2019 Toyota RAV4

The contact owns a 2019 Toyota Rav4. The contact stated that while attempting to open the fuel door, the latch failed to unlock as needed. There was no warning light illuminated. The vehicle was taken to a local independent mechanic to be diagnosed, and the contact was informed that the spring in the latch was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 54,900.

I was driving to Kansas on a road trip and we stopped for gas when we noticed the rear drivers side tire tilting inwards (top of tire angled towards the car). We then drove it to a mechanic in Kansas to see if it is safe to drive further. She noticed the bolt for the rear suspension loose and almost out entirely. She then told us we could not drive the car any further because a few more bumps and the bolt would fall out and create major safely concerns. She also noted that she could see where the bolt was rubbing on the rear suspension sub-plate and could see the old rusted damage along with the new damage from recent driving. She also noted the uneven wear on the tire with the tread worn significantly more on the inner side of the tire. We towed it to Denver to have it looked at and the said the bolt and nut need to be replaced along with a tire alignment. There were no warning signs other than my car felt more bouncy than normal. The car bolt has been replaced but you can inspect the surrounding damage if needed. Both the safety of the people in my vehicle and those around me would have been at risk if we didn't notice the tilt and continued the road trip.

Got a "Hybrid System Malfunction" notification on my dash and took it to the dealer. I was notified that my high voltage hybrid cable is corroded, and that the vehicle is unsafe to drive. I understand that customer support program 22TE09 exists for this problem, but because my vehicle has over 100,000 miles, it is not covered. If this is a safety issue that Toyota has acknowledged and admitted is an issue, there should be a complete recall. I was FORCED to get the work done at a dealer because Toyota has a hold on the part. I attempted to get an independent garage to do the work, but they were not authorized to even purchase the parts necessary. Ultimately I had no choice but to spend almost $5000 for a safety repair on a 2019 vehicle that Toyota themselves have admitted to the engineering mistake, while also making it impossible to fix outside of a dealer. This is completely unacceptable. Thank you.

I’m reporting a safety issue with my 2019 Toyota RAV4 that has recently started and is getting worse. The problem seems related to the start-stop system or something in the powertrain. When I come to a stop—at a stop sign, red light, or roundabout—the car doesn’t always respond normally when I try to start moving again. Sometimes there’s a hesitation, and other times it lurches forward unexpectedly when I lightly press the gas pedal, like you normally would. It feels like a jolt, almost like whiplash. It’s especially dangerous in roundabouts or tight traffic situations because I can’t predict how the car will respond. I’m worried I could accidentally hit another car, or get rear-ended myself because the car doesn’t move smoothly or reliably when restarting from a stop. Even when I turn off the start-stop system, the issue still happens. It feels like a hesitation followed by a sudden surge. The RPMs don’t change, but the car still lurches. Yesterday, for the first time, I noticed the car slightly accelerated on its own after stopping, which was very concerning. I found out through Toyota’s official website that there is a technical service bulletin about this issue that came out before we owned the vehicle. But because it’s not a full recall, the dealership said they wouldn’t fix it unless we paid the $80 diagnostic fee. We’re now just out of warranty. We’re making $580 monthly payments on a car that I don’t currently feel is safe to drive. There are no warning lights or messages on the dash. I’ll be taking it to Le Mieux Toyota in Ashwaubenon, Wisconsin, in two weeks to have it inspected, but I wanted to report this because I believe it’s a safety issue that should be looked into. I have two small kids and I’m genuinely worried about getting into an accident, especially when merging onto highways or driving in busy intersections. I’ve seen people say this system can be recalibrated, but the fact that this is happening without any dashboard warning and is worse.