2019 Toyota RAV4

My 2019 Toyota RAV4 Hybrid (VIN: [XXX] ) suffered sudden engine failure due to coolant intrusion. On Nov 20, 2025, Johnstons Toyota in Harriman, NY (RO#XXX) diagnosed the issue and recorded DTCs P26CA31 and P26CB, which indicate failure of the coolant flow control/bypass valve. The dealer confirmed heavy white smoke from the exhaust with a strong coolant smell and advised the engine had failed, recommending a replacement. This vehicle is part of the early 2019 Japan-built batch widely known for premature electric water pump and coolant-flow system failures. Internal impeller swelling, seal leakage, and bearing seizure can cause coolant pressure spikes and ultimately head-gasket failure with coolant entering the cylinders. This defect has been reported by thousands of RAV4 Hybrid owners (2019–2021). Toyota has addressed it quietly through internal TSBs such as XXX and XXX but no public recall has been issued. The safety risk is severe: the engine began emitting thick white smoke and ran roughly, risking sudden power loss, overheating, or engine seizure while driving. A stall at highway speed could easily cause a collision. Toyota USA opened Case #XXX but declined assistance despite the defect being well documented. This failure was sudden, with no warning lights prior to the incident. Given the widespread nature of this defect and its clear safety implications, I request that NHTSA open a formal investigation into the electric water pump/coolant system failures in 2019–2021 Toyota RAV4 Hybrids and consider requiring a safety recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Stopped for gas on 11/6/2025 immediately after getting gas the truck shook twice, the power steering light and engine shut down light came on and the truck turned off. Waited for a few minutes to turn the engine again it wouldn’t start. Got it towed to my nearest dealership who kept it for a day. Said there was nothing wrong with the truck, there was no code showing and they couldn’t determine the cause of the problem.

One week ago one section of the heated steering wheel was very hot. So much so that I could not touch that area. I took it to the Anderson Toyota dealership in Rockford today. On the way there, I turned on the heated steering wheel, and it started smoking. They said they couldn’t find what was wrong with it, and to replace it would be $1800 because it isn’t in warranty. They suggested I not use it.

It happened yesterday , November 3rd at 8:45 am Approx. speed was 35mph to 40 •Location: 934 York Road, Towson, MD •Description: Front-right impact at 40 mph, no airbag deployment, two children in back seat, vehicle had recent 50K service and roof-rail repair, CSP 22TE05, at Sheehy Toyota Cockeysville. Vehicle now at Caliber Collision Cockeysville. Claim #060381946 I am experiencing neck, shoulder and rib pain right now, my 5 year old complain about right ankle pain and apparently hit his head on the right side.My 3 year old complain about neck pain yesterday. There was no sign showing any kind of failure on my dashboard. I asked my vehicle to be investigated formally by Toyota engineer asap or forensic expert. I asked my vehicle to be freeze right until proper airbag inspection have been conducted. I have picture of the car showing clearly that none of the airbags worked.

There is a known TSB out for 2019 toyota rav4 and some select other years. The issue is a slow speed transmission issue. It is due to a programming issue. At slow speeds, if you try to go from the brake pedal to the gas pedal too quickly, there is a serious lag before power is delivered to the wheels. Which is very dangerous when making specific turns. An example is what happened to my wife and myself the other day. We were in a median turning lane, cars were coming, as we were coming to almost a stop, my wife went to apply the gas. There was a serious lag before power was delivered and it almost resulted in a T bone collision. My wife went to apply gas, there was no power for several seconds, which caused her to panic and hit the brakes again. In that process, the power was finally delivered to the wheels and caused the car to pull about halfway into the oncoming traffic before it stopped from her applying the brakes. She then hard to quickly reverse to avoid the collision. The TSB calls for a flash of the TCM and a relearn procedure to be done. Which I am having done today due to the severity of the incident we had. This could have 100% caused a serious or fatal accident. The two dealerships I spoke with severely down played it as an issue. This deserves a investigation and a recall to be sent out. I was never advised of the TSB or anything.

I stopped for gas; my car would not start. The power steering fluid light came on. I went inside to purchase some but when I returned to the car, there was no place to pour it. After a few minutes the car started. About a month later, my husband stopped for gas and the car killed right after he left the gas station, about 10 minutes later, it started. Took it to a mechanic, they couldn't find anything wrong with it because the check engine light wasn't on and the car wasn't giving any problem codes. About two weeks ago, I stopped for gas, the car wouldn't start. Finally got it started, and the check engine light came on. However, it's still not reading any codes.

The car transmission hesitates to accelerate at slow speeds and jerks or lurches forwards in a uncontrollable way. Dangerous at stop signs or on slow or hilly roads. Dealership does not directly acknowledge this issue, despite mechanic mentioning very clearly it is related to T-SB-0107-19 which Toyota dealerships charge to repair. No warning messages. Issue has existed as long as I have owned the vehicle 1.5 years from 61,000 miles to 71,000 miles.

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at 40 MPH, the steering wheel seized, and the contact had to use force to maneuver the steering wheel. A yellow light was illuminated, followed by a red light. The message "Power Steering Malfunction" was displayed. The vehicle was taken to the dealer, where it was diagnosed, and determined that the power steering unit sensor had failed. The vehicle was not repaired due to the cost. The contact retrieved DTCs: C05D604 (Electronic Power Steering (EPS) System Internal Failure); C151287 (Malfunction in the Electric Power Steering (EPS) System Torque Sensor); and C15D11C (Electric Parking Brake Failure). The vehicle was not repaired due to the cost. The contact stated that the failure persisted. The contact related the failure to NHTSA Campaign Number: 20V373000 (STEERING); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 45,500.