2008 Toyota Tacoma

The brakes on my 2008 Toyota Tacoma were failing so I took it to a mechanic, who said that the brake lines had failed and needed to be replaced. However, he said that it wasn't worth putting any money into the truck, as the leaf springs were corroded along with the frame, which could crack apart at any time. As we only purchased the truck one year ago, he advised us to take it to the dealership where we purchased it, and informed us of the recalls on both of these issues. I spoke with the mechanic at the dealership because when we purchased the vehicle, they did the inspection and said that everything was fine. When I asked the mechanic about this, he said that he didn't have anything to do with sales and we needed to speak to the owner (who is out on medical leave). The mechanic said that when the dealership purchased the vehicle at auction, the frame must have been undercoated and so they missed it. When I mentioned the recall, he told me to call Toyota. I have checked the VIN and it is not showing an open recall for this vehicle. However, it is experiencing the exact same safety issues as the recalls for leaf spring corrosion and frame rust and cracking. I have only had this truck for a little over one year and do not know what to do. It is too dangerous to drive as it could cause a serious accident. Neither the dealership nor Toyota want to take responsibility and offer a solution.

Toyota has had a long history of excessive frame rust. This truck has excessive frame rust. There was a recall to fix this frame rust and my truck has not been fixed. Toyota will not fix the current recall for the spring replacement because of the frame rust. My life and my children’s lives are in danger due to the possible leaf suspension failure that may puncture the gas tank.

Hope to be able to get this solved. My 2008 Toyota Tacoma had a recall with the previous owner but they didn't take it in. On the rear section of the frame on the inside beside the gas tank and on the driver side there is a lot of rust there the frame has expanded and is starting to go all away through also same place back beside the muffler on the passenger side. Also there are a few spots on the front part of the frame under the fire wall area on both sides. I had a recall on the truck and took it in and had it fixed which Toyota replaced the leaf springs on both sides and hardware. Says there was a recall when the previous owner had the truck. Will they validate that still? I've owned the truck almost a year now. But it's getting worse. Within a year I'm gonna have to park it because it liable to possible break in half. Toyota should of let me known when they had it on the lift replacing the rear leaf springs. Not my fault the previous owner didn't take the truck in to have them look at it.

In March of 2008, I purchased a new 2008 Toyota Tacoma (VIN: [XXX] ) from Orleans Toyota in Massachusetts. In July 2010 I re-located to New Hampshire and registered the vehicle in that state in July 2010 where I have resided since. The odometer reading at that time was 21,220 Miles. In September of 2014, I received a safety recall notice from Toyota regarding a potential frame corrosion problem. I scheduled an appointment with the local Toyota dealership in East Swanzy NH on September 12, 2014 to address this issue. The odometer reading at the time was 82,068 miles. There were two remediation options, as set by Toyota: A.Inspect frame, clean, and apply CRC if no perforations were found B.Inspect frame and if perforations found, replace the frame. Both of these options were intended to mitigate any and all risk of future corrosion of the frame that was a result of a known vehicle design flaw. Toyota chose to apply the CRC. I therefore assumed that the frame was intact at that point in time and the issue had been resolved. Between September 2014 and December 2019, I drove the vehicle 62 miles a day on [XXX] in NH commuting between Hillsboro and Keene for all 12 months of the year. This represents a total mileage of 87,939 (36,054 of which can be considered winter driving during the months of November thru March). The Toyota dealership inspected and passed the vehicle in 2023 without mention of any issue regarding the frame. On [XXX] of this year, the Toyota dealership rejected the state inspection due to severe frame corrosion (to the point that the technician felt it was a risk putting the truck on a lift). It should be noted that this vehicle has only been driven 3,000 since it passed inspection in 2023, none of which were during Winter months. In addition, there are no visible signs of rust or corrosion on the exterior of the vehicle. The above points to the fact that the CRC application in 2014 was ineffective in mitigating the safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

brought my tacoma truck in for trade in at toyota dealership,after they inspected vehicle,they told me frame on truck is rusted so bad that it has to be replaced.i have been driving this truck pulling my boat and hauling heavy loads.i had no ideal that frame was so rotted and is a saftey hazard on the road.now i have truck nobody wants and will cost to much to repair.truck is only 2008 with 111000 miles on it! how can this be?as far as i know there where no recalls on the frame sent to me.don't know what to do.wont be buying toyota any more.

The contact owns a 2008 Toyota Tacoma. The contact stated that the subframe of the vehicle was significantly corroded. The contact stated that the passenger's side of the vehicle was warped, which made the vehicle unsafe to drive. An unknown dealer was notified of the failure and informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and informed the contact that the vehicle had passed inspection when an unknown recall repair was previously performed on the vehicle in 2016. The failure mileage was approximately 243,000.

08trd Tacoma Frame rust bad I bought it in 2011 certified used vehicle. I 2015 had frame inspection They undercoat It has 66000 miles on it Tues this week asked mechanic change oil He said the frame is rusted bad Contacted Toyota that as soon as I got home, I had the email copy I sent to you. She gave me a little glimmer of hope she has a one. Oh I do bring it to the Smithtown dealership which is right down the block and left and I did the next one and I did and it’s documented, the rust is so bad he gonna pass inspection in December I take care of my vehicles yesterday got call Toyota declined to help I’m in shock past time They oct 2020 I’m so disappointed plz help truck is like new since bought 2011 to now I put 40000 Avg 4000 year im local

I brought my 2008 Toyota Tacoma in and they did an undercoating recall. Since then I've had to replace a broken leaf spring and brake line, and a few weeks ago, brought it in to a Toyota dealership to have a wheel bearing/ axlereplaced that had rusted. On the paper documentation nothing was mentioned regarding the frame deterioration. Recently brought it in for an exhaust replacement and was shown how dangerous the frame was, and that it was too far gone to weld anything to, as "there's nothing to weld to" (and no shop would assume liability for such a fix)by the muffler shop technician. I called the Toyota dealership and was told to bring it somewhere to have a plate welded . Told him that wasn't an option.