Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
2325–50K
2850–75K
2575–100K
11100–150K
1150K+
108 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports1 fire reports9 injury reports
What owners actually said
124 reports
2,200 miles · Jul 7, 2006
Power Train
DUAL MASS FLYWHEEL BLEW APART AT 2200 MILES THEN AT 7,800 MILES ON A 2006 BEETLE TDI. I AM NOW ON BOTH TIMES HAPPENED DOWN SHIFTING FROM 5TH TO 4TH GEAR. HAVE DRIVEN MANUAL SHIFTS ALL MY LIFE NEVER HAD THIS HAPPEN. WAS TOLD BY DEALER THAT DMF HAS A HARD TIME HANDLING TORQUE. I WAS STILL LESS THAN 3000 RPM WHEN DROPPING INTO …
Read full complaint
DUAL MASS FLYWHEEL BLEW APART AT 2200 MILES THEN AT 7,800 MILES ON A 2006 BEETLE TDI. I AM NOW ON BOTH TIMES HAPPENED DOWN SHIFTING FROM 5TH TO 4TH GEAR. HAVE DRIVEN MANUAL SHIFTS ALL MY LIFE NEVER HAD THIS HAPPEN. WAS TOLD BY DEALER THAT DMF HAS A HARD TIME HANDLING TORQUE. I WAS STILL LESS THAN 3000 RPM WHEN DROPPING INTO 4TH GEAR WHEN THE FLYWHEEL BROKE. THIS SHOULD NEVER HAPPEN AS IT SHOULD BE ABLE TO HANDLE THIS AMOUNT OF TORQUE AS A STANDARD OPERATING PROCEDURE. LUCKILY I WAS ABLE TO PULL OFF TO THE SIDE OF THE ROAD AS ALL MY TRANSMISSION OPERATION WAS LOST. *NM
NHTSA ODI #10161787
95 miles · Jun 5, 2006
Engine And Engine Cooling
ENGINE MAKES LOUD HUMMING NOISE WHEN A/C IS TURNED ON. *NM
NHTSA ODI #10158987
4,000 miles · May 28, 2006
Engine And Engine Cooling
A/C COMPRESSOR OR FAN MOTOR HOWLS VERY LOUDLY. TAKEN TO DEALER AND DEALER STATED AT FIRST THAT THEY COULD NOT DUPLICATE PROBLEM . INSISTED THEY LISTEN AGAIN SINCE SERVICE WRITER COULD HEAR NOISE WHEN WE DROVE IN. THEN STATED THAT CAR HAD TOO MUCH FREON IN UNIT AND THAT PROBLEM WAS FIXED. DROVE OUT OF LOT AND HOWLING WAS AS…
Read full complaint
A/C COMPRESSOR OR FAN MOTOR HOWLS VERY LOUDLY. TAKEN TO DEALER AND DEALER STATED AT FIRST THAT THEY COULD NOT DUPLICATE PROBLEM . INSISTED THEY LISTEN AGAIN SINCE SERVICE WRITER COULD HEAR NOISE WHEN WE DROVE IN. THEN STATED THAT CAR HAD TOO MUCH FREON IN UNIT AND THAT PROBLEM WAS FIXED. DROVE OUT OF LOT AND HOWLING WAS AS LOUD AS EVER. AFRAID COMPRESSOR OR FAN WILL BLOW OUT OF HOOD OF CAR. THE LONGER THE CAR IS DRIVEN THE LOUDER THE HOWL BECOMES. *JB
NHTSA ODI #10158450
8,800 miles · Apr 26, 2006
Power TrainService Brakes, Hydraulic
DT*: THE CONTACT STATED WHILE ATTEMPTING TO APPLY BRAKE PRESSURE AT ALL SPEEDS, THE BRAKES WENT TO THE FLOOR AND WOULD NOT RETURN TO THE NORMAL UP POSITION. THE DRIVER HAD TO PULL UP ON THE BRAKE PEDAL TO APPLY BRAKE PRESSURE. ALSO, THE TRANSMISSION FAILS TO MAINTAIN ENGAGED WHEN INCLINED. ALTHOUGH THE DEALER WAS ALERTED NO …
Read full complaint
DT*: THE CONTACT STATED WHILE ATTEMPTING TO APPLY BRAKE PRESSURE AT ALL SPEEDS, THE BRAKES WENT TO THE FLOOR AND WOULD NOT RETURN TO THE NORMAL UP POSITION. THE DRIVER HAD TO PULL UP ON THE BRAKE PEDAL TO APPLY BRAKE PRESSURE. ALSO, THE TRANSMISSION FAILS TO MAINTAIN ENGAGED WHEN INCLINED. ALTHOUGH THE DEALER WAS ALERTED NO INSPECTIONS HAVE BEEN MADE.
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
Consequence & remedy
Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 17-INCH WHEELS AND A 2.5L ENGINE FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE PRODUCED WITH A TIRE INFORMATION LABEL THAT LISTS AN INCORRECT FRONT TIRE SIZE. THE CORRECT FRONT TIRE SIZE SHOULD BE LISTED AS 225/45 R17. THE INFLATION PRESSURE IS CORRECT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO FITMENT OF IMPROPERLY SIZED REPLACEMENT TIRES.
Remedy: OWNERS WILL BE PROVIDED WITH A NEW TIRE INFORMATION LABEL AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 Volkswagen Beetle Problems, Complaints & Recalls | Skip That Year
Illustration