION DUE TO CHAFING, RESULTING IN AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: IF A SHORT OCCURS, EITHER THE ENGINE COULD STALL ORTHE RADIATOR FAN COULD STOP OPERATING CAUSING THE ENGINE TO OVERHEAT. EITHERCONDITION COULD RESULT IN A VEHICLE ACCIDENT.
Remedy: REROUTE AND SECURE VARIOUS WIRING HARNESSES INSIDE THE ENGINE COMPARTMENT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1993 Volkswagen Corrado Problems, Complaints & Recalls | Skip That Year
Illustration