2024 Toyota RAV4

After driving my 2024 RAV4 in rain for about an hour, I was then parked for about 5 minutes in a parking garage and the engine shut down and warning light came on for power steering, and white smoke /steam came out of the engine. Engine would not restart, even after tow truck arrived thirty minutes later. Once dealership received my vehicle they say it starts fine and can't find any issues. They have been unable to duplicate the issue. I saw this same issue online and have requested they check the MAF sensor and the battery load test. Seems to be a big issue in these cars.

2024 RAV4 XLE Premium will randomly pull to the left or right after start-up, or cold soak, and has been doing so since new. The Dealer has verified that the alignment is correct and there are no mechanical issues. When the vehicle is shut off and restarted, the symptoms will likely change and will often correct itself, but this sometimes changes the direction of the pull. This aligns with the same symptoms as NHTSA MC‑10214321 and Toyota Tech Tip T‑TT‑0616‑20. I have shared this information with the Dealer and they claim to be investigating the possible cause and I am waiting on confirmation of next steps to resolve it. Please update the known NHTSA complaint that has already been issued for Toyota RAV4 model years 2019-2021 to include later model years and including 2024.

While driving on the freeway for about 60 minutes, the drivers, driver side door that was locked released and opened up. The door was fully shut and no warning door ajar was lit up before driving. I grabbed the door and held it until I could exit and slow down to shut it. I tried to fully pull it shut while driving but was unsuccessful. I slowed down and had to pull the handle to release the lock and open the door more to have enough momentum to fully close the door again.

The contact owns a 2024 Toyota Rav4. The contact stated that while his wife was driving 75 MPH, as an occupant seated in the passenger’s side seat, the contact became aware that the rear passenger’s side window shattered without impact. Neither the dealer nor an independent mechanic was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 18,000.

Driving on [XXX] merging onto [XXX] heading north, the sun roof exploded at approximately 70 mph. There were not vehicles near us at the time nor any obvious shrapnel or ricochet marks indicating an object struck the glass causing the break. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Toyota Rav4. The contact stated that on several occasions while attempting to start the vehicle, the message to "Place Key fob Next to Start Button" was displayed. The contact placed the key fob on the start button, and the vehicle started. While driving approximately 35 MPH, the vehicle stalled. The vehicle was pulled over to the side of the road. The contact pressed the start button, but the vehicle failed to restart. The contact stated that the message was displayed again, and the key fob was placed next to the start button, and the vehicle restarted. The dealer was contacted and advised to change the battery in the key fob. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 11,000.

I was driving down the Interstate and my sunroof exploded without apparent cause. This was in Colorado, and there was a change in altitude, so I thought perhaps a difference in pressure might have played a part. There were no cars in front of me nor any visible debris. I was just driving, and heard a loud bang over my head. My sunroof and shade were closed at the time.

Car is out of alignment resolutions in the rear passenger tire to wear down at an abnormal rate. Had the vehicle inspected by a local mechanic and two different dealerships. All three inspections came back with the same answer. The camber and the toe for the right rear tire can not be set to a center good alignment. Leaving it in the red zone that will result in excessive Tire wear, handling and safety problems.

My wife was driving down the freeway with the panoramic sunroof closed. The sunroof glass without warning made a loud popping noise and there was safety glass all over the interior of the car. She was not operating the sunroof at the time. The fabric sunshade was open at the time. Dealership refuses to cover the damage ~$2200 under warranty.

The contact owns a 2024 Toyota Rav4. The contact stated that while driving at various speeds, an abnormal sound was heard coming from under the hood and would shudder towards the front-passenger side. In addition, the contact stated that the failure caused her to crash into a rail guard, and the rear driver-side tire had deflated, and the rim was damaged. No injuries were sustained, and no medical attention was sought. No police report was filed. In addition, an independent mechanic arrived on scene to replace the tire. The local dealer was contacted; however, the vehicle was not diagnosed or repaired due to the warranty having expired. The manufacturer was made aware of the failure. The failure mileage was approximately 40,000.