IllustrationTHE SEAT HEATER GOT EXTREMELY HOT VERY QUICK WHILE DRIVING. IT WAS SO HOT, THAT IT BURNED A HOLE IN THE SEAT AND BURNED MY BOTTOM. THIS ALSO NEARLY CAUSED ME TO GET INTO A HORRIBLE ACCIDENT AS I TRIED TO NOT GET BURNED. *TR
2006 Volkswagen Beetle
Owner reports · Recalls · Investigations
More warning signs than most Beetle years
Owner complaints for the 2006 Volkswagen Beetle are substantially higher than the model-year median of 49.
About this comparison →How this year compares
Owner complaints by model year
Compare all Beetle years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
2325–50K
2850–75K
2575–100K
11100–150K
1150K+
108 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports1 fire reports9 injury reports
Seats complaints
3 reportsTL*THE CONTACT OWNS A 2006 VOLKSWAGEN BEETLE. SHE NOTICED RED MARKS ALONG THE BACK OF HER LEGS AND BACK. AFTER SEEING A DOCTOR SHE WAS INFORMED THAT THE RED MARKS WERE A RASH FROM A HEATING BURN CAUSED BY THE HEATED CAR SEATS. SHE WAS ALSO INFORMED THAT THE RASH MAY NEVER GO AWAY. THE VEHICLE WAS NEVER EXAMINED BY A DEALER. …
Read full complaint
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN BEETLE. SHE NOTICED RED MARKS ALONG THE BACK OF HER LEGS AND BACK. AFTER SEEING A DOCTOR SHE WAS INFORMED THAT THE RED MARKS WERE A RASH FROM A HEATING BURN CAUSED BY THE HEATED CAR SEATS. SHE WAS ALSO INFORMED THAT THE RASH MAY NEVER GO AWAY. THE VEHICLE WAS NEVER EXAMINED BY A DEALER. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 100,000.
TL* - THE CONTACT OWNS A 2006 VOLKSWAGEN BEETLE. THE DRIVER'S SIDE HEATED SEAT WORKED INTERMITTENTLY. THE CONTACT STATED THAT IF ONE FORCED THE SWITCH ON AND OFF THE HEATER WOULD OPERATE. THE CURRENT AND FAILURE MILEAGEWAS 996. THE CONTACT HAS AN APPOINTMENT AT A DEALER FOR A DIAGNOSIS. *AK
Official recalls
310V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Dec 10, 2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
Consequence & remedy
Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
07V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
06V043000 · Equipment:other:labels
Feb 9, 2006
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 17-INCH WHEELS AND A 2.5L ENGINE FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE PRODUCED WITH A TIRE INFORMATION LABEL THAT LISTS AN INCORRECT FRONT TIRE SIZE. THE CORRECT FRONT TIRE SIZE SHOULD BE LISTED AS 225/45 R17. THE INFLATION PRESSURE IS CORRECT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO FITMENT OF IMPROPERLY SIZED REPLACEMENT TIRES.
Remedy: OWNERS WILL BE PROVIDED WITH A NEW TIRE INFORMATION LABEL AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.