IllustrationTL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 10V16000 (STRUCTURE) BUT WAS ADVISED BY THE DEALER AND MANUFACTURER THAT THE PARTS NEEDED TO COMPLETE THE REPAIR WERE NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
2006 Toyota Sienna
Owner reports · Recalls · Investigations
More warning signs than most Sienna years
Owner complaints for the 2006 Toyota Sienna are substantially higher than the model-year median of 183.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sienna years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1000–25K
14425–50K
19150–75K
17875–100K
142100–150K
65150K+
820 reports with mileage · 197 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 307 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 261 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 85 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports2 fire reports37 injury reports
Structure complaints
261 reportsTL* THE CONTACT OWNS 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE REAR HATCH STRUTS FAILED TO SUSTAIN THE HATCH AND CAUSED THE HATCH TO HIT THE CONTACT'S HEAD. THE CONTACT STATED THAT SHE DID NOT SUFFER INJURIES TO THE HEAD. THE DOOR HATCH WAS NOT REPLACED. THE MANUFACTURER ADVISED THAT THE WARRANTED REPAIR WAS EXPIRED. THE A…
Read full complaint
TL* THE CONTACT OWNS 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE REAR HATCH STRUTS FAILED TO SUSTAIN THE HATCH AND CAUSED THE HATCH TO HIT THE CONTACT'S HEAD. THE CONTACT STATED THAT SHE DID NOT SUFFER INJURIES TO THE HEAD. THE DOOR HATCH WAS NOT REPLACED. THE MANUFACTURER ADVISED THAT THE WARRANTED REPAIR WAS EXPIRED. THE APPROXIMATE FAILURE MILEAGE WAS 76,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 89,000.
SINCE 2012, THE FRONT PASSENGER'S DOOR HAS MADE A LOUD POPPING, CRACKING SOUND EVERY TIME IT IS OPENED OR CLOSED. TOYOTA DEALER INFORMED ME THE DOOR WELD IS CRACKED AND THE ENTIRE DOOR MUST BE REMOVED FOR A NEW WELD AND PAINT JOB AT A BODY SHOP. DEALER ALSO SHOWED ME A TOYOTA WARRANTY COVERAGE ENHANCEMENT FOR THIS PROBLEM (THE …
Read full complaint
SINCE 2012, THE FRONT PASSENGER'S DOOR HAS MADE A LOUD POPPING, CRACKING SOUND EVERY TIME IT IS OPENED OR CLOSED. TOYOTA DEALER INFORMED ME THE DOOR WELD IS CRACKED AND THE ENTIRE DOOR MUST BE REMOVED FOR A NEW WELD AND PAINT JOB AT A BODY SHOP. DEALER ALSO SHOWED ME A TOYOTA WARRANTY COVERAGE ENHANCEMENT FOR THIS PROBLEM (THE "DOOR CHECK MOUNTING PANEL," POL07-04, ISSUED 10/22/07), WHICH EXTENDS UP TO 5 YEARS OR 100,000 MILES. I NEVER RECEIVED NOTICE OF THIS IN THE MAIL, AND IT DOES NOT APPEAR UNDER THE TSBS ON THE NHTSA SITE. MY VAN IS NO LONGER COVERED AT 110,000 MILES. NOTE: I HAD THIS SAME PROBLEM ON MY DRIVER'S SIDE DOOR AT ONLY 32,000 MILES, WHICH WAS REPAIRED UNDER WARRANTY. THAT MEANS BOTH MY FRONT DOORS HAVE HAD FAILED WELDS. THIS CLEARLY IS A MANUFACTURING DEFECT WHICH TOYOTA SHOULD COVER, REGARDLESS OF MILEAGE.
TWO ISSUES: (1) SINCE 2012, THE FRONT PASSENGER'S DOOR HAS MADE A LOUD POPPING, CRACKING SOUND EVERY TIME IT IS OPENED OR CLOSED. TOYOTA DEALER INFORMED ME THE DOOR WELD IS CRACKED AND THE ENTIRE DOOR MUST BE REMOVED FOR A NEW WELD AND PAINT JOB AT A BODY SHOP. DEALER ALSO SHOWED ME A TOYOTA WARRANTY COVERAGE ENHANCEMENT FOR TH…
Read full complaint
TWO ISSUES: (1) SINCE 2012, THE FRONT PASSENGER'S DOOR HAS MADE A LOUD POPPING, CRACKING SOUND EVERY TIME IT IS OPENED OR CLOSED. TOYOTA DEALER INFORMED ME THE DOOR WELD IS CRACKED AND THE ENTIRE DOOR MUST BE REMOVED FOR A NEW WELD AND PAINT JOB AT A BODY SHOP. DEALER ALSO SHOWED ME A TOYOTA WARRANTY COVERAGE ENHANCEMENT FOR THIS PROBLEM (THE "DOOR CHECK MOUNTING PANEL," POL07-04, ISSUED 10/22/07), WHICH EXTENDS UP TO 5 YEARS OR 100,000 MILES. I NEVER RECEIVED NOTICE OF THIS IN THE MAIL, AND IT DOES NOT APPEAR UNDER THE TSBS ON THE NHTSA SITE. MY VAN IS NO LONGER COVERED AT 110,000 MILES. NOTE: I HAD THIS SAME PROBLEM ON MY DRIVER'S SIDE DOOR AT ONLY 32,000 MILES, WHICH WAS REPAIRED UNDER WARRANTY. THAT MEANS BOTH MY FRONT DOORS HAVE HAD FAILED WELDS. THIS CLEARLY IS A MANUFACTURING DEFECT WHICH TOYOTA SHOULD COVER, REGARDLESS OF MILEAGE. (2) POWER SLIDING DOOR WILL NOT OPERATE WHEN INTERIOR BUTTONS OR KEY FOB BUTTONS ARE PUSHED. IT WILL OPEN MANUALLY, BUT IT STICKS AND REQUIRES A HARD PULL. DEALER ADVISES CABLING IS MALFUNCTIONING AND THE MOTOR IN THE MAIN CONTROL BOARD IS BAD. I WAS TOLD THE WARRANTY ENHANCEMENT FOR THE REAR SLIDING DOOR ASSEMBLIES AND POWER SLIDING DOOR ASSEMBLIES WILL COVER THE CABLES AND LATCH, BUT DOES NOT COVER THE MOTOR, THE MAIN CONTROL BOARD, OR THE LOCK! THIS IS A VERY COSTLY REPAIR. THESE COMPONENTS ARE DEFECTIVE AND SHOULD BE INCLUDED IN THE WARRANTY ENHANCEMENT. *TR
2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO DRIVER SIDE DOOR WELD FAILURE. *SMD THE CONSUMER STATED LAST WEEK, THE DRIVER SIDE DOOR DEVELOPED A POPPING NOISE THAT OCCURRED WHENEVER THE DOOR WAS OPENED OR CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE AN INSPECTION REVEALED THE SPOT WELDS HAD BROKEN AWAY FROM THE DOO…
Read full complaint
2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO DRIVER SIDE DOOR WELD FAILURE. *SMD THE CONSUMER STATED LAST WEEK, THE DRIVER SIDE DOOR DEVELOPED A POPPING NOISE THAT OCCURRED WHENEVER THE DOOR WAS OPENED OR CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE AN INSPECTION REVEALED THE SPOT WELDS HAD BROKEN AWAY FROM THE DOOR STRUCTURE. *JB
THE DOOR CHECK POCKET ON THE DRIVER'S SIDE DOOR BEGAN MAKING A POPPING SOUND. UPON FURTHER INSPECTION, IT WAS EVIDENT THAT THE SPOT WELDS ON THE POCKET CAME UNDONE. LOOKING INTO THE MATTER, IT BECAME APPARENT THAT THIS IS A KNOWN ISSUE FOR TOYOTA. THEY OFFERED A WARRANTY ENHANCEMENT OF 5 YEARS OR 100,000 MILES FOR THE ISSUE. …
Read full complaint
THE DOOR CHECK POCKET ON THE DRIVER'S SIDE DOOR BEGAN MAKING A POPPING SOUND. UPON FURTHER INSPECTION, IT WAS EVIDENT THAT THE SPOT WELDS ON THE POCKET CAME UNDONE. LOOKING INTO THE MATTER, IT BECAME APPARENT THAT THIS IS A KNOWN ISSUE FOR TOYOTA. THEY OFFERED A WARRANTY ENHANCEMENT OF 5 YEARS OR 100,000 MILES FOR THE ISSUE. UPON CONTACTING THE COMPANY AND DISCUSSING THE ISSUE, I WAS PROMPTLY TOLD THAT MY VEHICLE DOES NOT QUALIFY AND THAT THERE IS NOTHING TOYOTA IS WILLING TO DO FOR ME. I HAVE BEEN TOLD BY MULTIPLE PEOPLE AT THE NATIONAL HEADQUARTERS THAT THE DECISION HAS BEEN MADE AND THEY WILL NOT COMPENSATE ME FOR THIS FAILURE WHICH IS DUE TO THEIR FAULTY MANUFACTURING. *TR
LESS THAN A YEAR AGO A CREAKING NOISE TURN INTO A CRACKING NOISE AND NOW IS WORSE LIKE A POPPING SOUND THAT FEEL LIKE THE DOOR IS GOING TO FALL WHEN YOU TRY TO CLOSE IT AND WHEN YOU ARE IN THE HIGHWAY THE DOOR VIBRATES AND IT FEELS LIKE IS GOING TO FALL FROM THE VEHICLE. TOYOTA SEND A NOTICE TO EXTEND THE WARRANTY 5 YRS OR 1000…
Read full complaint
LESS THAN A YEAR AGO A CREAKING NOISE TURN INTO A CRACKING NOISE AND NOW IS WORSE LIKE A POPPING SOUND THAT FEEL LIKE THE DOOR IS GOING TO FALL WHEN YOU TRY TO CLOSE IT AND WHEN YOU ARE IN THE HIGHWAY THE DOOR VIBRATES AND IT FEELS LIKE IS GOING TO FALL FROM THE VEHICLE. TOYOTA SEND A NOTICE TO EXTEND THE WARRANTY 5 YRS OR 100000 AND MY MINI VAN MOSTLY IS USED IN THE WEEKENDS SO I HAVE ONLY ABOUT 60000K FOR A 8 YEARS OLD CAR (LOW MILEAGE USE). OF COURSE THE NOISE START TO HAPPEN JUST AFTER 5 YRS BUT LESS THAN 6 YRS OR 100000 MILES AND TOYOTA APPARENTLY DOES NOT COVER THE REPAIR. I'M WANDERING IF THE DOOR FALL OFF FROM THE CAR IN THE HIGHWAY CAUSING A MAJOR ACCIDENT WHO IS GOING TO BE RESPONSIBLE. THIS IS VERY COMMON PROBLEM OF A WELDING JOINT AND THIS SHOULD NOT BE HAPPENING IF PROPER WORK HAVE BEEN DONE. I INVITE YOU TAKE PROMPT ACTION AND PUSH TOYOTA FOR A RECALL REGARDING THE FRONT DOOR WELDING PROBLEM. COST OF REPLACEMENT IS ABOVE 2K. I HOPE TO HEARD SOON FROM YOU. THANKS *TR
NHTSA ACTION NUMBER : EA06020 THE REPLACEMENT STRUT FOR THE REAR LIFT GATE UNDER THE RECALL NHTSA ACTION NUMBER : EA06020 ARE FAILING AGAIN. THEY WERE ALREADY REPLACE ONCE UNDER THE RECALL. IF IT'S A NORMAL WEAR ITEM THEN SHOULD BE LISTED UNDER MAINTENANCE. *TR
RIGHT SIDE POWER SLIDING DOOR WILL NOT OPEN OR CLOSE ALL THE WAY. NEED EXTREME MANUAL PRESSURE TO FORCE IT TO CLOSE. TURNING OFF POWER FOR THE SLIDING DOOR STILL DOES NOT ALLOW IT TO BE CLOSED WITHOUT NEEDING EXTREME MANUAL PRESSURE. AT THIS POINT IN TIME, WE ARE ONLY USING THE LEFT PASSENGER SLIDING DOOR TO ENTER AND EXIT THE V…
Read full complaint
RIGHT SIDE POWER SLIDING DOOR WILL NOT OPEN OR CLOSE ALL THE WAY. NEED EXTREME MANUAL PRESSURE TO FORCE IT TO CLOSE. TURNING OFF POWER FOR THE SLIDING DOOR STILL DOES NOT ALLOW IT TO BE CLOSED WITHOUT NEEDING EXTREME MANUAL PRESSURE. AT THIS POINT IN TIME, WE ARE ONLY USING THE LEFT PASSENGER SLIDING DOOR TO ENTER AND EXIT THE VEHICLE. *TR
2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO DRIVERS SIDE DOOR ISSUES. *SMD THE CONSUMER STATED SEVERAL WEEKS AGO, THE DRIVER'S SIDE DOOR STARTED MAKING A POPPING NOISE WHEN IT WAS OPENED AND CLOSED. THE CONSUMER DID SOME RESEARCH, AND DISCOVERED THE ISSUE WAS DUE TO POOR ENGINEERING ON THE DOOR WELD, THAT COULD NOT STA…
Read full complaint
2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO DRIVERS SIDE DOOR ISSUES. *SMD THE CONSUMER STATED SEVERAL WEEKS AGO, THE DRIVER'S SIDE DOOR STARTED MAKING A POPPING NOISE WHEN IT WAS OPENED AND CLOSED. THE CONSUMER DID SOME RESEARCH, AND DISCOVERED THE ISSUE WAS DUE TO POOR ENGINEERING ON THE DOOR WELD, THAT COULD NOT STAND THE STRESS OF OPENING AND CLOSING. THE CONSUMER CALLED TOYOTA CUSTOMER CARE AND WAS REASSURED THEY WOULD BE ABLE HELP HIM. THEY INDICATED, THEY WERE AWARE OF THE ISSUE. AFTER SEVERAL PHONE CALLS AND DRIVING AROUND TO GET VARIOUS ESTIMATED, TOYOTA DECIDED THEY WERE NOT GOING TO ASSIST THE CONSUMER. THE PROBLEM HAS SINCE WORSENED AND NOW REQUIRES A COMPLETE DOOR REPLACEMENT.
Official recalls
1117V657000 · Power Train:automatic Transmission
Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
16V396000 · Seats:front Assembly:seat Heater/cooler
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
14V743000 · Seats:front Assembly:seat Heater/cooler
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
14V273000 · Tires:temporary/emergency Spare Tire
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
10V270000 · Seats
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
10V160000 · Structure
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
10V035000 · Equipment:other:labels
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V234000 · Equipment:other:labels
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
09V223000 · Equipment:other:labels
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
08V244000 · Structure:body:hatchback/liftgate
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.