NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
11 reportsClear category filterMileage unknown · Oct 17, 2018
Electronic Stability Control (esc)EnginePower Train
WHEN MY FRAME WAS RECALLED AND REPAIRED I STARTED HAVING MY VCS AND CHECKNENGIN3 LIGHT COME ON CONSTANTLY AND NAME THE TRUCK SHAKES AND IS UNABLE TO BE DRIVEN OVER SPEEDS OF 25 UNSTABLE AND UNSAFE. TOOK IT TO LAWRENCE TOYOTA AND THE SAID IT WOULD COST $2175 TO REPAIR THIS PROBLEM HAS OCCURED IN 100 OF SEQUOIAS AND SHOULD BE PART…
Read full complaint
WHEN MY FRAME WAS RECALLED AND REPAIRED I STARTED HAVING MY VCS AND CHECKNENGIN3 LIGHT COME ON CONSTANTLY AND NAME THE TRUCK SHAKES AND IS UNABLE TO BE DRIVEN OVER SPEEDS OF 25 UNSTABLE AND UNSAFE. TOOK IT TO LAWRENCE TOYOTA AND THE SAID IT WOULD COST $2175 TO REPAIR THIS PROBLEM HAS OCCURED IN 100 OF SEQUOIAS AND SHOULD BE PART OF THE FRAME RECALL. THIS VEHICLE IS UNSAFE TO DRIVE AND ALL I WANT TOYOTA TO DO IS REPAIR MY VEHICLE AS PART OF THE ORIGINAL RECALL.
NHTSA ODI #11140794
180,000 miles · Jul 15, 2018
Engine
SECONDARY AIR SYSTEM REPEATEDLY BRAKING PUTTING THE VEHICLE INTO LIMP MODE, ALSO CAUSING JERKY DRIVING. 2-3K REPAIR ON A KNOWN DEFECT WITH NO RECALL?
NHTSA ODI #11111429
220,000 miles · Oct 24, 2016
EngineSteering
SPENT OVER 2K AT TOYOTA CARLSBAD FOR REPAIRS 1-2 YEARS AGO..PROBLEM ACCELERATING AND LIGHTS COMING UP FOR CHECK ENGINE, TRACK OFF AND VSC..TOOK AGAIN AND THEY ARE ASKING FOR NEARLY 5K FOR REPAIRS..PROBLEM ACCELERATING IN FREEWAY AND TPMS LIGHS ON..
NHTSA ODI #10918597
147,625 miles · Nov 9, 2015
Electronic Stability Control (esc)EngineVehicle Speed Control
WHILE DRIVING AT 35 MPH, THE CHECK ENGINE LIGHT, VSC OFF LIGHT, AND VSC TRAC LIGHT ALL CAME ON AT ONCE, AND THE VEHICLE STOPPED ACCELERATING, AND I EXPERIENCED A DRAMATIC DECREASE IN VEHICLE POWER. I DROVE THE VEHICLE HOME NOTICING A DRASTIC CHANGE IN ACCELERATION AS THE SEQUOIA WOULD NOT ACCELERATE NORMALLY; IT WOULD ACCELERATE…
Read full complaint
WHILE DRIVING AT 35 MPH, THE CHECK ENGINE LIGHT, VSC OFF LIGHT, AND VSC TRAC LIGHT ALL CAME ON AT ONCE, AND THE VEHICLE STOPPED ACCELERATING, AND I EXPERIENCED A DRAMATIC DECREASE IN VEHICLE POWER. I DROVE THE VEHICLE HOME NOTICING A DRASTIC CHANGE IN ACCELERATION AS THE SEQUOIA WOULD NOT ACCELERATE NORMALLY; IT WOULD ACCELERATE AT A SIGNIFICANTLY REDUCED RATE, TOPPING OUT AT 35MPH ON THE FLATS AND 16 MPH ON AN INCLINE, IN ADDITION, DURING START UP, THE ENGINE MAKES A HIGH-PITCH VACUUM NOISE, WHICH DROPS OFF AND NORMAL ENGINE SOUND RETURNS. I HAVE HAD THE CAR DIAGNOSED; ERROR CODES P2440, P441 AND P444 ARE ALL PRESENT INDICATING A FAILURE OF THE AIR INJECTION PUMP. THIS IS A KNOWN PROBLEM ON TOYOTA SEQUOIAS AND TUNDRAS; HOWEVER, TOYOTA HAS ONLY ACKNOWLEDGED IT ON THE 07-10 SEQUOIA BY EXTENDING THE WARRANTY TO 10 YEARS AND 150,000K MILES FOR THIS PART. IT IS CLEAR FROM OTHER POSTS ON THE NHTSA WEBSITE AND OTHERS THAT THIS PROBLEM ALSO EXISTS WITH THE 2004-07 SEQUOIAS AS WELL. THIS IS A SAFETY ISSUE THAT NEEDS TO BE ADDRESSED BEFORE SOMEONE IS INJURED, OR WORSE YET KILLED.
NHTSA ODI #10789393
87,000 miles · Oct 8, 2015
Electrical SystemElectronic Stability Control (esc)Engine
VEHICLE ACCELERATION STALLS FOR A FEW SECONDS WHEN TURNING RIGHT INTO TRAFFIC. THIS ISSUE IS THE SAME AS NHTSA 10V176000, BUT IS NOT COVERED UNDER THIS SAFETY RECALL. THIS ISSUE IS VERY HAZARDOUS TO DRIVERS.
NHTSA ODI #10780742
130,000 miles · Oct 7, 2015
Electronic Stability Control (esc)EngineService Brakes
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE CHECK ENGINE, THE TRACTION OFF AND THE VSC TRACT WARNING INDICATORS ILLUMINATED AS THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKING WAS DELAYED. THE VEHICLE ALSO VEERED FROM LEFT TO RIGHT. THE VEHICLE WAS TAKEN TO AN INDEP…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE CHECK ENGINE, THE TRACTION OFF AND THE VSC TRACT WARNING INDICATORS ILLUMINATED AS THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKING WAS DELAYED. THE VEHICLE ALSO VEERED FROM LEFT TO RIGHT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR PUMP ASSEMBLY AND SWITCHING VALVES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
NHTSA ODI #10780480
125,100 miles · Jul 16, 2014
EngineService BrakesVehicle Speed Control
WHILE DRIVING AT LOW SPEEDS THE VEHICLE EXPERIENCED A MOMENTARY LOSS OF POWER AND A GRINDING/VIBRATING OF THE BRAKES WHILE IN MOTION. THE TRAC OFF AND VSC TRAC WARNING LIGHTS CAME ON ALONG WITH THE BRAKE LIGHT. THE WARNING LIGHTS AND VIBRATING OF THE BRAKES COULD ONLY BE RESET BY TURNING THE IGNITION OFF AND RESTARTING THE VEHI…
Read full complaint
WHILE DRIVING AT LOW SPEEDS THE VEHICLE EXPERIENCED A MOMENTARY LOSS OF POWER AND A GRINDING/VIBRATING OF THE BRAKES WHILE IN MOTION. THE TRAC OFF AND VSC TRAC WARNING LIGHTS CAME ON ALONG WITH THE BRAKE LIGHT. THE WARNING LIGHTS AND VIBRATING OF THE BRAKES COULD ONLY BE RESET BY TURNING THE IGNITION OFF AND RESTARTING THE VEHICLE. IT HAPPENED TWICE IN THE LAST 12 HOURS. *TR
NHTSA ODI #10610871
112,966 miles · May 28, 2014
Engine
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE RECURRED SEVERAL TIMES AND THE VEHICLE WAS TAKEN TO…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE RECURRED SEVERAL TIMES AND THE VEHICLE WAS TAKEN TO ANOTHER DEALER, WHERE THE VALVE SPRING KEY WAS REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 112,966. UPDATED 8/12/14*CN THE CONSUMER STATED THE REPAIRS PERFORMED ON THE VEHICLE WERE DONE INCORRECTLY . THE VALVE KEY LOOSENED CAUSING THE VEHICLE TO MISFIRE. UPDATED 08/25/2014 *JS
NHTSA ODI #10594494
112,854 miles · May 22, 2014
Engine
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE AT A STOP, ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE AT A STOP, ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 112,854 AND THE CURRENT MILEAGE WAS 112,966.
NHTSA ODI #10593386
111,354 miles · May 2, 2014
Engine
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STARTED TO VIBRATE AS THE DASHBOARD LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER STATED THAT THE VEHICLE HAD EXHIBITED A MISFIRE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFI…
Read full complaint
TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STARTED TO VIBRATE AS THE DASHBOARD LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER STATED THAT THE VEHICLE HAD EXHIBITED A MISFIRE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 111,354.
NHTSA ODI #10586171
Official recalls
8Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Feb 5, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.
Consequence & remedy
Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.
Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.
May 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.
May 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 19, 2007
ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.
Consequence & remedy
Consequence: IN EXTREME CASES, IF THE VEHICLE IS CONTINUOUSLY OPERATED IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE AND COULD CAUSE A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
EA06014 · Lower Ball Joint Failure
Opened Aug 2, 2006 · Closed Feb 28, 2007
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
IN A LETTER DATED JANUARY 18, 2007, TOYOTA NOTIFIED NHTSA OF A SAFETY DEFECT IN MODEL YEAR (MY) 2004 THROUGH 2006 TOYOTA TUNDRA AND MY 2004 THROUGH 2007 TOYOTA SEQUOIA VEHICLES PRODUCED BETWEEN SEPTEMBER 15, 2003 AND NOVEMBER 17, 2006 (NHTSA RECALL NO. 07V-013). ACCORDING TO TOYOTA, ?IN THE FRONT SUSPENSION LOWER BALL JOINT ON THE SUBJECT VEHICLES, DUE TO POSSIBLE IMPROPER FINISHING OF THE BALL JOINT, SUCH AS THE ASPECT OF THE BALL STUD SURFACE, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION. IN EXTREME CASES, IF THE VEHICLE IS CONTINUOUSLY OPERATED IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE AND COULD CAUSE LOSS OF VEHICLE CONTROL.?TOYOTA WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY TOYOTA DEALER FOR REPLACEMENT OF THE FRONT SUSPENSION LOWER BALL JOINTS. THIS ENGINEERING ANALYSIS HAS BEEN CLOSED, AS TOYOTA IS RECALLING THE AFFECTED VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Illustration