2002 Toyota Tacoma

THE TOYOTA TACOMA HAD A REAR AXLE WRAP UP, THIS WAS WHERE THE TWO PIECE DRIVESHAFT BECOMES LOOSE AT THE SPLEEN AND CAUSED A CLUNG OR LOOSENESS IN THE DRIVE LINE, WHICH CAUSED UNDUE STRESS ON THE ENGINE AND THE TRANSMISSION, WHICH COULD CAUSE THE DRIVESHAFT TO BREAK AT THE YOKE AND FALL TO GROUND, CAUSING AN ACCIDENT. THIS WAS GETTING PROGRESSIVELY WORSE ON THE TRUCK. I HAVE TAKEN THE CAR UNDER WARRANTY TO THE DEALER. THEY DISMISSED IT AS NORMAL. THIS WAS NOT NORMAL. IT WAS A FLAW IN THE SPRINGS THEY USED ON THE TRUCK.*AK

CONSUMER COMPLAINT REGARDING SAFETY ISSUE WITH BALL JOINTS. *TS *** NO ANSWER REQUIRED*** UPDATED 11/7/2005 - THE CONSUMER HAD PROBLEMS WITH THE TOYOTA DEALER THEREFORE DECIDED TO TAKE HIS VEHICLE TO A NON-TOYOTA DEALER TO HAVE RECALL ON THE LOWER BALL JOINT REPAIRED (RECALL NUMBER 05V225000). THE CONSUMER REQUEST REIMBURSEMENT FORM THE MANUFACTURER SINCE HE HAD TO PAY FOR THE REPLACEMENT. *NM

INFO COPY LTR FWD TO TOYOTA REGARDING FRONT SUSPENSION LOWER BALL JOINT RECALL, CUSTOMER DISSATISFIED W/QUALITY OF CURRENT TOYOTA VEHICLES. *TS THE CONSUMER STATED HE EXPERIENCED STEERING PROBLEMS AND THE FRONT END OF THE VEHICLE WAS LOOSE. THE CONSUMER TRADED THE VEHICLE ON JUNE 4, 2005 AND 4 MONTHS SHE RECEIVED A RECALL LETTER IN THE MAIL. *JB

DT: THE CONSUMER STATED THAT 2002 TOYOTA TACOMA WAS INVOLVED IN A CRASH ON MAY 20, 2005. THE DRIVER HEARD NOISES IN THE FRONT END, LIKE A CLICKING SOUND. THE CONSUMER WAS MAKING A LEFT HAND TURN AND LOST CONTROL OF THE VEHICLE. THE VEHICLE FLIPPED UPON ITS SIDE. THE CONSUMER SUSTAINED SOME MINOR INJURIES. THE CONSUMER LATER RECEIVED NHTSA RECALL 05V225000 CONCERNING LOWER BALL JOINTS. THE CONSUMER CONTACTED THE MANUFACTURER, AND THEY SAID THEY WILL MAKE AN APPOINTMENT FOR THE PARTS TO BE REPLACED FROM THE RECALL, AND THEY WOULD DO THEIR OWN INSPECTION. TOYOTA CALLED THE CONSUMER TODAY WITH THE REPORT. THEY FOUND NOTHING WRONG WITH THE FRONT END OR THE BALL JOINTS. THE CONSUMER WAS UPSET THAT HE COULD NOT SEE THE JOINT BALLS THAT WERE REPLACED. HE THOUGHT THAT HE WAS CHEATED IN THE FACT THAT HE COULD NOT SEE THE JOINTS BEFORE TOYOTA TOOK THEM. THE CONSUMER WANTED TO DO HIS OWN INSPECTION ON THE PARTS. HE NOTICED THAT THERE WAS POWER STEERING FLUID LEAKING, AND HE THOUGHT THAT THE POWERING STEERING WAS UNDER STRESS. A POLICE AND INSURANCE REPORTS WERE TAKEN. . THE VEHICLE HAS NOT BEEN REPAIRED AS OF NOW. THE SPEED WAS BETWEEN 25-35 MPH WHEN THE CRASH OCCURRED.*AK

NO KNOWN EVENTS LEADING TO THE FAILURE. PROGRESSIVE, SUCCESSIVE FAILURE OF BOLTS HOLDING LEFT FRONT WHEEL ASSEMBLY AND SUSPENSION ARM TO THE TRUCK. THIS CAUSED SEPARATION OF MENTIONED MEMBER FROM THE VEHICLE RESULTING IN TOTAL LOSS OF CONTROL AND OVERTURNING OF SAID VEHICLE. THE VEHICLE WAS A TOTAL LOSS AS A RESULT OF THE INCIDENT.*AK

FOR THE LAST YEAR I HAVE BROUGHT TRUCK BACK TO SF TOYOTA DEALERSHIP FOR TRANSMISSION PROBLEMS , SUSPENSION PROBLEMS RATTLING DASH BOARD, SQUEAKING SOUNDS FROM SEAT AND FRONT BUSHINGS. ALL THESE PROBLEMS STILL HAVE NOT BEEN FIXED. AFTER 15 VISITS TO DEALERSHIP, SF TOYOTA LEFT SCRATCHES ON BODY AND LOST MUD FLAP. BODY NOW TILTED AFTER SERVICE. *NLM

BROUGHT TRUCK TO TOYOTA SERVICE FOR 5000 MILE SERVICE REPORTED AUTO TRANS JUMP IN GEAR SHIFT FROM 1ST TO SECOND (MECHANIC SAID NEEDED NEW TRANSMISSION, AFTER LEAVING SERVICE STATION NOTICED TRUCK WASN'T DRIVING PROPERLY BROUGHT TRUCK BACK MECHANIC SAID NEEDS NEW FRONT SHOCK AND REAR SHOCK. NOW IT DID NOT NEED NEW TRANSMISSION EVEN THOUGH IT STILL JUMPS FROM GEAR TO GEAR.