NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
52 reportsClear category filter80,000 miles · Dec 28, 2016
EngineFuel/propulsion System
DRIVING ON THE STREET TO WORK ONE MORNING, THE TRAC OFF AND CHECK ENGINE LIGHTS BOTH SUDDENLY APPEARED. I THEN NOTICED THAT MY TRUCK WAS NOT ABLE TO ACCELERATE PAST ~40 MPH. GOING UPHILL, MY TRUCK WAS LIMITED TO ONLY ~20 MPH. MY TRUCK WENT INTO THIS "SAFE MODE." I CONNECTED AN OBD DEVICE AND THE CAME UP WITH THE FOLLOWING TW…
Read full complaint
DRIVING ON THE STREET TO WORK ONE MORNING, THE TRAC OFF AND CHECK ENGINE LIGHTS BOTH SUDDENLY APPEARED. I THEN NOTICED THAT MY TRUCK WAS NOT ABLE TO ACCELERATE PAST ~40 MPH. GOING UPHILL, MY TRUCK WAS LIMITED TO ONLY ~20 MPH. MY TRUCK WENT INTO THIS "SAFE MODE." I CONNECTED AN OBD DEVICE AND THE CAME UP WITH THE FOLLOWING TWO CODES: P2440 AND P2442. THE CODES REFER TO "SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN" FOR BANKS 1 AND 2, RESPECTIVELY. I DID SOME FURTHER RESEARCH ON THE CODES, AND IT TURNS OUT THIS IS A COMMON ISSUE ON 2012 TACOMAS. APPARENTLY, THE VALVE FOR THE SECONDARY AIR INJECTION SYSTEM IS STUCK OPEN DUE TO MOISTURE AND/OR CARB BUILD UP. I BELIEVE THIS IS A DESIGN/ENGINEERING ISSUE. PART REPLACEMENT COSTS ~$480 FOR EACH VALVE ASSEMBLY. LABOR CAN RANGE ANYWHERE BETWEEN $200-$500. IF THIS IS A KNOWN ISSUE THAT IS COMMON TO A LOT OF 2012 TACOMAS, THEN I BELIEVE TOYOTA SHOULD BE PROACTIVE SUCH AS RELEASING AN OFFICIAL RECALL OR EVEN IMPLEMENT SOME TYPE OF REIMBURSEMENT. NOTE THAT MY TRUCK HAS ~80,000 MILES ON IT. AS AN OWNER, I SHOULDN'T SUFFER FROM AN ENGINEERING DESIGN FLAW AND I SHOULDN'T BE FINANCIALLY RESPONSIBLE TO REPAIR/FIX THE ISSUE. ANY ASSISTANCE WOULD BE HELPFUL. THANK YOU AND HAPPY HOLIDAYS! *TR
NHTSA ODI #10937939
89,000 miles · Nov 8, 2016
Fuel/propulsion System
SECONDARY AIR INJECTION SYSTEM: STARTED THE VEHICLE AND CHECK ENGINE LIGHT CAME ON. OBD READ P2440/P2442. WHILE DRIVING UPHILL ON A VERY BUSY HIGHWAY, THE VEHICLE LOSS POWER AND WOULD NOT GO FASTER THAN 20MPH AND THE RPM'S RAMMED UP. AFTER SOME SOME RESEARCH FOUND OUT THIS IS A COMMON PROBLEM WITH THE TACOMA IN WHICH TOYOTA WAS …
Read full complaint
SECONDARY AIR INJECTION SYSTEM: STARTED THE VEHICLE AND CHECK ENGINE LIGHT CAME ON. OBD READ P2440/P2442. WHILE DRIVING UPHILL ON A VERY BUSY HIGHWAY, THE VEHICLE LOSS POWER AND WOULD NOT GO FASTER THAN 20MPH AND THE RPM'S RAMMED UP. AFTER SOME SOME RESEARCH FOUND OUT THIS IS A COMMON PROBLEM WITH THE TACOMA IN WHICH TOYOTA WAS AWARE OF.
NHTSA ODI #10924933
18,200 miles · Sep 14, 2016
Fuel/propulsion System
THE AIR INJECTION PUMP WENT OUT AND HAD TO BE REPLACED, AND THERE IS ONLY 18,200 MILES ON THE VEHICLE. THE CHECK ENGINE LIGHT CAME ON WHILE DRIVING, AND I WAS ABLE TO DRIVE THE VEHICLE TO THE DEALERSHIP BEFORE "SAFE MODE" KICKED IN. TOYOTA WAS ABLE TO REPLACE THE DEFECTIVE PART. I UNDERSTAND FROM READING ON THE INTERNET THAT …
Read full complaint
THE AIR INJECTION PUMP WENT OUT AND HAD TO BE REPLACED, AND THERE IS ONLY 18,200 MILES ON THE VEHICLE. THE CHECK ENGINE LIGHT CAME ON WHILE DRIVING, AND I WAS ABLE TO DRIVE THE VEHICLE TO THE DEALERSHIP BEFORE "SAFE MODE" KICKED IN. TOYOTA WAS ABLE TO REPLACE THE DEFECTIVE PART. I UNDERSTAND FROM READING ON THE INTERNET THAT THIS IS TURNING OUT TO BE A COMMON PROBLEM FOR THIS VEHICLE, AND WISH TO ADD MY EXPERIENCE TO THE LIST.
NHTSA ODI #10906719
45,100 miles · Jul 20, 2016
EngineFuel/propulsion SystemPower Train
MY 2012 TACOMA WITH 45,000 MILES GOT A CHECK ENGINE LIGHT AND "TRAC OFF" LIGHT WHEN I STARTED IT TO GO HOME. I WAS MERGING ONTO THE INTERSTATE AND UNABLE TO GO ABOVE 40 MPH. THIS WAS OBVIOUSLY NOT SAFE SO I EXITED AND TOOK IT TO A DEALER. THEY CITED TROUBLE CODES P2440 AND P2442 AND SAID THEY NEEDED TO REPLACE SECONDARY AIR I…
Read full complaint
MY 2012 TACOMA WITH 45,000 MILES GOT A CHECK ENGINE LIGHT AND "TRAC OFF" LIGHT WHEN I STARTED IT TO GO HOME. I WAS MERGING ONTO THE INTERSTATE AND UNABLE TO GO ABOVE 40 MPH. THIS WAS OBVIOUSLY NOT SAFE SO I EXITED AND TOOK IT TO A DEALER. THEY CITED TROUBLE CODES P2440 AND P2442 AND SAID THEY NEEDED TO REPLACE SECONDARY AIR INJECTION VALVE (PN 25710-31022) FOR A TOTAL COST OF $940! ACCORDING TO FORUMS AND THE NHTSA.GOV SITE, THIS IS A VERY COMMON COMPLAINT WITH THIS YEAR AND MODEL. I JUST BOUGHT THIS LAST JULY AND I NEVER EXPECTED TO HAVE TO REPLACE PARTS ANYTIME SOON.
NHTSA ODI #10886218
54,640 miles · Jul 16, 2016
Electronic Stability Control (esc)EngineFuel/propulsion System
MY 2012 TOYOTA TACOMA PRERUNNER 2WD HAS 54,640 MILES. I JUST GOT A CHECK ENGINE LIGHT AND "TRAC OFF" LIGHT YESTERDAY. MY TRUCK WOULD ACCELERATE TO JUST 25 MPH WHEN MERGING ONTO THE INTERSTATE AND TOP SPEED WAS AROUND 50 MPH. THIS IS A SERIOUS SAFETY ISSUE AND TOYOTA WILL NOT COVER THIS KNOWN PROBLEM UNDER THE STANDARD 3 YEAR 36,…
Read full complaint
MY 2012 TOYOTA TACOMA PRERUNNER 2WD HAS 54,640 MILES. I JUST GOT A CHECK ENGINE LIGHT AND "TRAC OFF" LIGHT YESTERDAY. MY TRUCK WOULD ACCELERATE TO JUST 25 MPH WHEN MERGING ONTO THE INTERSTATE AND TOP SPEED WAS AROUND 50 MPH. THIS IS A SERIOUS SAFETY ISSUE AND TOYOTA WILL NOT COVER THIS KNOWN PROBLEM UNDER THE STANDARD 3 YEAR 36,000 MILE WARRANTY. AUTOZONE RAN THE DIAGNOSTIC SCAN AND CAME UP WITH TROUBLE CODES P2440 AND P2442. THESE ARE TIED TO THE SECONDARY AIR INJECTION SYSTEM AND SWITCHING VALVES. THE TOYOTA DEALERSHIP SAID THIS WOULD COST ME CLOSE TO $2000 TO REPAIR. I PAID $30,000 FOR THIS VEHICLE BRAND NEW JUST 4 YEARS AGO. THIS NEEDS TO BECOME A CLASS ACTION LAWSUIT SO THAT A SAFETY RECALL IS ISSUED FOR TOYOTA TO REPAIR THIS KNOWN DEFECT FOR FREE.
NHTSA ODI #10885279
37,000 miles · Jun 28, 2016
Fuel/propulsion SystemVehicle Speed Control
I TOOK MY 2012 TACOMA INTO SERVICE TODAY WITH A TRAC OFF AND CHECK ENGINE LIGHT ON. I WAS TOLD THAT THE SECONDARY AIR INJECTION SWITCHING VALVE NEEDED REPLACED AT THE TUNE OF $1300. I SEE THAT MANY OTHERS HAVE HAD THIS ISSUE AND WITH 37K MILES, I FIND IT UNREAL THAT THIS ISN'T COVERED UNDER THE POWERTRAIN WARRANTY.
NHTSA ODI #10881334
49,100 miles · Jun 15, 2016
Fuel/propulsion System
ONLY 49,000 MILES ON MY $32,000 TRUCK AND LIKE MANY OTHER OWNERS OF 2012 TACOMAS I HAVE THE CHECK ENGINE LIGHT COME ON WITH THE TRAC OFF LIGHT AND GIVING THE DIAGNOSTIC CODE OF P2442 SECONDARY AIR INJECTION SWITCHING VALVE. THIS IS CLEARLY A EMISSIONS AND MANUFACTURING PROBLEM WITH THIS YEAR AND TOYOTA SHOULD HAVE TO FOOT THE B…
Read full complaint
ONLY 49,000 MILES ON MY $32,000 TRUCK AND LIKE MANY OTHER OWNERS OF 2012 TACOMAS I HAVE THE CHECK ENGINE LIGHT COME ON WITH THE TRAC OFF LIGHT AND GIVING THE DIAGNOSTIC CODE OF P2442 SECONDARY AIR INJECTION SWITCHING VALVE. THIS IS CLEARLY A EMISSIONS AND MANUFACTURING PROBLEM WITH THIS YEAR AND TOYOTA SHOULD HAVE TO FOOT THE BILL INSTEAD OF CHARGING US $2,100 FOR A FIX A A PRACTICALLY NEW EXPENSIVE TRUCK. THE AIR INJECTION VALVE IS PART OF EMISSIONS AND SHOULD BE COVERED AND A TSB OR RECALL SHOULD BE ISSUED FOR THIS. WHEN THIS VALVE GOES OUT TYPICALLY EVERY 50,000 IT RENDERS YOUR TRUCK USELESS AND PUTS IT INTO SAFE MODE NOT ALLOWING YOU TO GO MORE THAN 35-40 MPH. NEEDLESS TO SAY THIS SPEED JUST DOESN'T WORK ON THE HIGHWAY TO TRAVEL TO WORK AND UNLESS YOU FORK OVER THE $2,100 TO HAVE IT FIXED THEN YOU HAVE TO FIND ANOTHER WAY TO WORK. THIS IS SUCH A SCAM ON TOYOTAS PART AND I AM OUTRAGED THAT AFTER PURCHASING OVER 4 TOYOTA VEHICLES FROM THEM THEY DON'T STAND BY THEIR PRODUCT TO FIX THE PROBLEM.
NHTSA ODI #10874492
70,650 miles · May 31, 2016
Electrical SystemFuel/propulsion SystemUnknown Or Other
THE SECONDARY AIR INJECTION SYSTEMS SEEMS TO FAIL QUITE FREQUENTLY ON THESE 2012 TACOMAS WITH LITTLE TO NO HELP FROM TOYOTA TO TAKE CARE OF THIS ISSUE AS A RECALL. THESE ARE KNOWN TO FAIL RIGHT AFTER YOUR OUT OF WARRANTY AND TO CHARGE IT'S LOYAL CUSTOMERS OVER $1000 FOR A PART THAT SHOULD NOT FAIL OR A PART THAT SHOULD BE COVERE…
Read full complaint
THE SECONDARY AIR INJECTION SYSTEMS SEEMS TO FAIL QUITE FREQUENTLY ON THESE 2012 TACOMAS WITH LITTLE TO NO HELP FROM TOYOTA TO TAKE CARE OF THIS ISSUE AS A RECALL. THESE ARE KNOWN TO FAIL RIGHT AFTER YOUR OUT OF WARRANTY AND TO CHARGE IT'S LOYAL CUSTOMERS OVER $1000 FOR A PART THAT SHOULD NOT FAIL OR A PART THAT SHOULD BE COVERED IS ABSURD. I HAVE BEEN A LOYAL TOYOTA CUSTOMER MY WHOLE LIFE BUT THE ISSUES OF THE TACOMA ARE MAKING ME RETHINK MY DECISIONS AS AN AUTOMOTIVE CONSUMER
NHTSA ODI #10871717
32,000 miles · Mar 9, 2016
Fuel/propulsion System
WHILE ON HIGHWAY DOING 65MPH, VEHICLE SLOWED TO 50, TO 40, TO 30, TO 20 BY ITSELF. PULLED OVER, PLACED BACK INTO GEAR, VEHICLE ONLY WENT 40 MPH DOWNHILL, 20 MPH UPHILL. DROVE TO TOYOTA DEALER WHO SAID THIS WAS THIRD TACOMA THIS WEEK WITH FAULTY SECOND AIR FUEL INJECTOR. NO RECALL YET, BUT 3 WEEKS FOR BACK ORDER OF PART. 43 OTHER…
Read full complaint
WHILE ON HIGHWAY DOING 65MPH, VEHICLE SLOWED TO 50, TO 40, TO 30, TO 20 BY ITSELF. PULLED OVER, PLACED BACK INTO GEAR, VEHICLE ONLY WENT 40 MPH DOWNHILL, 20 MPH UPHILL. DROVE TO TOYOTA DEALER WHO SAID THIS WAS THIRD TACOMA THIS WEEK WITH FAULTY SECOND AIR FUEL INJECTOR. NO RECALL YET, BUT 3 WEEKS FOR BACK ORDER OF PART. 43 OTHERS BEFORE MY PART REQUEST. SAME PART ON RECALL FOR TUNDRA MODEL. SAFETY WAS COMPROMISED ON HIGHWAY BECAUSE OF AUTOMATIC DECELERATION
NHTSA ODI #10845669
3,000 miles · Nov 6, 2015
Electrical SystemFuel/propulsion System
FUEL SYSTEM CAN BE HEARD HOURS AFTER THE TRUCK IS PARKED, FEW TIMES A WEEK AND SOMETIMES DAILY .AND RUNS 2 TO 15 MINUTES. CONTACTED DEALER AND SAYS IT NORMAL FOR FUEL EVAP TO DO A SYSTEM CHECK. ONGOING STARTED BEFORE 3000 MILES
NHTSA ODI #10788758
Official recalls
7Jul 3, 2017
Southeast Toyota Distributors, LLC (SET) is recalling certain 2011-2016 Toyota Tacoma and 4Runner vehicles equipped with accessory hood scoops installed by SET or SET dealers. The adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Consequence & remedy
Consequence: If the hood scoop detaches, it may become a road hazard, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. The recall began on September 1, 2017. Owners may contact SET customer service at 1-954-429-2000. SET's number for this recall is SET17B.
Additional source detail variants (2)
Equipment
Southeast Toyota Distributors, LLC (SET) is recalling certain 2011-2016 Toyota Tacoma and 4Runner vehicles equipped with accessory hood scoops installed by SET or SET dealers. The adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Consequence: If the hood scoop detaches, it may become a road hazard, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. The recall began on September 1, 2017. Owners may contact SET customer service at 1-954-429-2000. SET's number for this recall is SET17B.
Structure:body:hood:hinge And Attachments
Southeast Toyota Distributors, LLC (SET) is recalling certain 2011-2016 Toyota Tacoma and 4Runner vehicles equipped with accessory hood scoops installed by SET or SET dealers. The adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.
Consequence: If the hood scoop detaches, it may become a road hazard, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. The recall began on September 1, 2017. Owners may contact SET customer service at 1-954-429-2000. SET's number for this recall is SET17B.
Aug 4, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
Feb 12, 2014
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence & remedy
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Electronic Stability Control (esc)
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.
Consequence: If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.
Remedy: Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.
Oct 17, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2012-2013 Tacoma vehicles equipped with 18" Maverick Alloy Wheels. In the affected vehicles, the spare tire requires the use of a different style of lug nut to attach it to the vehicle than the other wheels use. These lug nuts were not provided with the vehicle.
Consequence & remedy
Consequence: If the spare tire/wheel is installed on the vehicle using the lug nuts from another wheel, damage to the wheel could result and may eventually lead to a loose wheel, increasing the risk of a crash.
Remedy: SET will notify owners, and dealers will: (a) Install a Warning Label on the spare tire/wheel, (b) supply a bag containing proper spare wheel lug nuts, and (c) place an Owner's Manual Addendum in the vehicle's glove box. The recall began on January 23, 2014. Owners may contact SET at 1-954-429-2000.
Apr 9, 2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Jan 16, 2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence & remedy
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Additional source detail variants (2)
Seats
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Apr 10, 2012
GULF STATES TOYOTA (GST) IS RECALLING CERTAIN MODEL YEAR 2012 TACOMA TRUCKS. THE TIRE AND LOADING INFORMATION PLACARD ON EACH VEHICLE CONTAINS INACCURATE SPARE TIRE SIZE AND COLD INFLATION PRESSURE INFORMATION. THUS, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110,TIRE SELECTION AND RIMS.
Consequence & remedy
Consequence: AN INCORRECT PLACARD COULD LEAD TO IMPROPER SPARE TIRE USE OR REPLACEMENT WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: GST WILL NOTIFY OWNERS, AND SEND EACH OWNER A CORRECTED PLACARD, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 5, 2012. OWNERS MAY CONTACT GULF STATES TOYOTA, INC. AT 1-713-744-3465.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.