NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
61 reportsClear category filter186,573 miles · Dec 31, 2017
Steering
RACK AND PINION FAILURE. DEAR SIR/MADAM: I BROUGHT MY 2006 SIENNA (PURCHASED NEW) TO THE DEALERSHIP DUE TO WHAT I SUSPECTED WAS A BAD WHEEL BEARING ON THE FRONT PASSENGER SIDE. THE TECHNICIAN CONFIRMED THE BEARING PROBLEM, BUT ALSO INFORMED ME THAT THE SEAL ON THE PASSENGER SIDE RACK AND PINION HAD GONE BAD AND HAD LEADED INTO…
Read full complaint
RACK AND PINION FAILURE. DEAR SIR/MADAM: I BROUGHT MY 2006 SIENNA (PURCHASED NEW) TO THE DEALERSHIP DUE TO WHAT I SUSPECTED WAS A BAD WHEEL BEARING ON THE FRONT PASSENGER SIDE. THE TECHNICIAN CONFIRMED THE BEARING PROBLEM, BUT ALSO INFORMED ME THAT THE SEAL ON THE PASSENGER SIDE RACK AND PINION HAD GONE BAD AND HAD LEADED INTO THE BOOT ON THAT SIDE, AND SINCE THERE WAS NO WAY TO JUST REPLACE THE SEAL, I NEEDED A NEW RACK AND PINION SYSTEM INSTALLED, PLUS A FOUR-WHEEL ALIGNMENT AFTER THE INSTALLATION TOTALING $1187. I MENTIONED TO THE TECHNICIAN THAT I RECENTLY HAD NOTICED THE POWER STEERING RESERVOIR LOWER THAN USUAL AND RECENTLY NOTICED FLUID ON MY DRIVEWAY, SO THAT SEEMS TO BE THE CAUSE OF THOSE OBSERVATIONS. THE ORIGINAL PROBLEM I BROUGHT MY SIENNA IN FOR OF THE BEARING NOISE SEEMED TO BE A FORTUNATE SITUATION, AS IT RESULTED IN THE REVELATION OF THE STEER SYSTEM PROBLEM BEFORE IT LED TO A MORE SERIOUS SITUATION. AFTER GETTING THE REPAIRS DONE, I RESEARCHED THE RACK AND PINION ISSUE AND REALIZED THAT THIS SEEMS TO BE A COMMON PROBLEM WITH THIS MAKE, MODEL, AND YEAR. IT ALSO SEEMS THAT WITH THE PREDICTABLE AND REGULAR OCCURRENCES OF THIS FAILURE, ADDRESSING THIS THROUGH A RECALL WOULD BE A REASONABLE ACTION TOYOTA CAN MAKE IN ITS EFFORTS TO CONTINUE MITIGATING POTENTIAL CATASTROPHIC SAFETY EVENTS FOR CUSTOMERS AND THEIR FAMILIES. THANK YOU FOR YOUR TIME IN CONSIDERING THIS CONCERN. I CONTINUE TO FIND THAT TOYOTA PROVIDES A QUALITY PRODUCT. I HAVE BEEN A TOYOTA CUSTOMER SINCE 1984 AND DO APPRECIATE TOYOTA'S EFFORTS IN MAINTAINING THEIR REPUTATION AS A RELIABLE AND CONSUMER-FOCUSED COMPANY.
NHTSA ODI #11057791
205,000 miles · Dec 12, 2017
Electronic Stability Control (esc)Service BrakesSteering
STABILITY AND/OR TRACTION CONTROLS (YAW ?) SEEMED TO WANT TO BELIEVE THE VEHICLE WAS IN AN UNDERSTEER -- CAUSING THE VEHICLE TO WANT TO BRAKE AUTOMATICALLY, SOUNDING A TRACTION CONTROL ALARM. ON A BONE - DRY ROAD !!!
NHTSA ODI #11054242
Mileage unknown · Nov 28, 2016
Steering
STEERING RACK IS LEAKING AND THIS IS A DANGER TO PEOPLE A SERIOUS DANGER. PEOPLE WITH VANS USUALLY HAVE CHILDREN AND I AM READING OF ALL THESE COMPLAINTS WITH THE STEERING TACK LEAK. TOYOTA IS BEING ABSOLUTELY RIDICULOUS. WE AS CONSUMERS NEED TO VOICE MORE BECAUSE THE MORE WE SPEAK AND VOICE OUR CONCERNS FOR OUR LIVES THE LESS C…
Read full complaint
STEERING RACK IS LEAKING AND THIS IS A DANGER TO PEOPLE A SERIOUS DANGER. PEOPLE WITH VANS USUALLY HAVE CHILDREN AND I AM READING OF ALL THESE COMPLAINTS WITH THE STEERING TACK LEAK. TOYOTA IS BEING ABSOLUTELY RIDICULOUS. WE AS CONSUMERS NEED TO VOICE MORE BECAUSE THE MORE WE SPEAK AND VOICE OUR CONCERNS FOR OUR LIVES THE LESS COSTS EFFECTIVE IT WOULD BE FOR THEM TO IGNORE US. REMEMBER THEY DO NOT CARE ABOUT WHO DIES FROM THEIR LACK OF CONCERN IT IS ABOUT HOW MUCH THEY MAKE AND I WANT A RECALL FOR THIS DEFECT!!!
NHTSA ODI #10928437
43,123 miles · Oct 25, 2016
Steering
STEERING HAS HANDLED FINE SINCE I BOUGHT NEW MARCH 2006 FROM TOYOTA CAPITAL DEALER; 1ST REPORTED ON 2/16/13 AT 43,123 MILES SIENNA POWER STEERING RACK & PINION LEAKING--COST TO REPAIR $1,542.38 (WITH ALIGNMENT). HAVE NOT REPAIRED YET AS FLUID LEVEL HAS NOT CHANGED. POWER STEERING FLUID WAS REPORTED DIRTY ON 3/1/09 AT 22,321 M…
Read full complaint
STEERING HAS HANDLED FINE SINCE I BOUGHT NEW MARCH 2006 FROM TOYOTA CAPITAL DEALER; 1ST REPORTED ON 2/16/13 AT 43,123 MILES SIENNA POWER STEERING RACK & PINION LEAKING--COST TO REPAIR $1,542.38 (WITH ALIGNMENT). HAVE NOT REPAIRED YET AS FLUID LEVEL HAS NOT CHANGED. POWER STEERING FLUID WAS REPORTED DIRTY ON 3/1/09 AT 22,321 MILES. ONLINE RESEARCH SHOWS LEAKING PROBLEM IS COMMON & HAS OCCURRED WITH OTHER 2006 SIENNA'S--PLEASE RECALL ALL THE 2006 SIENNA'S. ATTACHED IS CURRENT MECHANIC WITH PICTURE OF PROBLEM AT END OF REPORT.
NHTSA ODI #10918841
65,000 miles · Sep 16, 2016
Steering
2011 @38000 MILES CAR WAS DIAGNOSTIC AT DEALER WITH LEAK POWER STEERING RACK PINNON ASSEMBLY, COST ROUGHLY $1400 TO REPAIR 2016 @65000 MILES CAR WAS DIAGNOSTIC AT DEALER WITH THE SAME PROBLEM FOR THE SAME PART AGAIN, DEALER WANT ANOTHER $1400 FOR REPAIRING. CALLED TOYOTA, CUSTOMER SERVICE WAS NICE AND GAVE ME A CASE NUMBER B…
Read full complaint
2011 @38000 MILES CAR WAS DIAGNOSTIC AT DEALER WITH LEAK POWER STEERING RACK PINNON ASSEMBLY, COST ROUGHLY $1400 TO REPAIR 2016 @65000 MILES CAR WAS DIAGNOSTIC AT DEALER WITH THE SAME PROBLEM FOR THE SAME PART AGAIN, DEALER WANT ANOTHER $1400 FOR REPAIRING. CALLED TOYOTA, CUSTOMER SERVICE WAS NICE AND GAVE ME A CASE NUMBER BUT FOUND NO SOLUTIONS IN TOYOTA'S DATABASE AND WANT ME TO CONTACT DEALER FOR FINANCIAL DISCOUNT FOR REPAIR. SEARCHED GOOGLE AND FOUND MANY SIMILAR COMPLAINT REGARDING TO STEERING ISSUES AND WONDER CAN THIS BE A DESIGN FAULTS OR A OEM COMPONENT QUALITY FOR A SAFETY CONCERN - WAS WARNED THAT "LOSE OF STEERING CAPABILITY CAN CAUSE A ACCIDENT." ALSO REPEAT CHARGING CUSTOMERS FOR THE SAME EXPENSIVE ASSEMBLY OF 27000 MILES INTERVAL SHOULD PROOF THE CASE - IT IS EITHER A QUALITY OR DESIGN RELATED PROBLEM
NHTSA ODI #10907228
58,500 miles · Aug 24, 2016
Steering
FAILURE OF THE RACK AND PINION BOOT CAUSES A LEAK OF LUBRICANT AND CONTAMINATION OF THE RACK AND PINION SYSTEM. SINCE A FAILURE OF THE BOOT CAN LEAD INTO NOT BEING ABLE TO CONTROL THE STEERING, THIS COULD CAUSE AN ACCIDENT ON THIS MINIVAN AND SHOULD BE RECALLED BYTOYOTA IN ORDER TO FIX IT.. I'VE SEEN MANY COMPLAINTS ONLINE OF …
Read full complaint
FAILURE OF THE RACK AND PINION BOOT CAUSES A LEAK OF LUBRICANT AND CONTAMINATION OF THE RACK AND PINION SYSTEM. SINCE A FAILURE OF THE BOOT CAN LEAD INTO NOT BEING ABLE TO CONTROL THE STEERING, THIS COULD CAUSE AN ACCIDENT ON THIS MINIVAN AND SHOULD BE RECALLED BYTOYOTA IN ORDER TO FIX IT.. I'VE SEEN MANY COMPLAINTS ONLINE OF THIS SPECIFIC PROBLEM,
NHTSA ODI #10898306
Mileage unknown · May 28, 2016
SteeringUnknown Or Other
CRACK OR STICKY DASH DUE TO STICK DASH SUN REFLECT TO YOUR EYE WHICH BLIND YOU WHILE DRIVING THAT IS DANGEROUS FOR AN ACCIDENT
NHTSA ODI #10871309
85,000 miles · Mar 5, 2016
Steering
VISITED THE DEALER TO CHECK THE NOISE, TPMS AND VIBRATINGSOUND WHEN MAKING TURNS AND DRIVING OVER 35 MPH. TECH INFORMED ME THAT THE FRONT PASSENGER SIDE TIRE HAD BUMP AND FOUND THAT THE STEERING RACK AND PINION SECTOR IS LEAKING FROM THE PASSENGER SIDE BOOT AND THE STEERING HAS A KNOCKING NOISE WHEN TURNING THE STEERING WHEEL. M…
Read full complaint
VISITED THE DEALER TO CHECK THE NOISE, TPMS AND VIBRATINGSOUND WHEN MAKING TURNS AND DRIVING OVER 35 MPH. TECH INFORMED ME THAT THE FRONT PASSENGER SIDE TIRE HAD BUMP AND FOUND THAT THE STEERING RACK AND PINION SECTOR IS LEAKING FROM THE PASSENGER SIDE BOOT AND THE STEERING HAS A KNOCKING NOISE WHEN TURNING THE STEERING WHEEL. MILES 85K
NHTSA ODI #10840039
200,000 miles · Feb 22, 2016
Steering
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE METAL TUBE ON THE RETURN LINE FOR THE PRESSURE LINE WAS RUBBING ON THE ENGINE AND OIL PAN. AS A RESULT, THE OIL PAN FRACTURED AND CAUSED THE POWER STEERING FLUID TO LEAK. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS AWAITING A DIAGNOSIS. THE VEHICLE WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE METAL TUBE ON THE RETURN LINE FOR THE PRESSURE LINE WAS RUBBING ON THE ENGINE AND OIL PAN. AS A RESULT, THE OIL PAN FRACTURED AND CAUSED THE POWER STEERING FLUID TO LEAK. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS AWAITING A DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10837583
140,000 miles · Dec 28, 2015
Steering
THE STEERING RACK AND PINION SECTOR IS LEAKING FROM THE PASSENGER SIDE BOOT AND THE STEERING HAS A KNOCKING NOISE WHEN TURNING THE STEERING WHEEL
NHTSA ODI #10816518
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration