NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
445 reportsMileage unknown · Feb 8, 2024
Unknown Or Other
Following an oil change my mechanic expressed concern about the amount of rust and damage from the rust on my vehicle frame. Due to his concern, I set up an evaluation appointment with the Arlington Heights (IL) Toyota dealer. They evaluated, videotaped the inspection which showed several rusted-through spots, and said it looked…
Read full complaint
Following an oil change my mechanic expressed concern about the amount of rust and damage from the rust on my vehicle frame. Due to his concern, I set up an evaluation appointment with the Arlington Heights (IL) Toyota dealer. They evaluated, videotaped the inspection which showed several rusted-through spots, and said it looked very serious and unsafe. The dealer then contacted the Toyota corporate office who refused to do anything. I'm the second owner. I have all the paperwork from the original owner who followed the rusty frame protocol properly (take it to the dealer who sprays it with rust preventative or replaces the frame). The frame was sprayed by Toyota while he had it and it did not work. There are now several rusted-through areas in the frame and I fear for the safety of myself and my family if we were involved in a crash and the frame were to collapse.
NHTSA ODI #11570728
Mileage unknown · Nov 30, 2023
Service BrakesStructure
The brakes completely failed on the vehicle. When inspected the main brake line was found damaged due to the frame of the car being totally corroded and shifting of the mechanical structure. If I were not quick in getting the emergency brake applied, we would have had an uncontrolled crash in traffic and could have potentially…
Read full complaint
The brakes completely failed on the vehicle. When inspected the main brake line was found damaged due to the frame of the car being totally corroded and shifting of the mechanical structure. If I were not quick in getting the emergency brake applied, we would have had an uncontrolled crash in traffic and could have potentially been killed. There were no warnings or lights that came on in the vehicle prior to the complete brake failure. The car is currently at a local repair shop and can be inspected if necessary. The frame corrosion was so bad on this car that the repair shop was not comfortable even putting it on a lift as they felt the car frame would break.
NHTSA ODI #11557770
Mileage unknown · Nov 13, 2023
Suspension
brought my tacoma truck in for trade in at toyota dealership,after they inspected vehicle,they told me frame on truck is rusted so bad that it has to be replaced.i have been driving this truck pulling my boat and hauling heavy loads.i had no ideal that frame was so rotted and is a saftey hazard on the road.now i have truck nobod…
Read full complaint
brought my tacoma truck in for trade in at toyota dealership,after they inspected vehicle,they told me frame on truck is rusted so bad that it has to be replaced.i have been driving this truck pulling my boat and hauling heavy loads.i had no ideal that frame was so rotted and is a saftey hazard on the road.now i have truck nobody wants and will cost to much to repair.truck is only 2008 with 111000 miles on it! how can this be?as far as i know there where no recalls on the frame sent to me.don't know what to do.wont be buying toyota any more.
NHTSA ODI #11554779
Mileage unknown · Oct 15, 2023
Structure
Frame is rusted. Lancaster Toyota Mazda body shop recommended the frame be replaced. They will not repair it.
NHTSA ODI #11550001
243,000 miles · Oct 13, 2023
StructureSuspension
The contact owns a 2008 Toyota Tacoma. The contact stated that the subframe of the vehicle was significantly corroded. The contact stated that the passenger's side of the vehicle was warped, which made the vehicle unsafe to drive. An unknown dealer was notified of the failure and informed the contact that the VIN was not include…
Read full complaint
The contact owns a 2008 Toyota Tacoma. The contact stated that the subframe of the vehicle was significantly corroded. The contact stated that the passenger's side of the vehicle was warped, which made the vehicle unsafe to drive. An unknown dealer was notified of the failure and informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and informed the contact that the vehicle had passed inspection when an unknown recall repair was previously performed on the vehicle in 2016. The failure mileage was approximately 243,000.
NHTSA ODI #11549849
Mileage unknown · Oct 3, 2023
Structure
I purchased this vehicle used several years ago. I recently took it in for an oil change and my mechanic advised me that the underside was rusting out. There was a recall for this issue but it has expired and Toyota has refused to do anything.
NHTSA ODI #11548017
Mileage unknown · Sep 7, 2023
Air BagsElectrical System
First notices that volume control on steering wheel and temp and directional display stopped working about a year ago. Now air bag light stays on when car is started and alarm for seat belts quit working.
NHTSA ODI #11543109
Mileage unknown · Aug 26, 2023
Suspension
08trd Tacoma Frame rust bad I bought it in 2011 certified used vehicle. I 2015 had frame inspection They undercoat It has 66000 miles on it Tues this week asked mechanic change oil He said the frame is rusted bad Contacted Toyota that as soon as I got home, I had the email copy I sent to you. She gave me a little glimmer …
Read full complaint
08trd Tacoma Frame rust bad I bought it in 2011 certified used vehicle. I 2015 had frame inspection They undercoat It has 66000 miles on it Tues this week asked mechanic change oil He said the frame is rusted bad Contacted Toyota that as soon as I got home, I had the email copy I sent to you. She gave me a little glimmer of hope she has a one. Oh I do bring it to the Smithtown dealership which is right down the block and left and I did the next one and I did and it’s documented, the rust is so bad he gonna pass inspection in December I take care of my vehicles yesterday got call Toyota declined to help I’m in shock past time They oct 2020 I’m so disappointed plz help truck is like new since bought 2011 to now I put 40000 Avg 4000 year im local
NHTSA ODI #11540886
Mileage unknown · Aug 14, 2023
Structure
While driving at unknown low speed on 2 lane road, contact observed bed of truck rise vertically in the air, within the frame of rearview mirror. Upon pulling over, further investigation indicated that indeed, while adding body weight to the truck bumper, rear of bed, was more than sufficient to cause the front of the bed to ri…
Read full complaint
While driving at unknown low speed on 2 lane road, contact observed bed of truck rise vertically in the air, within the frame of rearview mirror. Upon pulling over, further investigation indicated that indeed, while adding body weight to the truck bumper, rear of bed, was more than sufficient to cause the front of the bed to rise. Truck was later moved to dealer location, Courtesy Toyota, Brandon, FL, for inspection. Inspection by Toyota indicated both frame rails were completely severed by corrosion. Truck was tagged out of service and not safe to operate by the OEM. This unit was inspected by same Toyota dealership in Jan 2019, for extended frame corrosion warranty program, and was passed for frame rail replacement as it did not meet the failure criteria of the incorrectly written test. This criteria DOES NOT address all failure modes, nor a normal population of "most likely" failure modes, thus allowing the OEM to side-step responsibility. placing consumers at great risk for bodily harm for both vehicle owners/operators, and the general public in proximity to the traveling vehicle. Known Quality issue. Known Safety issue. Harm is imminent. Financial damage imminent.
NHTSA ODI #11538532
Mileage unknown · Jul 26, 2023
Structure
Red paint peeling off
NHTSA ODI #11534675
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 4, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration