2020 Toyota RAV4

Toyota and Lexus vehicles equipped with fuel pumps and manufactured by dense international America and its affiliates contain a defective component. - settlement paper states this that I received in the mail, in which I am a class member of. I was driving my car roughly a year ago, when my car shut off in the middle of the road and would not turn back on period. Road side assistance had to come retrieve my car, and haul it to the dealership. Today I still have this faulty fuel pump in my car, that could shut off at any point in time while I'm driving down the road.

Before purchasing this car (used, certified) I asked the salesman if the 2020 RAV4 Hybrid had the fuel filling issue I had read about in the 2019. He said he'd never heard of it; I told him it was all over the internet and he said "oh, that's for earlier models." So I bought the car. Immediately had issue where I can't get more than 10.5 gallons of gas in the tank when fuel light is on and DTE is 20 or less. The advertised fuel capacity is 14.5. I have a long daily commute and bought this car for the range. I asked the dealer again and they provided me with Toyota's chart that shows 2.5 gallons of "reserve" at the bottom and another 1-2 for "air" at the top of the tank. Yes, Toyota thinks you can fuel their cars with air. I then called Toyota HQ and they said the fuel tank on this car was already taken care of as part of their customer support bulletin. They said it was still under warrantee and should be replaced again — "fixed properly." Dealer still refuses to take care of this issue, telling me now that the 2.5 gallons of "reserve" on the bottom is "unusable." As a woman who commutes long distances daily on rural roads, this frightens me. What if I run out of fuel because I think that I've got 2.5 gallons of "reserve" to make it to the next open gas station — only to run out of gas on a cold, dark winter's night? As dramatic as I am being, the point is that not only is this is a potential safety issue, it's also absolute fraud on Toyotas part — a car advertised as having a 14.5 gallon/572 mile range takes only 10.4 gallons with a 425 mile range.

Toyota emphatically advertises that its 2020 RAV4 hybrids come equipped with a 14.5-gallon gas tank that can hit a 580-mile driving range. The cars suffer from the apparent fuel tank issue that harms both the environment and the benefit of the cars’ electric power. The RAV4 hybrids not only fail to comply with federal and state gas tank regulations, which prohibit the sale of vehicles that cannot fill 90 percent or within two gallons of their nominal gas tank capacity, but suffer from substantially reduced driving range. The fuel tank defect poses an environmental and safety hazard in that drivers are left to guess how much gas they have left and effectively encouraged to top off their fuel tanks in order to fill up as much as possible,

My car’s distance to empty never goes above 420 miles, despite a visit to the Lexington MA Toyota dealership with this complaint. Published range is about 580 miles. The dealership reset values in the car, but this did not make any difference, and at no point during my ownership of the car (which was bought new) has the range on the dashboard when the tank is full exceeded 430 miles.

FUEL TANK CAPACITY WHEN THE CAR WAS BOUGHT NEW WAS 9.3 GALLONS BETWEEN LOW FUEL LIGHT TO REFUEL CLICK AT GAS PUMP. AFTER FUEL TANK CAPACITY AFTER FUEL TANK AND PUMP REPLACEMENT IS 11.3 GALLONS. THIS IS BETWEEN WHEN THE LOW FUEL INDICATION ASSERTS TO WHEN REFUELING CLICKS AT THE GAS STATION. THIS IS STILL WELL BELOW THE ADVERTISED FUEL CAPACITY OF 14.5 GALLONS. A SOFTWARE RESET WAS DONE, BUT THE FUEL CAPACITY DID NOT CHANGE. THIS CAUSES US TO REFUEL MORE OFTEN THAN EXPECTED SINCE THE ADVERTISED RANGE OF 500 MILES ON A TANK OF GAS CAN NOT BE ACHIEVED. HAD WE KNOWN OF THIS ISSUE WHEN WE BOUGHT THE CAR, WE WOULD EITHER NOT HAVE BOUGHT THE CAR OR PAID LESS. TOYOTA IS STILL SELLING THESE CARS WITHOUT WARNING CUSTOMERS OF THE FALSE ADVERTISEMENT.

THE MILEAGE I AM GETTING IS FAR BELOW THE STATED RATING ON THE STICKER. I AM AVERAGING ABOUT 33.5 MPG IN MIXED DRIVING WHEREAS THE STATED RATING IS 41 MPG OVERALL. IT'S NOT EVEN CLOSE. THE TANK WAS RECENTLY REPLACED BECAUSE YOU COULD NOT FILL THE TANK. EXTREMELY DISAPPOINTED IN THE MILEAGE WHICH WAS THE MAIN PURPOSE OF BUYING THIS VEHICLE. SOMETHING NEEDS TO BE DONE.

ON FEBRUARY 6, 2021 IN ATLANTA GA, THE VEHICLE, WHILE IN MOTION AT AROUND 30MPH, DISPLAYED A 'HYBRID SYSTEM MALFUNCTION' WARNING AND BEGAN BEEPING AND TREMBLING. THE WARNING SAID THAT THE CAR MUST BE STOPPED WITHIN 0.9 MILES BUT LASTED FAR LESS THAN THAT, FULLY LOSING ANY EFFECT OF THE ACCELERATOR PEDAL MID-TRAFFIC. THE VEHICLE COASTED INTO A PARKING LOT ON MOMENTUM AND WAS STOPPED WITH A FINAL WARNING THAT BRAKING POWER WAS REDUCED. HAD THIS VERY SITUATION OCCURRED ON AN INTERSTATE, IT EASILY COULD HAVE BEEN FATAL TO MY WIFE, WHO WAS DRIVING AT THE TIME, AND TO OUR UNBORN CHILD. THE VEHICLE IS 9 MONTHS OLD, WAS PURCHASED NEW, AND HAS AROUND 15,000 MILES.