2020 Toyota RAV4

Trunk lift gate unable to close or open properly due to faulty lift gate shock and strut supports as diagnosed by dealership in January 2024. As of then there is was no ETA on parts to complete repair and was blamed on Toyota not supplying enough parts beyond new vehicles and warranties vehicles. Only resolution was to not use the trunk, or as little as possible and told that I was added to a 700+ person waiting list.

on 5/28/24 the vehicle air bag lights and front passenger seat light was flashing and an alarm continuously went off with a message to visit a dealer for service. On 5/29/24 the vehicle was brought in for inspection to a Toyota dealer. I was told an electrical wiring needed to be replaced. Dealership did that but it did not correct the issue. Codes were not resetting. They are now saying it is a wiring/electrical issue under passenger seat and saying they have been communicating with Toyota. We do not have a Toyota extended warranty but vehicle has 32K miles and are told by dealership Toyota should be covering. I am submitting this to have this on record as we have warning lights, messages, etc. occurring which is a safety issue under NHTSA. Dealership keeps increasing charges for parts and labor and states our 3rd party warranty may or may not cover charges. They are trying to determine the issue and if Toyota will cover and resolve.

The contact owns a 2020 Toyota Rav4. The contact stated while driving approximately 35 MPH, the "Engine Maintenance Required" warning illuminated. The contact stated that the instrument cluster displayed the warning; however, all information, including the speedometer, mileage, fuel, and temperature gauge went blank. The contact stated that power was not lost and was able to continue driving to the destination. The contact stated that when the vehicle was turned off and restarted, the instrument cluster functioned as needed. The contact stated that the failure was intermittent at first but had become a recurring failure and occurred at various speeds. The contact had taken the vehicle to a local dealer; however, the vehicle was not yet diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 48,000.

My name is [XXX] and I would like to file a complaint against Toyota. I purchased my RAV4 XLE in 2020 after returning home from military training. This was my dream car and I was filled with joy to be able to purchase it. In the four years I have had it, I have had minimal issues, nothing to note other than normal wear and tear, until recently. The "Engine Maintenance Required" light came on roughly 3 weeks ago. I deemed it to be my oil change notification and reset it knowing when my next oil change was due. The notification came back on to which I started investigating further. I typed in "2020 RAV4 Engine Maintenance Required" into Google and was surprised at how many car forums and complaints popped up for this exact problem. It was an astronomical number of complaints made by loyal Toyota owners. I scrolled for an hour reading everyone's story, which was almost identical to mine. I made an appointment at my nearest Toyota in Bountiful, UT to get a diagnostic test done. Not to my surprise, the code that was tripping the system was for the 'coolant bypass valve.' I was quoted $660 for the parts and labor. After getting a price breakdown and verbally stating how frustrated I was with this issue due to how many others online had the same issue and there not being a recall, I felt like my only option was to pay it and suppress my anger. I am not upset with the Toyota dealership I went to. I am upset that this is a very known issue that even the mechanic verbally stated knowing about, and that Toyota as a large corporation is not doing right by the people who swear by owning Toyota's and their reputable reputation. I called two private mechanics about the issue and they both stated that they have worked on several RAV4's with this issue. It is not cosmetic, it is a critical issue that needs to be fixed. I hope this complaint makes it to the right hands and a solution is implemented so people can enjoy their car without these worries. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

A week prior to this incident, the 2020 RAV4 was taken to Toyota for its maintenance check where everything was checked, replaced and changed. However, the last two days an incessant message keeps popping up on the dash stating “engine maintenance required… Visit your dealer” taking up the entirety of the middle screen inhibiting my ability from seeing my speed, mileage, distance to empty , time, lane assist and other car information that I normally rely on. I have pressed the “arrow back” or “back” button numerous times but three seconds later the message pops again inhibiting me from being able to use necessary car controls to stay safe. The engine on the 2020 RAV4 needs to be recalled as my car only has 55,000 miles on it. I have talked to numerous professionals within the motor industry in which they state these engines have lower stability and life expectancy than PREVIOUS engines used in older RAV4 models. Not only the engine, but the messaging system within the RAV4 needs to be fixed immediately as the communication of maintenance WHILE driving is a hazard. If I cannot look at texts to even just simply read it, why is there is message bright and in the middle of my dashboard popping every 3 seconds with a bright red triangle stating that I need “engine maintenance required,visit a dealer”. This is a safety issue and one in which almost nearly cost me my life.

* Coolant Bypass Valve * This problem costs $800 to fix at the Toyota Dealership. *My car is a 2020 Rav4 with only 32k miles on it. * After reading thousands of complaints on websites from other 2020 Rav4 owners with the exact same problem, I think there should be a recall as this can be a dangerous issue if the engine overheats. I am shocked that nothing has been done about this yet. *The only warning was a routine maintence light that comes on every 5,000 miles.

The following is an issue involving my 2020 RAV4 Toyota battery manufacturing defects that ended the life of my RAV4 battery. The mentioned event occurred on [XXX], and a report was created and recorded by a Toyota representative on [XXX], via (800) 331-4331 phone call, with the reference report number [XXX]. The nature of the issue was that my 2020 RAV4 battery parts came loose from the inside, and the metals were rubbing with each other, causing the smoke and the battery to overheat, ending its life due to the mentioned manufacturing defects. Based on the dangerous, alarming issue of overheating and dense heavy smoke from the battery, I left it at the dealer for service to prevent any toxic fumes, fire, or explosion. I told the dealer adviser that those manufacturing defects are a serious safety concern that should be reported in the public’s best interest to avoid any possible tragedies. I noticed when I picked up my car from the dealer that the battery manufacture defect was not recorded in the paperwork I had received; the manager and the advisor didn’t show any sense of urgency to the matter, so I filed a report to Toyota Motor North America Headquarters, Plano Texas. Report number: [XXX] The dashboard panel never displayed any safety hazard warnings or any symbols indicating the conditions of the smoke and battery overheating were jeopardizing my life and my family aboard while I drove with them. I paid $ 552.55 for the battery and a diagnostic service; management did not want to acknowledge that a manufacturing defect ended the battery life. Customers should not be responsible for replacement costs when the event is caused by manufacturing imperfection “even though the warranty is over.” The dealer advisor and management know that these manufacturing battery defects happen. Still, nobody ever informed me to be mindful of the dangerous state of faulty battery defects when I purchased my 2020 RAV4. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)