2016 Toyota Tacoma

AT shifter was stiff from purchase. I thought this was normal. Sometimes it shifted OK, most times not. Had independent repair shops lubricate the shifter multiple times to no avail. Then the shifter wouldn't move at all and I was in a traffic lane causing a dangerous situation. Had truck towed to an independent repair shop that found a second way to lubricate the shaft. Curious how many trucks left the factory without AT shaft lubricated.

Just like with the other double cab Tacoma recalls I am hearing about, the third rear tail light is leaking water into my access cab. The interior smells like mildew. I’m not sure why my truck is not covered by the recall, but it is experiencing the exact same situation. Water leaking through the deteriorated seal of the break-light. I think with accompanying mold build up.

What component or system failed or malfunctioned, and is it available for inspection upon request? Heated seat heating module. How was your safety or the safety of others put at risk? Module burned out during usage and emitted fire odor and smoke when burnt out (potential fire hazard if kept on). Has the problem been reproduced or confirmed by a dealer or independent service center? [XXX] Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Unknown. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? None. 2016 Tacoma limited heated seat heating module overheated/burned out with slight smoke under seat during minimal usage (texas based). TSB [XXX] released in October 2018, about the time most of the 2016 (produced in 2015) are going out of warranty, and based on frequency of usage and locale (warmer climates observe less usage) - also even though parts used are the same, VIN is apparently not affected. Toyota will not honor TSB even though the burn out can be a potential fire hazard if not known/smelled especially while traveling and buckled into seat belt (similar to Mercedes heated seats caught on fire). No notice provided by Toyota of TSB at time of issue. Item should be a recall as it affects many 2016-2018 Tacoma's and is a fire safety and burn hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fuel injector(s) leaked without any warning, causing engine to loose power on freeway. We were fortunate to be able to move over to the shoulder before the truck lost all power. Vehicle was towed to dealer and it was determined that the injector leaked fuel into engine causing engine failure. Repairs needed include engine block, heads sub assembly, injectors and assorted other parts total for parts and labor $19,256 No warning lights or symptoms prior to this problem. Truck has been running fine with no problems, only has 41,000 miles.

On 10/30/2023 Toyota stopped supporting Scout GPS Link. This is the Toyota installed navagation system and the only navagation system that works with the Toyota display/audio system. All other navagation systems are blocked from the Toyota system. Navagation is now reduced to using a Cell Phone display and audio. Well this option works it is much less safe as the display is much lower beneath the driver's normal line of sight. Eyes must be taken off the road for a much longer period and looking at a much smaller display. While not as big a safety risk as other vehicle problems this may provide NHTSA with the opportunity to track the safety impact of vehcile navigation systems vs hand held nagivation systems.

Truck had to be abandoned after I attempted to start it and the brake pedal was stiff and the ignition would not allow starter to function. Dashboard message indicated a brake problem with transmission interlock. The next day, after viewing a U-Tube video on the problem (same make/model/year) I held the starter button in for 12-15 seconds with no foot on the brake. The engine started but the transmission remained locked in Park. Tow truck operator was able to release the shifter using an access port and screwdriver and found that he could drive it up onto the inclined platform. Once in place on the platform he shifted to Park and found it was again locked. This issue disabled the truck in a traffic area where it could not be started or shifted into Neutral to move it...a dangerous situation.

My 2016 Toyota Tacoma has had multiple oil leaks in the timing cover. The dealer has already fixed this issue twice and the timing cover is currently leaking oil. This leak is expensive to fix because it involves removing the engine and the transmission to properly seal the timing cover. This is a know defect that poses a serious safety concern as the oil leak may go from a small leak to a large leak quickly, causing the engine to fail. Additionally the air pressure from driving can cause the oil to end up everywhere which can lead other components to degrade and fail. Because the fix is so complex, the process to remove and reinstall the engine and transmission may result in other mistakes. During one of the attempts to fix the issue, the dealer forgot to replace an engine bolt and forgot to hook up a vent hose. The cost to fix this issue is so high that it makes it too expensive for many to fix.

Vehicle is designed in such a way as to allow moisture accumulating in drivers side floor mat and carpeting to wick upward and be deposited on the primary vehicle wiring harness located in the drivers side kick panel. The moisture collected travels down into the backside of the various female connectors and corrodes the conductors and receptacles that result in short circuits between the various vehicle components including the ignition, engine shutoff, temperature sensors, Antilock Breaking, Blind Spot Monitoring, Fuel Gauge, Forward Vehicle Lighting (high and low beam), Security, Traction Control and other critical vehicle systems. On February 5th, 2023 I returned to my vehicle to find the security alarm sounding in the parking lot of a local business, both the keyless entry system and key-fob were unresponsive and would neither silence the alarm or unlock the vehicle. After manually unlocking the door handle the alarm ceased, the vehicle started as normal and then began indicating a failure of the BSM system, while underway the ABS indicated it had also failed and upon arrival at our destination the engine would not turn off even with the emergency shutdown routine prescribed for unintended acceleration cases. In addition, the high beams would be triggered by unrelated button operation occasionally fail to turn off, the fuel gauge, temperature readouts and climate control provided unintelligible values. The vehicle was returned to to dealership where it was determined that water from the floormats was able to contaminate and cause systemwide failure. The repair was to replace the entire wire harness which would not be covered by warranty. On 3/15/2023 I reached out to Toyota Headquarters' Customer Engagement team and was advised that Toyota was aware of the problem and had no interest or obligation in rectifying the situation, regardless of my concerns that this presented a clear safety hazard to both operators and the general public.

POWER STEERING ISSUES, LEAKS, CORRODED. CAN LEAD TO ENTIRE RACK AND PINON REPLACEMENT. STEERING IS TIGHT, ACTIVE FLUID LEAK(S); TOYOTA DEALER THAT IT WAS PURCHASED FROM KNEW IT WAS LEAKING BUT REFUSED TO INVESTIGATE FURTHER. PER TOYOTA, POWER STEERING LEAKS CAN CAUSE ENGINE COMPARTMENT FIRE, VEHICLE SHOULD NOT BE DRIVEN UNTIL LEAK IS REPAIRED. HOWEVER, TOYOTA SERVICE DEPARTMENT WOULD NOT LOCATE THE LEAK AND REMEDY, LET ME DRIVE KNOWING IT COULD BE POTENIALLY HAZARDOUS.