NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
40 reportsClear category filter140,000 miles · Dec 18, 2017
Electrical SystemPower Train
POWERTRAIN FAILS AT 140,000 MILES WHICH IS VERY UNUSUAL FOR TOYOTA [REPAIR COST ~4000 QUOTED FROM DEALER]. ALSO, THERE ARE PLENTY OF ELECTRICAL PROBLEMS STARTS WITH FAILING ACTUATORS SUCH AS SLIDING DOOR ACTUATOR [$~1500 QUOTE FROM DEALER], HVAC AIR BLEND ACTUATORS [$~850 QUOTE FROM DEALER]AND VEHICLE STABILITY CONTROL SOLENOIDS…
Read full complaint
POWERTRAIN FAILS AT 140,000 MILES WHICH IS VERY UNUSUAL FOR TOYOTA [REPAIR COST ~4000 QUOTED FROM DEALER]. ALSO, THERE ARE PLENTY OF ELECTRICAL PROBLEMS STARTS WITH FAILING ACTUATORS SUCH AS SLIDING DOOR ACTUATOR [$~1500 QUOTE FROM DEALER], HVAC AIR BLEND ACTUATORS [$~850 QUOTE FROM DEALER]AND VEHICLE STABILITY CONTROL SOLENOIDS [$~500 QUOTE FROM LOCAL]. PLEASE HELP US AND OTHERS TO SHED SOME LIGHT ON SUCH KIND OF ISSUES SINCE IT COSTS TOO MUCH. IN WINTER TIME WHEN HEATER IS NOT WORKING.
NHTSA ODI #11055300
Mileage unknown · Oct 29, 2017
Power Train
ON 9/10/17 MY WIFE WAS DRIVING THE ABOVE MENTIONED CAR. SHE TRIED TO PARK THE CAR IN THE PARKING LOT, THE CAR WILL NOT SHIFT IN PARK, THE SHIFTER WAS FREE AND THEN CAR STARTED ROLLING. THE CAR WAS ABOUT TO GO OVER THE RAVINE, SHE PRESSED THE EMERGENCY BRAKES. AND STOPPED THE CAR, OTHERWISE SHE WOULD HAVE GONE THROUGH THE RAVINE …
Read full complaint
ON 9/10/17 MY WIFE WAS DRIVING THE ABOVE MENTIONED CAR. SHE TRIED TO PARK THE CAR IN THE PARKING LOT, THE CAR WILL NOT SHIFT IN PARK, THE SHIFTER WAS FREE AND THEN CAR STARTED ROLLING. THE CAR WAS ABOUT TO GO OVER THE RAVINE, SHE PRESSED THE EMERGENCY BRAKES. AND STOPPED THE CAR, OTHERWISE SHE WOULD HAVE GONE THROUGH THE RAVINE AND HIT THE MAIN ROAD TRAFFIC. SHE CALLED ME AND I GOT HER HOME AND THEN WENT BACK TO TRY TO TURN THE CAR ON, IT WILL NOT RUN AND GEARS SHIFTER WAS STUCK. I GOT THE CAR TOWED TO MY MECHANIC AT EOC HOMEWOOD STORE #0102.
NHTSA ODI #11041003
161,000 miles · Dec 2, 2016
Power Train
CURRENTLY THERE IS A RECALL OUT FOR THE SHIFT LOCK SOLENOID ASSEMBLY IN CERTAIN TOYOTA SIENNA VAN MODELS FROM 2004-2005 AND 2007 TO 2009. I OWN A 2005 SIENNA LE AND HAVE NO PROBLEM WITH MY SHIFT LOCK SOLENOID. HOWEVER, I HAVE A 2006 SIENNA LE AND UPON SHUTTING OFF THE CAR AFTER DRIVING, I CAN MOVE THE AUTOMATIC TRANSMISSION SE…
Read full complaint
CURRENTLY THERE IS A RECALL OUT FOR THE SHIFT LOCK SOLENOID ASSEMBLY IN CERTAIN TOYOTA SIENNA VAN MODELS FROM 2004-2005 AND 2007 TO 2009. I OWN A 2005 SIENNA LE AND HAVE NO PROBLEM WITH MY SHIFT LOCK SOLENOID. HOWEVER, I HAVE A 2006 SIENNA LE AND UPON SHUTTING OFF THE CAR AFTER DRIVING, I CAN MOVE THE AUTOMATIC TRANSMISSION SELECTOR OUT OF PARK WHEN THE KEY IS OUT OF THE IGNITION AND THE BRAKE PEDAL IS NOT DEPRESSED. THIS CONDITION CAN HAPPEN 50 PERCENT OF THE TIME AND IS QUITE REPRODUCIBLE ON MY VAN. I WILL BE CONTACTING TOYOTA USA TODAY, BUT I THOUGHT IT PERTINENT THAT YOUR AGENCY IS AWARE OF THE PROBLEM AS WELL. I HAVE 3 SMALL CHILDREN, 2 OF WHOM COULD EASILY TAKE THE CAR OUT OF GEAR FROM A PARKED POSITION. THANK YOU. *TR
NHTSA ODI #10929515
163,064 miles · Aug 25, 2016
Electronic Stability Control (esc)Power TrainSuspension
ON AUGUST 20TH, 2016 MY TOYOTA SIENNA 2006 EXPERIENCED A FAILURE OF THE ANTI-SWAY CONTROLS WHICH RESULTED IN SUDDEN DECELERATION AND SEVERE DAMAGE TO THE POWER STEERING, AS WELL AS THE SUSPENSION SYSTEM. THIS INCIDENT OCCURRED WHILE DECELERATING INTO A TURN. ATTACHED IS A NARRATIVE DESCRIPTION OF THE INCIDENT AND THE ESTIMATE …
Read full complaint
ON AUGUST 20TH, 2016 MY TOYOTA SIENNA 2006 EXPERIENCED A FAILURE OF THE ANTI-SWAY CONTROLS WHICH RESULTED IN SUDDEN DECELERATION AND SEVERE DAMAGE TO THE POWER STEERING, AS WELL AS THE SUSPENSION SYSTEM. THIS INCIDENT OCCURRED WHILE DECELERATING INTO A TURN. ATTACHED IS A NARRATIVE DESCRIPTION OF THE INCIDENT AND THE ESTIMATE PROVIDED BY THE SERVICING DEALERSHIP TO REPAIR.
NHTSA ODI #10898609
Mileage unknown · Jun 27, 2016
Power Train
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE ATTEMPTING TO CHANGE GEARS, THE SHIFT LEVER BECAME INOPERABLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFTER CABLE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFI…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE ATTEMPTING TO CHANGE GEARS, THE SHIFT LEVER BECAME INOPERABLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFTER CABLE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10876865
121,000 miles · Jul 29, 2015
Power Train
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE PARKED, THE SHIFT LEVER FAILED TO SHIFT OUT OF THE PARK POSITION UNLESS THE BRAKE PEDAL WAS DEPRESSED. THE ANTI- BRAKE SYSTEM WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MAD…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE PARKED, THE SHIFT LEVER FAILED TO SHIFT OUT OF THE PARK POSITION UNLESS THE BRAKE PEDAL WAS DEPRESSED. THE ANTI- BRAKE SYSTEM WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 121,000.
NHTSA ODI #10744749
185,000 miles · Jun 5, 2015
EnginePower Train
I WAS TRAVELING AT 65MPH ON INTERSTATE 90 EAST. THE CAR WHILE DRIVING WHEN I WAS GIVING GAS IT DIDNT RUN FORWARD AND IT JUST STOPPED ON THE MIDDLE OF THE ROAD WITH MY KIDS IN IT. I TOOK IT TO THE DEALER AND DEALER TOLD ME THAT THE RADIATOR PIPE GOT CORRODED SO THE COOLING OIL FROM THE TRANSMISSION DIDNT FLOW PROPERLY AND THE TR…
Read full complaint
I WAS TRAVELING AT 65MPH ON INTERSTATE 90 EAST. THE CAR WHILE DRIVING WHEN I WAS GIVING GAS IT DIDNT RUN FORWARD AND IT JUST STOPPED ON THE MIDDLE OF THE ROAD WITH MY KIDS IN IT. I TOOK IT TO THE DEALER AND DEALER TOLD ME THAT THE RADIATOR PIPE GOT CORRODED SO THE COOLING OIL FROM THE TRANSMISSION DIDNT FLOW PROPERLY AND THE TRANSMISSION FAILED DURING THE CAR RUNNING.THE TOYOTA HAS SAFETY RECALL OF EXCESSIVE CORROSION FOR THE SPARE TIRE THEN SAME THING APPLIES AS THE CORROSION PART IS UNDERNEATH OF THE ENGINE.
NHTSA ODI #10723691
71,274 miles · Mar 24, 2015
Power TrainWheels
ALL FOUR ALLOY WHEELS ON THIS VEHICLE HAVE THE PAINT BUBBLING AND CHIPPING OFF LEAVING THE WHEEL EXTERIOR EXPOSED TO WEATHER AND FURTHER CORROSION. UNDERNEATH THE CHIPPED PAINT THE ALLOY IS CORRODING, POTENTIALLY COMPROMISING THE STRENGTH AND OVERALL INTEGRATY OF THE WHEELS. I HAVE EXPERIENCED AIR LOSS IN BOTH FRONT TIRES OVER T…
Read full complaint
ALL FOUR ALLOY WHEELS ON THIS VEHICLE HAVE THE PAINT BUBBLING AND CHIPPING OFF LEAVING THE WHEEL EXTERIOR EXPOSED TO WEATHER AND FURTHER CORROSION. UNDERNEATH THE CHIPPED PAINT THE ALLOY IS CORRODING, POTENTIALLY COMPROMISING THE STRENGTH AND OVERALL INTEGRATY OF THE WHEELS. I HAVE EXPERIENCED AIR LOSS IN BOTH FRONT TIRES OVER THE COURSE OF JUST A FEW DAYS. MY LOCAL TIRE SHOP CHECKED BOTH FRONT TIRES FOR PUNCTURES BUT FOUND NOTHING. THEY THEN REMOVED THE TIRES FROM THE RIMS AND INDICATED THE RIMS HAD CORRODED AROUND THE OUTER DIAMETER OF THE RIM WHERE THE TIRE BEAD IS SUPPOSED TO SEAL. THEY CLEANED THE CORROSION FROM THE RIM INTERIOR AND APPLIED A BEAD SEALING COMPOUND THAT FILLS IN THE CORRODED AND PITTED BEAD AREA OF THE RIM ALLOWING THE TIRE BEAD TO SEAL AND HOLD AIR. WHEN IT COMES TIME TO ROTATE THE TIRES THE TECH PERSON INDICATED THAT I SHOULD ALSO HAVE THEM SEAL THE TIRES PLACED ON THE FRONT OF THE VEHICLE AS THEY WOULD PROBABLY START LOOSING AIR AS WELL WITH THE ADDED WEIGHT OF THE FRONT WHEEL DRIVE ENGINE AND TRANSMISSION. THIS SEEMS TO BE A COMMON ISSUE WITH THIS YEAR MODEL OF THE TOYOTA SIENNA. THUS FAR,TOYOTA WILL NOT DO ANYTHING TO CORRECT THIS ISSUE WHICH SEEMS TO ME TO BE A SERIOUS SAFETY HAZARD. *TR
NHTSA ODI #10701391
169,600 miles · Nov 28, 2014
Power TrainSeat Belts
WILL DRIVING I CAME TO A STOP SIGN AND PROCEEDED TO SLOW DOWN BUT THE CAR CONTINUED TO REV A HIGH RATE AND LUNGED FORWARD INTO THE FOUR WAY CROSS BEFORE FINALLY COMING TO A STOP. *TR
NHTSA ODI #10661163
133,295 miles · May 25, 2014
Power TrainTires
AT FIRST, I HAVE THE TIRE PRESSURE INDICATOR LIGHT CONTINUING TO LIT UP. THEN ONE MORNING, THE VAN WAS SLOW TO RESPONSE TO SHIFTING GEAR AND ACCELERATION. AFTER STOPPING, IT WON'T START AND MOVE INTO GEAR AT ALL. THERE WAS NO ENGINE LIGHT BEING LIT OR WARNING SIGN. TOWED TO SHORE TOYOTA AT MAYS LANDING, NJ. THEY TOLD ME THAT…
Read full complaint
AT FIRST, I HAVE THE TIRE PRESSURE INDICATOR LIGHT CONTINUING TO LIT UP. THEN ONE MORNING, THE VAN WAS SLOW TO RESPONSE TO SHIFTING GEAR AND ACCELERATION. AFTER STOPPING, IT WON'T START AND MOVE INTO GEAR AT ALL. THERE WAS NO ENGINE LIGHT BEING LIT OR WARNING SIGN. TOWED TO SHORE TOYOTA AT MAYS LANDING, NJ. THEY TOLD ME THAT THE TRANSMISSION OIL HAD ALL LEAKED OUT DUE TO THE BURST OF ABRUPT FAILURE ON THE INLET TO THE RADIATOR. THEY ASKED ME TO REPLACE THE RADIATOR AT A COST OF $1,150.26! AFTER REPAIRED, THEY THEN TOLD ME THAT THE TRANSMISSION IS BAD AND DIFFICULT TO MOVE INTO GEAR. THEY QUOTED ANOTHER $3,780 TO REPLACE THE TRANSMISSION. I WAS FURIOUS. SINCE THAT THE DEALER TOLD ME THAT THE VAN CAN BE DRIVEN. I WAS PREPARED TO TRADE IT IN AND WEIGHING MY OPTIONS. THE VAN HAS 133,279 MILES. I DROVE IT OK INITIALLY, HOWEVER, I EXPERIENCED THAT IT WAS DIFFICULT TO ACCELERATE TWICE. AFTER 15 MILES WHEN I STOPPED AT A TRAFFIC LIGHT, THE VAN JUST STUCK- IT CANNOT MOVE IN ANY OF THE GEARS AT ALL. I TOWED BACK HOME. AFTER COOLING DOWN, IT WAS ABLE TO DRIVE AGAIN. THE NEW TRANSMISSION FLUID SMELLED BURNT. I AM WONDERING WHY: ?WHY THE ENGINE LIGHT WAS NOT LIT UP AT ALL WHEN THE COOLANT TEMPERATURE WAS SO HIGH BEFORE SPOILING THE WHOLE TRANSMISSION? ?WHY WAS THAT NOT EVEN ANY DTC CODES STORED ON THE OBDII SYSTEMS AT ALL AFTER ALL THESE DEFECTS? ?THIS SEEMED THE SAME PROBLEM AS THE STICKY TRANSMISSION THAT OTHER CUSTOMERS HAVE BEEN COMPLAINING ABOUT, YET TOYOTA HAS NOT INFORMING THE CUSTOMER OF ANY ACTIONS NEED TO BE TAKE. I HAVE BEEN RECEIVING NOTICES ABOUT THE VARIOUS RECALLS AND THE POTENTIAL OF MONETARY COMPENSATION, HOWEVER, NOTHING HAS BEEN REALIZED YET. ?THIS SEEMED TO BE A VERY DANGEROUS SITUATIONS, IF THE VAN CAN BE SLOWED DOWN OR STOPPED SO DRASTICALLY, THE PEOPLE IN THE VEHICLE COULD BE BUMPED OVER. *TR
NHTSA ODI #10593943
Official recalls
11Oct 18, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake pedal.
Consequence & remedy
Consequence: If the shift lever can be moved from the "Park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0V. Vehicles that were previously recalled under campaign 13V-429 are not affected by this recall.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
May 22, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence & remedy
Consequence: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Remedy: Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.
Jun 17, 2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequence & remedy
Consequence: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Remedy: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Apr 20, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
Consequence & remedy
Consequence: THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jun 25, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORIZED THROUGH VEHICLE PROCESSING CENTERS AND HAD ACCESSORIES INSTALLED THAT CAUSED THE VEHICLE TO EXCEED THE GVWR VALUE. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 110, "TIRE SELECTION AND RIMS," AND 49 CFR PART 567.
Consequence & remedy
Consequence: THE GVWR IS INSUFFICIENT FOR THE LOAD CARRYING CAPACITY OF THE VEHICLES.
Remedy: TOYOTA WILL NOTIFY OWNERS INSTRUCTING THEM TO RETURN THEIR VEHICLE TO A TOYOTA OR LEXUS DEALER FOR AN EXCHANGE OF THE CERTIFICATION LABEL AND THE TIRE AND LOADING INFORMATION LABEL, AN INSTALLATION OF THE LOAD CARRYING CAPACITY MODIFICATION LABEL, IF NECESSARY, AND A CORRECTION TO THE OWNER'S MANUAL. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Jun 3, 2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIORATE, THE PERFORMANCE OF THE LIFTGATE WILL BEGIN TO DEGRADE AND THE POWER REAR LIFTGATE WILL OPERATE MORE SLOWLY THAN WHEN THE GAS STRUTS WERE NEW.
Consequence & remedy
Consequence: IF NOT REPAIRED, THE GAS STRUTS MAY NOT BE ABLE TO SUPPORT THE WEIGHT OF THE LIFTGATE WHEN IT IS OPEN EVENTUALLY, THE GAS STRUTS COULD DETERIORATE TO THE POINT THAT THE LIFTGATE WILL FALL ABOUT TEN INCHES AFTER IT REACHES THE FULLY OPEN POSITION, AT WHICH POINT THE POWER MOTOR WILL ENGAGE AND POWER THE LIFTGATE TO THE FULLY CLOSED POSITION. THIS CONDITION MAY CAUSE INJURY TO A PERSON WHO IS STRUCK BY THE LIFTGATE WHEN IT FALLS OR WHEN IT IS CLOSING.
Remedy: DEALERS WILL REPLACE THE GAS STRUTS WITH NEWLY DESIGNED GAS STRUTS THAT HAVE A LONGER SERVICE LIFE. THE CAMPAIGN BEGAN ON AUGUST 8, 2008, AND WILL BE MAILED IN THREE PHASES ENDING IN LATE DECEMBER 2008. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ12010 · Stabilus Rear Liftgate Struts Failing
Opened Sep 28, 2012 · Closed Dec 31, 2012
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
Please see the attached closing resume summary.It has been attached to this document as a PDF.
EA08024 · Steering Intermediate Shaft Binding
Opened Oct 28, 2008 · Closed Jul 16, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Additional source detail variants (3)
Steering:column
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering:linkages
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
Steering
ODI'S ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED IN JUST 0.2 PERCENT OF THE SUBJECT VEHICLE POPULATION.WHEN THE ANALYSIS IS LIMITED TO SALT-BELT STATES, THE RATE IS STILL WELL BELOW ONE PERCENT OF THE POPULATION (0.4 PERCENT).IN ADDITION, TESTS CONDUCTED BY ODI AND TOYOTA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL AFFECT ON STEERING EFFORTS.ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT INDICATED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS IN THE INITIAL STEERING MANEUVERS AFTER FIRST STARTING A COLD VEHICLE.THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR 4 TO 5 YEARS WITH NO CRASHES OR INJURIES ASSOCIATED WITH THE ALLEGED DEFECT.TOYOTA'S TECHNICAL SERVICE BULLETIN PROVIDES ASSISTANCE TO SERVICE TECHNICIANS IN THE EARLY DIAGNOSIS AND REPAIR OF THE ALLEGED DEFECT CONDITION. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-024 CLOSING REPORT.
EA06020 · Unexpected Closing Of Power Liftgate
Opened Dec 1, 2006 · Closed Jun 25, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Additional source detail variants (4)
Latches/locks/linkages:hatchback/liftgate:lock
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:hinge And Attachments
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate:support Device/strut
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Structure:body:hatchback/liftgate
ON MAY 30, 2008, TOYOTA INITIATED A SAFETY RECALL TO REPLACE THE LIFTGATE STRUTS IN APPROXIMATELY 196,000 MODEL YEAR 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER LIFTGATES (RECALL 08V-244).THE RECALL WILL PROVIDE THE OPPORTUNITY FOR VEHICLE OWNERS TO OBTAIN NEW STRUTS THAT ARE MORE ROBUST.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED TO CLOSE THE INVESTIGATION.WHILE TOYOTA HAS NOT MADE A DECISION THAT THE RECALLED VEHICLES CONTAIN A SAFETY-RELATED DEFECT, IN VIEW OF THE RECALL, FURTHER USE OF THE AGENCY'S RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE ANY FINDING BY NHTSA.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ADDITIONAL INFORMATION CAN BE FOUND IN THE ENGINEERING ANALYSIS REPORT.
Illustration