Toyota RAV4 transmission problems

VEHICLE WOULD HESITATE FROM A STOP CREATING A POTENTIAL HAZARD. INDEPENDENT GARAGE TOLD US THAT IT WAS A TRANSMISSION ISSUE. TRANSMISSION WAS COVERED UNDER OUR EXTENDED WARRANTY SO WE TOOK VEHICLE TO TOYOTA DEALER. THEY ADVISED US THAT ISSUE WAS ECM (ELECTRONIC CONTROL MODULE) ISSUE AND NOT COVERED BY THE EXTENDED WARRANTY. WHEN I ASKED IF TOYOTA WOULD COVER I WAS ADVISED THAT THEY WOULD NOT AS THIS ISSUE WAS NOT SUBJECT TO ANY RECALL? THEY DID HOWEVER HAVE A TECHNICAL BULLETIN THAT ADDRESSED THE TRANSMISSION HESITATION TO THE FAULTY ECM? I REPLACED THE ECM ($1612) AND IT APPEARS THAT IT CORRECTED THE PROBLEM. MY RESEARCH HAS SHOWN THAT THIS PROBLEM IS VERY COMMON TO THE 2002 RAV4 MODEL ONLY IN THE TOYOTA FAMILY OF SUVS. IS THIS A DESIGN DEFECT? *TR

CAR STARTED TO HESITATE AND JERK INTO 2ND GEAR WHEN ACCELERATING. THIS CREATED DANGEROUS SITUATIONS AT INTERSECTIONS , GOING AROUND CORNERS AND TRYING TO MERGE INTO TRAFFIC. CHECK ENGINE LIGHT CAME ON. DEALER SAID NEEDED TO REPLACE AN ECM MODULE IN THE TRANSMISSION HOPING THIS WILL FIX IT (COST 1350) IF IT DOESN'T I WILL NEED A TRANSMISSION (3500). FOUND 38 SIMILAR COMPLAINTS ON EXACT SAME THING ON INTERNET. WHY AREN'T WE MADE AWARE AND WHY NOT A RECALL BEFORE SOMEONE GETS KILLED. *TR

I HAVE A TOYOTA RAV 4 4WD 2001 MODEL. AT 47,000 MILES I HAD AN ENGINE REPLACEMENT DONE BY LYNCH TOYOTA UNDER WARRANTY. 25,000 MILES LATER VEHICLE WAS DIAGNOSED WITH A CRACKED FLEX PLATE. REPAIR WAS DONE BY AAMCO AND IN THEIR WRITTEN REPORT THEY STATE THAT DUE TO AN ALIGNMENT DOWEL THAT WAS CUT OFF WHEN LYNCH REPLACED THE ENGINE, THE ENGINE BECAME MISALIGNED AND THE FLEX PLATE CRACKED. IN ADDITION THE TORQUE CONVERTER ALSO HAD TO BE REPLACED. THE REPORTS WERE HANDED TO LYNCH AND THEIR SERVICE MANAGER DOES NOT ACCEPT RESPONSIBILITY FOR THIS AND REPORTED THAT THE CRACKED FLEX PLATE WAS MORE THAN LIKELY DUE TO POOR MATERIALS. I STILL HAVE THE FLEX PLATE AND WOULD LIKE TO KNOW IF THERE IS A WAY TO HAVE IT CHECKED TO FIND OUT IF INDEED IT WAS MADE FROM POOR MATERIALS. AAMCO DON'T APPEAR TO BELIEVE THIS TO BE THE CASE. *TR

I HAVE NOT HAD AN ACCIDENT OR INJURIES TO WHAT MY COMPLAINT IS ABOUT. I PERSONALLY THINK THIS IS A SAFETY ISSUE. I DRIVE A 2001 TOYOTA RAV4 AND RECENTLY STARTED HAVING SHIFTING ISSUES. I STARTED TO RESEARCH THIS ISSUE AND CAME ACROSS THIS WEBSITE CALLED CARCOMPLAINTS.COM AND FOUND MANY OTHERS WITH THE SAME ISSUE. TOYOTA IS AWARE OF THE PROBLEMS BECAUSE THEY CAME OUT WITH A TSB IN 2006. WHEN YOU COME TO A COMPLETE STOP AND THEN GO TO DRIVE THE CAR FORWARD THE VEHICLE DOESN'T SHIFT PROPERLY THEREFORE COULD BE A SAFETY ISSUE WITH NOT BEING ABLE TO MOVE OUT OF THE WAY OF ON COMING TRAFFIC. PLEASE VISIT THIS WEBSITE AND SEE THE AMOUNT OF PEOPLE HAVING THE SAME ISSUES AND I LIKE MANY OTHERS FEEL THERE IS A DEFECTIVE ECM IN THESE VEHICLES SENDING FAULTY SIGNALS TO THE TRANSMISSION CAUSING THE VEHICLE TO NOT SHIFT PROPERLY AND COULD POTENTIALLY CAUSE ACCIDENTS. THE OTHER PROBLEM IS THAT THIS IS NOT HAPPENING ALL THE TIME, ITS SPORADIC AND EVEN THE DEALER IS HAVING DIFFICULTY DUPLICATING THE PROBLEM. I HOPE MORE PEOPLE MAKE COMPLAINTS AND I WOULD BE INTERESTED IN SEEING HOW MANY HAVE. THANKS! *TR

TRANSMISSION SLIPPING ON 2001 TOYOTA RAV4. SERVICE BULLETIN ISSUED REQUIRING REPLACEMENT OF COMPUTER TO FIX THIS PROBLEM. BULLETIN EXTENDED WARRANTY TO 80,000. CONSUMER NEVER NOTIFIED OF THIS PROBLEM. COMPUTER WENT BAD AT 87,000 MILES. TOYOTA AND CONSUMER CURRENTLY GOING ROUND AND ROUND OVER WHETHER TOYOTA OR CONSUMER MUST PAY FOR COMPUTER REPLACEMENT. CONSUMER ALSO TOLD THAT TRANSMISSION MAY NOW NEED TO BE REPLACED. TOYOTA HAS RECEIVED NUMEROUS COMPLAINTS ABOUT THIS PROBLEM FROM RAV4 OWNERS AND IN MANY CASES THE SHIFT PROBLEMS RELATED TO THE COMPUTER FAILURE HAS RESULTED IN DAMAGE TO TRANSMISSION WHICH TOYOTA WILL NOT PAY FOR. *TR

TL*THE CONTACT OWNS A 2006 TOYOTA RAV4. THE DRIVETRAIN IN THE TRANSMISSION MAKES A WHINING SOUND. THE DEALER REPLACED THE TRANSMISSION. A REGIONAL ENGINEER RECENTLY STATED THAT THE NOISE WAS TYPICAL OF A 2006 RAV4 AND THERE WAS NOTHING TO REPAIR. THE NOISE BEGAN WHILE DRIVING 40 MPH HOUR AND IS CURRENTLY ONGOING WHILE DRIVING BETWEEN 30 TO 55 MPH. THE ENGINEER ALSO STATED THAT THE SOUND OF THE TRANSMISSION IS INHERENT TO THE VEHICLE. THE FAILURE MILEAGE WAS 5,070 AND CURRENT MILEAGE WAS 24,100. UPDATED 04-08-08 *BF UPDATED 04/08/08 *TR

TWO SEPARATE PROBLEMS: 1) LEFT REAR SUSPENSION, REPORTED TO TWO DEALERS STARTING 8/11/07 FOLLOWED BY THREE OTHER COMPLAINTS, DIAGNOSED AS WORN BUSHING. PARTS ON ORDER; PROBLEM GETTING WORSE. NOTIFIED DEALER THROUGH FACTORY REP; DEALER HAS NOT INDICATED THAT DRIVING VEHICLE IS A SAFETY ISSUE. 2) HESITATION DOWNSHIFTING WHEN DEPRESSING GAS PEDAL. FIRST REPORTED TO TWO DEALERS ON 9/8/07 FOLLOWED BY TWO OTHER COMPLAINTS. INFORMED IT WAS/IS A SOFTWARE PROBLEM CORRECTED AT THE FACTORY, YET PROBLEM PERSISTS. *TR

FAULTY ENGINE CONTROL MODULE. IT HAS FAILED AND CAUSED TRANSMISSION TO FAIL AS WELL. AFTER $4K REPLACEMENT TRANSMISSION IS SHOT AGAIN. TRANSMISSION MISSES GEARS AND HAS STALLED IN THE MIDDLE OF INTERSECTION. NOTHING WAS DONE TO CORRECT. DEALERSHIP IS STATING TO REPLACE TRANSMISSION FIRST THEN COME BACK TO FIX COMPUTER. FOR OTHER COMPLAINTS OF SIMILAR NATURE SEE: WWW.CARCOMPLAINTS.COM/TOYOTA/RAV4/2002/TRANSMISSION/PROBLEMS_SHIFITING.SHTML *TR