NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
50 reportsClear category filter81,937 miles · Jan 20, 2013
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
APPROACHING SLIGHT RIGHT TURN ON A PARK WAY AT ABOUT 40MPH,DOWN HILL OF THE RIGHT TURN SUDDENLY THE SLIP ICON LIGHT ON THE DASH BOARD WAS ON AND OFF WITH BEEPING SOUND ALARM AND OBSERVED GRINDING OR BRAKING SOUND ON THE VEHICLE WHICH MADE JERKING LIKE ON AND OFF POWER OF THE VEHICLE. ROAD CONDITION WAS DRY AND SUNNY AT ABOUT 11:…
Read full complaint
APPROACHING SLIGHT RIGHT TURN ON A PARK WAY AT ABOUT 40MPH,DOWN HILL OF THE RIGHT TURN SUDDENLY THE SLIP ICON LIGHT ON THE DASH BOARD WAS ON AND OFF WITH BEEPING SOUND ALARM AND OBSERVED GRINDING OR BRAKING SOUND ON THE VEHICLE WHICH MADE JERKING LIKE ON AND OFF POWER OF THE VEHICLE. ROAD CONDITION WAS DRY AND SUNNY AT ABOUT 11:30 AM. *TR
NHTSA ODI #10493530
80,000 miles · Apr 4, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS 2006 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE MERGING ONTO THE HIGHWAY AT 65 MPH, THE VEHICLE ABNORMALLY ACCELERATED TO 100 MPH. THE ACCELERATOR PEDAL HAD BECOME STUCK AND WOULD NOT RELEASE. THE CONTACT HAD TO REACH DOWN UNDER THE STEERING WHEEL AND RELEASE THE LODGED ACCELERATOR PEDAL, WHILE CONTINUING …
Read full complaint
TL* THE CONTACT OWNS 2006 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE MERGING ONTO THE HIGHWAY AT 65 MPH, THE VEHICLE ABNORMALLY ACCELERATED TO 100 MPH. THE ACCELERATOR PEDAL HAD BECOME STUCK AND WOULD NOT RELEASE. THE CONTACT HAD TO REACH DOWN UNDER THE STEERING WHEEL AND RELEASE THE LODGED ACCELERATOR PEDAL, WHILE CONTINUING TO MANEUVER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE FOR TEN DAYS BUT WAS UNABLE TO DIAGNOSE A FAILURE. THE MANUFACTURER WAS THEN NOTIFIED AND A COMPLAINT WAS FILED. THE MANUFACTURER SENT AN INVESTIGATOR TO FURTHER INSPECT THE FAILURE HOWEVER, WAS UNABLE TO DETERMINE A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #10454067
81,700 miles · Mar 9, 2011
Vehicle Speed Control
COMING UP TO AN INTERSECTION, CAR KEPT ACCELERATING AS I LIFTED MY FOOT OFF OF THE GAS PEDAL, HAD TO PUSH HARD ON THE BRAKE AS ENGINE CONTINUED TO REV, PLACED IN NEUTRAL, DEPRESSED GAS PEDAL A COUPLE MORE TIMES, ENGINE QUIT REVVING. DISCOVERED THAT ANCHORS FOR THE DRIVER'S SIDE FLOOR MAT HAD COME OUT OF THE CARPET AND ALLOWED T…
Read full complaint
COMING UP TO AN INTERSECTION, CAR KEPT ACCELERATING AS I LIFTED MY FOOT OFF OF THE GAS PEDAL, HAD TO PUSH HARD ON THE BRAKE AS ENGINE CONTINUED TO REV, PLACED IN NEUTRAL, DEPRESSED GAS PEDAL A COUPLE MORE TIMES, ENGINE QUIT REVVING. DISCOVERED THAT ANCHORS FOR THE DRIVER'S SIDE FLOOR MAT HAD COME OUT OF THE CARPET AND ALLOWED THE FLOOR MAT TO CREEP UP AFFECTING THE GAS PEDAL. REMOVED THE MAT, TOOK TO LOCAL TOYOTA DEALER WHO SAID THERE WAS NO RECALL REGARDING THE SIENNA FLOOR MATS, THE DEALER REPLACED THE 2 RINGS IN THE CARPET USED TO ANCHOR AT MY COST, ONE ANCHOR BECAME DISLODGED AGAIN WITHIN A DAY. SEEMS THAT THERE IS SOME TYPE OF DEFECT IN THE ENGINEERING OF THAT RING USED TO SANDWICH/SECURE INTO THE CARPET. *TR
NHTSA ODI #10386970
137,585 miles · Jul 21, 2010
Service Brakes, ElectricVehicle Speed Control
I WAS ATTEMPTING TO PARK MY 2006 TOYOTA SIENNA WHEN SUDDENLY THE ENGINE STARTED TO REV LOUDLY & THE CAR CONTINUED TO MOVE FORWARD, EVEN AS I FRANTICALLY APPLIED THE BRAKES. THE CAR WOULD NOT STOP BUT MY FAST-THINKING HUSBAND QUICKLY PUT THE CAR INTO NEUTRAL & THEN SHUT THE CAR OFF. WE DROVE TO OUR TOYOTA DEALER IN VINELAND, NJ…
Read full complaint
I WAS ATTEMPTING TO PARK MY 2006 TOYOTA SIENNA WHEN SUDDENLY THE ENGINE STARTED TO REV LOUDLY & THE CAR CONTINUED TO MOVE FORWARD, EVEN AS I FRANTICALLY APPLIED THE BRAKES. THE CAR WOULD NOT STOP BUT MY FAST-THINKING HUSBAND QUICKLY PUT THE CAR INTO NEUTRAL & THEN SHUT THE CAR OFF. WE DROVE TO OUR TOYOTA DEALER IN VINELAND, NJ, WHERE THEY PERFORMED DIAGNOSTIC TESTS BUT COULDN'T FIND ANYTHING WRONG. THEIR DETERMINATION WAS THAT IT MUST HAVE BEEN THE FLOOR MAT PRESSING ON THE ACCELERATOR. I AM SURE THAT THE MAT WAS NOT THE PROBLEM AND THAT TOYOTA IS ATTEMPTING TO COVER UP A PROBLEM WITH A CAR THAT IS NOT ALREADY ON THEIR RECALL LIST. *TR
NHTSA ODI #10344576
127,358 miles · May 25, 2010
Power TrainService Brakes, HydraulicVehicle Speed Control
I WAS DRIVING ON A STRAIGHT, LEVEL DRY ROAD WITH CRUISE CONTROL SET AT 58MPH. SUDDENLY CAR BEGAN TO DOWNSHIFT. ASSUMING TRANSMISSION PROBLEM I DISENGAGED CRUISE CONTROL AND CAR ALMOST CAME TO A STOP. I PUSHED GAS PEDAL AND DROVE IN LOW GEAR TO NEAREST PULL-OFF. DISCOVERED LEFT FRONT BRAKE WAS SMOKING. AFTER THINGS COOLED OF…
Read full complaint
I WAS DRIVING ON A STRAIGHT, LEVEL DRY ROAD WITH CRUISE CONTROL SET AT 58MPH. SUDDENLY CAR BEGAN TO DOWNSHIFT. ASSUMING TRANSMISSION PROBLEM I DISENGAGED CRUISE CONTROL AND CAR ALMOST CAME TO A STOP. I PUSHED GAS PEDAL AND DROVE IN LOW GEAR TO NEAREST PULL-OFF. DISCOVERED LEFT FRONT BRAKE WAS SMOKING. AFTER THINGS COOLED OFF I DROVE CAR IN LOW GEAR ABOUT 6 MILES TO LOCAL SERVICE STATION. MECHANIC FOUND ALL BRAKES LOCKED AND REMOVED ALL WHEELS. HE INSPECTED ALL ROTORS, CALIPERS BRAKE LINES, ETC AND FOUND NO PROBLEMS. (I HAD NEW BRAKES INSTALLED AT DEALERSHIP ABOUT 4 MONTHS EARLIER.) WHEN MECHANIC MANIPULATED LEFT FRONT CALIPER ALL BRAKES DISENGAGED. MECHANIC FOUND BRAKE FLUID LEVEL WAS NORMAL. I'VE DRIVEN CAR ABOUT 500 MILES SINCE PROBLEM OCCURRED WITH NO PROBLEMS. I DON'T USE CRUISE CONTROL OFTEN - AND HAVEN'T USED IT SINCE PROBLEM OCCURRED. I'M WONDERING IF PROBLEM IS WITH CRUISE CONTROL RATHER THAN BRAKES?? THIS COULD HAVE BEEN A DISASTER IF IT HAPPENED ON A FREEWAY AT HIGHER SPEEDS! *TR
NHTSA ODI #10332104
Mileage unknown · Apr 28, 2010
Vehicle Speed Control
2006 TOYOTA SIENNA CONCERN *GR THE CONSUMER STATED THE VEHICLE SEEMED TO TRAVEL EXTREMELY FAST EVEN THOUGH SHE WAS DRIVING BETWEEN 60-65 MPH.
NHTSA ODI #10327451
26,500 miles · Mar 16, 2010
Vehicle Speed Control
WHEN STARTING TO ACCELERATE FROM A STOP AT A LIGHT, MY TOYOTA SIENNA SUDDENLY BOLTED FORWARD AS IF A BOULDER HAD BEEN DROPPED ON THE ACCELERATOR. I BRAKED AS HARD AS I COULD, BUT WAS ONLY ABLE TO KEEP THE SPEED DOWN TO ABOUT 40-45 MPH. EVENTUALLY, IT EITHER IT LET UP ON ITS OWN, OR I SHIFTED INTO NEUTRAL AND SLOWED, I AM NOT S…
Read full complaint
WHEN STARTING TO ACCELERATE FROM A STOP AT A LIGHT, MY TOYOTA SIENNA SUDDENLY BOLTED FORWARD AS IF A BOULDER HAD BEEN DROPPED ON THE ACCELERATOR. I BRAKED AS HARD AS I COULD, BUT WAS ONLY ABLE TO KEEP THE SPEED DOWN TO ABOUT 40-45 MPH. EVENTUALLY, IT EITHER IT LET UP ON ITS OWN, OR I SHIFTED INTO NEUTRAL AND SLOWED, I AM NOT SURE WHICH -- IT HAPPENED SO FAST. I IMMEDIATELY GOT OUT OF MY CAR AND LOOKED TO SEE IF ANYTHING WAS ON THE ACCELERATOR, BUT THERE WAS NOTHING. I DO HAVE FLOOR MATS, BUT THEY ARE CUT TO AVOID THE PEDALS AND IN FACT WERE NOT CAUGHT ON THE PEDALS. THIS IS THE ONE AND ONLY TIME IT HAS HAPPENED. I REPORTED IT TO TOYOTA BUT THEY INFORMED ME THAT SIENNAS DO NOT HAVE THE PART THAT IS CAUSING THE SUDDEN ACCELERATION PROBLEM. *TR
NHTSA ODI #10320233
68,000 miles · Mar 12, 2010
Vehicle Speed Control
I WAS GOING DOWN AN OFF RAMP IN MY SIENNA, BRAKING GRADUALLY AS I CAME TO THE BOTTOM OF THE RAMP. THERE WAS ANOTHER CAR STOPPED ABOUT 6 FT AHEAD OF ME. I STILL HAD MY FOOT ON THE BRAKE WHEN THE ENGINE SURGED AND THE VAN LURCHED FORWARD. I STOMPED DOWN ON THE BRAKE AND THE VAN DID STOP BEFORE IT HIT THE CAR IN FRONT OF ME. I HAVE…
Read full complaint
I WAS GOING DOWN AN OFF RAMP IN MY SIENNA, BRAKING GRADUALLY AS I CAME TO THE BOTTOM OF THE RAMP. THERE WAS ANOTHER CAR STOPPED ABOUT 6 FT AHEAD OF ME. I STILL HAD MY FOOT ON THE BRAKE WHEN THE ENGINE SURGED AND THE VAN LURCHED FORWARD. I STOMPED DOWN ON THE BRAKE AND THE VAN DID STOP BEFORE IT HIT THE CAR IN FRONT OF ME. I HAVE TAKEN THE VAN INTO THE LOCAL DEALER (TOYOTA OF KNOXVILLE) BUT THEY COULD FIND NO PROBLEMS. I HAVE ALSO REPORTED THE INCIDENT TO THE TOYOTA CONSUMER HOTLINE. *TR
NHTSA ODI #10319357
50,000 miles · Mar 9, 2010
Vehicle Speed ControlCrash
THE ACCIDENT HAPPENED 3/9/2010. THE ACCIDENT INVOLVES OUR 2006 TOYOTA SIENNA... THERE WERE TWO ADULTS AND THREE SMALL CHILDREN IN THE VAN. MY HUSBAND, WHO WAS DRIVING, SLOWED DOWN TO MAKE A RIGHT HAND TURN INTO A GAS STATION. WHILE HE WAS TURNING... THE VAN ACCELERATED AT A HIGH SPEED... MY HUSBAND TRIED TO APPLY BRAKES TO NO AV…
Read full complaint
THE ACCIDENT HAPPENED 3/9/2010. THE ACCIDENT INVOLVES OUR 2006 TOYOTA SIENNA... THERE WERE TWO ADULTS AND THREE SMALL CHILDREN IN THE VAN. MY HUSBAND, WHO WAS DRIVING, SLOWED DOWN TO MAKE A RIGHT HAND TURN INTO A GAS STATION. WHILE HE WAS TURNING... THE VAN ACCELERATED AT A HIGH SPEED... MY HUSBAND TRIED TO APPLY BRAKES TO NO AVAIL. WE SMASHED INTO A PARKED CAR (WITH OWNER STANDING NEXT TO IT PUMPING GAS) AT THE GAS STATION PUMP AND THEN THE VAN CONTINUED TO GO A BIT BEFORE SLOWING DOWN AT A SNOW BERM. LUCKILY NO ONE WAS BADLY INJURED. *TR
NHTSA ODI #10318226
10 miles · Mar 9, 2010
Electrical SystemPower TrainStructure
TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE DRIVER STATED THAT WHILE DRIVING 10 MPH IN AN ATTEMPT TO INCREASE SPEED, THE VEHICLE BEGAN TO HESITATE AND SURGE. THE DEALER STATED THAT THERE WAS NOTHING THEY COULD DO TO ASSIST HIM SINCE THE FAILURE WAS ELECTRICAL WHICH WAS ALSO A NORMAL FUNCTION OF THE VEHICLE. THE FAILURE MILEAG…
Read full complaint
TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE DRIVER STATED THAT WHILE DRIVING 10 MPH IN AN ATTEMPT TO INCREASE SPEED, THE VEHICLE BEGAN TO HESITATE AND SURGE. THE DEALER STATED THAT THERE WAS NOTHING THEY COULD DO TO ASSIST HIM SINCE THE FAILURE WAS ELECTRICAL WHICH WAS ALSO A NORMAL FUNCTION OF THE VEHICLE. THE FAILURE MILEAGE WAS 10 AND THE CURRENT MILEAGE WAS 75,000. THE CONSUMER STATED WHEN SLOWING DOWN BETWEEN 5- 10 MPH AND THEN SPEEDING BACK UP AGAIN, THE VAN WOULD HESITATE AND THEN SURGE FORWARD TO THE POINT OF JERKING THE CONSUMERS NECK. THE VEHICLE WOULD SLOW DOWN ONCE THE ACCELERATOR WAS RELEASED. ALSO, THE DRIVERS SIDE DOOR WAS EXHIBITING A POPPING/SCRAPPING NOISE WHEN IT WAS BEING OPENED OR CLOSED. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THERE WAS A RECALL REGARDING THE THINNESS OF METAL WHICH ALLOWED THE CRACKING OF THE METAL WHERE THE DOOR STOP WAS ATTACHED TO THE DOOR. UPDATED 04/21/10
NHTSA ODI #10317971
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration