2023 Toyota RAV4

The contact owns a 2023 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 25V595000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the instrument panel failed to display critical safety information. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 21,000.

I purchased my 2023 Toyota RAV4 new back on March 13,2023. 10 days later on March 23 it was raining as I pulled into BJ’s parking lot, I parked and began fumbling around getting my bag and keys together when my car started shaking and sputtering eventually shutting down with an error message engine stopped steering power low. After a call to the salesman I was able to get my car restarted after 15minutes and many failed attempts. Car was bought back to service the following week and I was told car was not properly programmed at delivery, it was now programmed correctly and this should not happen again. April 17,2023 my son pulling into Tractor supply , raining out, pulls into spot and car again shakes, sputters and shuts off, same message engine stopped steering power low. After many attempts car restarts approximately 20 minutes later. Car serviced codes ARE FOUND and cleared, road tested and told car was ok. May 31,2025 I was driving down Rt 80, pouring rain when traffic comes to a complete stop due to accident ahead. Car starts shaking, sputtering and shuts down. Same message code as always. I turned the car completely off as not to kill battery and started to goggle the RAV4. I attempted to restart the car numerous times. Called for a tow, prayed that I didn’t get killed once traffic started to move. Finally 1-1/2 hours later it started. Traffic began moving 15 minutes after I got it started. Took in for service, charged $199.61 only to be told there were no codes. Problem could not be duplicated and in the future to always disable the start/stop button while using the vehicle. October30, 2025 raining, I stopped at Panera drive thru. Placed an order waiting in line and car shuts down, same error code, couldn’t restart car for 20 minutes. Took to Toyota November 5th same response no codes and cannot replicate issue, car is ok. Please help rectify this before someone gets killed!

The contact owns a 2023 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the passenger’s side blind spot warning system located on the exterior side mirror failed to function as intended. The light flashed on the side mirror; however, the beeping sound was inaudible. No warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. The contact stated that the failure had occurred the same month the vehicle was purchased. The manufacturer was notified of the failure. The failure mileage was approximately 20.

While driving or idling, the pre-collusion, RSA malfunction, Headlight system malfunction, and LTA system malfunction will go off as well as my navigation on my screen. Its been going on and off for 7 months now. It works, then it doesn't. I don't want to take it in because I know they're famous for making me pay high dollar fees for anything and everything. Toyota is horrible for their services and just want the money. I never had any issues with my car until I got a nail in my tire that was an easy fix (that they also wanted to keep my car overnight for a patch).

Faulty instrument panel keeps going on and off. It will reset itself and then do it again like it’s trying to fix itself. But then we’ll go on and off again it’s been doing it for about six months now we’ve been putting off by telling someone because we thought it might straighten up and when we keep looking up recalls, it says there’s no recall on it.

Vehicle: 2023 Toyota RAV4 Hybrid Issue: Persistent brake noise, safety hazard, manufacturer negligence I leased a 2023 Toyota RAV4 Hybrid from Clermont Toyota (Florida). Well before reaching 5,000 miles, the brakes began squealing and grinding, posing a potential safety hazard. Multiple service visits failed to correct the issue. Toyota Motor Sales, U.S.A., Inc. and its distributor, Southeast Toyota Distributors LLC, have long been aware of this defect, as documented in Technical Service Bulletin TSB-0001-22 and numerous NHTSA consumer reports describing similar brake failures and noises in 2019–2023 RAV4 models. Despite repeated notice, Toyota refused to repair or replace the defective vehicle and denied my Lemon Law claim through an arbitration panel connected to manufacturer counsel. This unresolved brake defect creates danger to the driver, passengers, and others on the road. Toyota’s continued sale and lease of vehicles with known braking issues constitute a serious public safety concern. I request that NHTSA investigate Toyota’s knowledge of these defects, evaluate the adequacy of its response, and consider a recall to protect consumers nationwide. Contact: [XXX] – [XXX] – [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While starting my rav4 prime, the instrument panel (gas gauge, speedometer, battery life, etc) went black. Took it to 3 different Toyota dealers; 2 sent me away and the 3rd said I can’t drive the car anymore. Service tech said it’s the 3rd one he’s seen with the instrument cluster black in the last year! They’re still running official diagnostics on it.

For over month on multiple random events, the car shuts down while traveling at hwy speeds. The car light prompt to shift the vehicle into neutral and push the start button to re start the engine. We have had the car at the dealership 4 separate occasions and they can not find the issue because it does not cause an engine light to come on when this happens. They also supposedly can not get it to duplicate so they are refusing to go any further. We have video of this occurring at 50mph. This causes lost of steering and braking. We reported this to Toyota and opened a case. They to will not pursue fixing the issue as they are not getting a trouble code. I fear this is going to cause a major accident and this poses a severe safety risk as you loose control of the vehicle

The vehicle's radio/ GPS navigation system shuts off and on and it is available for inspection upon request. My safety and the safety of others were put at risk because while in the middle of driving on a one-way street the radio/ GPS navigation system shut off in the middle of my trip and I was unaware of if I was going down the correct street because the navigation system completely shut off. I had almost crashed into another vehicle because the radio/GPS navigation system cut off in the middle of my turn so I was unaware of where I was supposed to be driving at the moment. The vehicle has been inspected by Toyota but has not fixed yet. There were no warning lamps but the radio/GPS navigation system did shut off a few times prior to this incident but it never occurred in a situation where I was in a time where I needed the GPS and feared for my life and the lives of others.