NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
76 reportsClear category filterMileage unknown · Aug 3, 2021
Structure
My Toyota was denied needing a frame replacement. I regret not taking it to a different dealership because it was very rusted! The corrosion compound was applied and now at 126,000 miles, you can literally rip handfuls of the frame off the truck. The frame is to the point of it not being safe to drive. I fear that it could defi…
Read full complaint
My Toyota was denied needing a frame replacement. I regret not taking it to a different dealership because it was very rusted! The corrosion compound was applied and now at 126,000 miles, you can literally rip handfuls of the frame off the truck. The frame is to the point of it not being safe to drive. I fear that it could definitely break in half while driving it. Has any other people reported rust coming through the spray on corrosion compound? It definitely did not solve the problem on my Toyota Tacoma.
NHTSA ODI #11427661
Mileage unknown · Jun 29, 2021
Structure
This vehicle falls under a Toyota "Limited Service Campaign" based on the VIN. Because the vehicle is registered in Arizona my parents never received a notice of this campaign. But this vehicle is now in Indiana and is exposed to issues related to this campaign (Frame Rust - Cold Climate states). To base a campaign on state r…
Read full complaint
This vehicle falls under a Toyota "Limited Service Campaign" based on the VIN. Because the vehicle is registered in Arizona my parents never received a notice of this campaign. But this vehicle is now in Indiana and is exposed to issues related to this campaign (Frame Rust - Cold Climate states). To base a campaign on state registration is short sighted and wrong. My parents still reside in Arizona and the vehicle is registered there but it will remain in Indiana as their vehicle for when they visit. I contacted Toyota and asked them to inspect and apply the CRC per the campaign but they have refused. Would ask the NTSB to review this campaign and cover all customer vehicles that might have exposure to cold climate not limited to registration state. If we would have been made aware of this we would have acted sooner but again, no one from Toyota informed us of the issue.
NHTSA ODI #11422820
14,000 miles · May 5, 2021
Structure
GAS TANK SUPPORT RUSTED OUT CAUSING THE GAS TANK TO FALL OFF THE TRUCK
NHTSA ODI #11415217
Mileage unknown · May 4, 2021
StructureSuspension
FOYOTA TACOMA 2008 TRUCK, FRAME RUST HAS BROKEN INTO.
NHTSA ODI #11415204
264,000 miles · Feb 6, 2021
Structure
I PURCHASED MY 2008 TOYOTA TACOMA IN 2010 WITH 39,000 MILES ON IT. IN EARLY 2018, I RECEIVED A NOTICE FROM TOYOTA THAT MY TRUCK NEEDED TO HAVE THE FRAME INSPECTED. I SCHEDULED AN APPOINTMENT WITH THE TOYOTA DEALERSHIP IN LEESBURG, VA AND HAD THE FRAME INSPECTED AND TREATED WITH SOME TYPE OF BLACK TREATMENT. THIS SUBSTANCE NE…
Read full complaint
I PURCHASED MY 2008 TOYOTA TACOMA IN 2010 WITH 39,000 MILES ON IT. IN EARLY 2018, I RECEIVED A NOTICE FROM TOYOTA THAT MY TRUCK NEEDED TO HAVE THE FRAME INSPECTED. I SCHEDULED AN APPOINTMENT WITH THE TOYOTA DEALERSHIP IN LEESBURG, VA AND HAD THE FRAME INSPECTED AND TREATED WITH SOME TYPE OF BLACK TREATMENT. THIS SUBSTANCE NEVER COMPLETELY ADHERED TO THE FRAME AND WASHED OFF. THIS IS APPARENT IN THE ATTACHED PHOTOS. I EXPRESSED A CONCERN ABOUT REOCCURRING RUST IN APRIL 2020 WITH THE TOYOTA DEALER AND THEY DIRECTED ME TO CALL TOYOTA DIRECTLY. I THEN OPENED A CASE WITH TOYOTA, CASE #2004082516 AND WAS UNABLE TO GET THE FRAME RE-INSPECTED DUE TO COVID. RECENTLY IN 2021 DURING A REGULAR SERVICE, THE TECHNICIAN BROUGHT TO MY ATTENTION LARGE GAPING HOLES IN THE FRAME. THE TECHNICIAN SAID THAT THE FRAME WOULD NOT PASS VA STATE SAFETY INSPECTION WHICH IS DUE IN APRIL 2021. I AM NOW LEFT WITH A VEHICLE THAT IS NOT SAFE TO DRIVE AND OF NO VALUE.
NHTSA ODI #11394953
199,773 miles · Feb 3, 2021
Structure
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER TAKING THE VEHICLE IN FOR INSPECTION AT AUTO NATION, HE WAS INFORMED THAT THE VEHICLE'S SUBFRAME WAS CORRODED. THE VEHICLE WAS COATED WITH A PROTECTIVE SEALANT TO AVOID FURTHER CORROSION. THE CONTACT STATED THAT HE NOTICED MORE CORROSION TO THE VEHICLE. THE…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER TAKING THE VEHICLE IN FOR INSPECTION AT AUTO NATION, HE WAS INFORMED THAT THE VEHICLE'S SUBFRAME WAS CORRODED. THE VEHICLE WAS COATED WITH A PROTECTIVE SEALANT TO AVOID FURTHER CORROSION. THE CONTACT STATED THAT HE NOTICED MORE CORROSION TO THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER MALLOY TOYOTA (400 WEEMS LN #3609, WINCHESTER, VA 22601; (540) 678-1791) WHO INFORMED THE CONTACT THAT THE SUBFRAME HAD ROTTED THROUGH AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 199,773.
NHTSA ODI #11394529
147,000 miles · Dec 16, 2020
StructureUnknown Or Other
TOOK TRUCK IN FOR INSPECTION MECHANIC SAID FRAME IS ROTTED OUT TOYOTA SAID THAT THERE'S NO RECALL PENDING ON THIS VEHICLE
NHTSA ODI #11383613
113,200 miles · Aug 26, 2020
Structure
I HAD 2 PREVIOUS RECALLS ON THIS VEHICLE TO CHECK FOR A RUSTED FRAME. . . . WHEN I PURCHASED THIS VEHICLE I HAD IT UNDER COATED AND OF COURSE IT PASSED THE TWO INSPECTIONS. .THE UNDERCOATING HAS NOW FLAKED OFF SO NOW THE FRAME HAS RUSTED THROUGH . . I TOOK IT TO A BODY SHOP AND HAD A PATCH WELDED ON TO THE FRAME. . . TOYOTA N…
Read full complaint
I HAD 2 PREVIOUS RECALLS ON THIS VEHICLE TO CHECK FOR A RUSTED FRAME. . . . WHEN I PURCHASED THIS VEHICLE I HAD IT UNDER COATED AND OF COURSE IT PASSED THE TWO INSPECTIONS. .THE UNDERCOATING HAS NOW FLAKED OFF SO NOW THE FRAME HAS RUSTED THROUGH . . I TOOK IT TO A BODY SHOP AND HAD A PATCH WELDED ON TO THE FRAME. . . TOYOTA NOW SAYS THERE IS NO RECALL ON THIS VEHICLE FOR A RUSTED FRAME. . . I HAVE TO QUESTION THIS AFTER RECEIVING THE TWO PREVIOUS RECALLS. . .
NHTSA ODI #11351405
Mileage unknown · Aug 13, 2019
Structure
MY VEHICLE HAS A LOT OF RUST AREA ON THE BOTTOM FRAME. I AM UNABLE TO PUT A CARJACK TO LIFT THE VEHICLE UP WITHOUT THE FRAME BREAKING. I AM AFRAID IF I NEED TO SWITCH THE TIRE I WONT BE ABLE TO BECAUSE OF ALL THE RUST. I NEED TO PLACE A SIDE STEP RUNNING BOARD ON THIS VEHICLE BUT I AM AFRAID IT MAY BE TOO RUSTED TO HOLD IT. THER…
Read full complaint
MY VEHICLE HAS A LOT OF RUST AREA ON THE BOTTOM FRAME. I AM UNABLE TO PUT A CARJACK TO LIFT THE VEHICLE UP WITHOUT THE FRAME BREAKING. I AM AFRAID IF I NEED TO SWITCH THE TIRE I WONT BE ABLE TO BECAUSE OF ALL THE RUST. I NEED TO PLACE A SIDE STEP RUNNING BOARD ON THIS VEHICLE BUT I AM AFRAID IT MAY BE TOO RUSTED TO HOLD IT. THERE IS SOME RUST ON THE BODY AREA AND I WAS THINKING ABOUT FIXING IT MYSELF BUT THE FRAME MAYBE A LITTLE HARDER TO FIX IF I NEED TO REPLACE THESE PARTS.
NHTSA ODI #11243479
85,000 miles · Aug 14, 2018
StructureSuspension
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS TAKEN TO SERVCO AUTO KAUAI (2477 ULU MAIKA ST, LIHUE, HI 96766, 877-689-1808) WHERE THE TECHNICIAN DISQUALIFIED THE VEHICLE FOR THE RECALL REPAIR DUE TO AN AFTERMARKET LEVELING KIT BEING …
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS TAKEN TO SERVCO AUTO KAUAI (2477 ULU MAIKA ST, LIHUE, HI 96766, 877-689-1808) WHERE THE TECHNICIAN DISQUALIFIED THE VEHICLE FOR THE RECALL REPAIR DUE TO AN AFTERMARKET LEVELING KIT BEING INSTALLED. THE CONTACT STATED THAT THE FRAME WAS RUSTED AND THERE WERE HOLES UNDERNEATH THE FRONT DRIVER AND PASSENGER SEATS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.
NHTSA ODI #11119960
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Sep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Consequence & remedy
Consequence: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Remedy: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 4, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
Aug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
Consequence & remedy
Consequence: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Remedy: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Mar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Mar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
Consequence & remedy
Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration