Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2570–25K
2525–50K
1550–75K
575–100K
7100–150K
0150K+
309 reports with mileage · 568 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 205 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports2 fire reports16 injury reports
What owners actually said
877 reports
Mileage unknown · Jul 16, 2024
Engine
Coolant Bypass Valve Failure Engine Maintenance Required: See Dealer message appears on the drive screen when driving and you can't remove it- which means you can't see your digital speed or what you are setting your cruise at. The failure of this valve will cause the car to overheat which will lead to radiator/engine damage if …
Read full complaint
Coolant Bypass Valve Failure Engine Maintenance Required: See Dealer message appears on the drive screen when driving and you can't remove it- which means you can't see your digital speed or what you are setting your cruise at. The failure of this valve will cause the car to overheat which will lead to radiator/engine damage if not taken care of immediately. This part needs to be recalled!!!! RECALL THE TOYOTA COOLANT BYPASS VALVE! It is a faulty part that is failing in all 2019-2020 Toyota models. Mine is a 2019 RAV4. The part is plastic and is failing across the board. It Is costing $996.00 to have this problem diagnosed and fixed so I can drive my car again. I am a teacher and this is a substantial amount of money for a plastic part that should have never been used in the first place. Toyota needs to be held responsible for its cheap and faulty parts. I didn't know if I was going to make it to the dealership or not.
NHTSA ODI #11602790
Mileage unknown · Jul 16, 2024
Engine
Engine maintenance required per dealership it is the coolant bypass valve. Reason for failed per Toyota “bad luck” appears to be a class action suit filed for this issue current mileage 72,384
NHTSA ODI #11602640
Mileage unknown · Jul 15, 2024
Engine
Engine maintenance required notification came on - told it was due to the coolant bypass valve circuit shorting to the battery
NHTSA ODI #11602459
Mileage unknown · Jul 15, 2024
Unknown Or Other
THE CENTRAL ENTERTAINMENT TOUCH SCREEN /DISPLAY HAS NOT BEEN WORKING AT ALL. CARPLAY AND CHARGING DOES NOT WORK AT ALL AS DISPLAY IS NOT WORKING. SPEAKER SETTINGS AS WELL AS GAS MILEAGE INFO CAN NOT BE ACCESSED AS IT DISPLAYS NOT WORKING OR NOT RESPONSIVE. I TRIEDTO CHECK WITH TOYOTA DEALERSHIP HERE IN LOUISIANA AND THEY A…
Read full complaint
THE CENTRAL ENTERTAINMENT TOUCH SCREEN /DISPLAY HAS NOT BEEN WORKING AT ALL. CARPLAY AND CHARGING DOES NOT WORK AT ALL AS DISPLAY IS NOT WORKING. SPEAKER SETTINGS AS WELL AS GAS MILEAGE INFO CAN NOT BE ACCESSED AS IT DISPLAYS NOT WORKING OR NOT RESPONSIVE. I TRIEDTO CHECK WITH TOYOTA DEALERSHIP HERE IN LOUISIANA AND THEY ARE SAYING THAT IT IS OUTSIDE WARRANTY AND HAVE TO PAY 1500 DOLLARS TO CHANGE THE RADIO AND THE DISPLAY COMPLETELY. TO ME PERSONALLY IT LOOKS LIKE A SOFTWARE ISSUE RATHER THAN A HARDWARE PROBLEM. HOPE IT HAS A SIMPLE FIX. PLEASE INVESTIGATE THIS ISSUE SO THAT OTHER DRIVER'S DO NOT ENCOUNTER THIS PROBLEM WHILE DRIVING AND GET INTO A LIFE-THREATENING ACCIDENT. APPRECIATE YOUR HELP.
NHTSA ODI #11602354
Mileage unknown · Jul 11, 2024
Engine
Known issue and reported by many others. Coolant bypass valve needs to be replaced around 30,000 to 50,000 miles. Occurs when turning on AC. Engine maintenance required sign pops up and cannot remove which does not allow driver to see speedometer leading to unsafe driving speeds.
NHTSA ODI #11601321
Mileage unknown · Jul 10, 2024
Engine
Coolant Bypass Valve Defect. Toyota sold me a 2019 RAV 4 knowing there are problems with coolant bypass valve. Toyota RAV4s and Corollas is “insufficiently manufactured and/or designed” as it can crack and leak coolant. Once a leak begins, the coolant comes into contact with an electrical connector near the valve and corrodes an…
Read full complaint
Coolant Bypass Valve Defect. Toyota sold me a 2019 RAV 4 knowing there are problems with coolant bypass valve. Toyota RAV4s and Corollas is “insufficiently manufactured and/or designed” as it can crack and leak coolant. Once a leak begins, the coolant comes into contact with an electrical connector near the valve and corrodes and damages the component, the filing says. Once this occurs, a vehicle’s engine can no longer communicate with the coolant bypass valve during operation, the suit states.
NHTSA ODI #11601043
Mileage unknown · Jul 10, 2024
Engine
A “Engine Maintenance Required” notification came up on dash boards. When car was taken to dealership and a diagnosis was made they stated that the engine coolant bypass valve was damaged and needed to be replaced. Upon research online it appears that Toyota would be recalling over 44,000 vehicles of the makes RAV4 and Corolla r…
Read full complaint
A “Engine Maintenance Required” notification came up on dash boards. When car was taken to dealership and a diagnosis was made they stated that the engine coolant bypass valve was damaged and needed to be replaced. Upon research online it appears that Toyota would be recalling over 44,000 vehicles of the makes RAV4 and Corolla ranging from the manufacturer years 2019-2023. The issue with these vehicles states that potential of a crack forming in the engine, a result of a manufacturing error. Coolant or oil could leak from the crack, leading to the engine stalling, overheating, or possibly catching fire. This issue can be found within several articles. The dealership is wanting me to pay $787+ tax for an issue that appears to be a manufactured issue which later I may not be refunded.
NHTSA ODI #11600836
Mileage unknown · Jul 9, 2024
Engine
A message popped up on my dash "Engine Maintenance Required - See Dealer". After further research this is a known issue with the Toyota Rav4s. The coolant bypass valve gets stuck open/closed. I took it into Toyota and before they even looked under my hood, he read the message on the dash and said "I know what it is". After payin…
Read full complaint
A message popped up on my dash "Engine Maintenance Required - See Dealer". After further research this is a known issue with the Toyota Rav4s. The coolant bypass valve gets stuck open/closed. I took it into Toyota and before they even looked under my hood, he read the message on the dash and said "I know what it is". After paying $742.16, it was fixed. My local mechanic was not aware of this issue, so I had to go through Toyota directly. If someone cannot afford $700-$1,000 repair, they risk their engine overheating. Toyota is aware of this issue and they have not recalled this part in their vehicles that is consistently failing.
NHTSA ODI #11600429
Mileage unknown · Jul 2, 2024
Fuel/propulsion System
I was told on 6/28/2024 that my car needs a new coolant bypass valve at a cost of 900.00 on researching this I see there is a class action suit against Toyota because there are so many people with this problem and it should be a recall. Not sure where to go from here .
NHTSA ODI #11598227
Mileage unknown · Jun 28, 2024
Fuel/propulsion System
My RAV4 does not hold a full tank of gas. It only allows half a tank get full of gasoline. Toyota says they don't know how to fix, as well as two other shops I have brought it to. There are no engine messages or any other signs of issues. Gas will gush out of the tank when filling up if I do not stop at half way.
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Consequence & remedy
Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence & remedy
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 RAV4 and RAV4 Hybrid vehicles. Due to a damaged electrical connector, the back-up camera may not activate when the vehicle is in reverse. As such, these vehicles fail to comply to Federal Motor Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: If the backup camera system does not activate and the driver does not check his/her surroundings while reversing, there is an increased risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the back-up camera system and replace the audio display unit, if necessary, free of charge. The recall began September 27, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is K0N.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.
Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration