Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
970–25K
2125–50K
1650–75K
475–100K
4100–150K
2150K+
144 reports with mileage · 187 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports32 fire reports13 injury reports
What owners actually said
331 reports
Mileage unknown · Jan 28, 2023
Electrical SystemEnginePower Train
Bought brand new 04/02/2018. First battery died July 2018. First cooling system needed replaced December 2019 due to overheating issues. There has been 7 battery replacements, about two each year, the two most recent was July 2022 and October 31, 2022. Second cooling system replaced December 2022 due to overheating issue. Damage…
Read full complaint
Bought brand new 04/02/2018. First battery died July 2018. First cooling system needed replaced December 2019 due to overheating issues. There has been 7 battery replacements, about two each year, the two most recent was July 2022 and October 31, 2022. Second cooling system replaced December 2022 due to overheating issue. Damaged engine and needed to replace engine. Other issues have been stalling while driving in traffic; stalling while turning and at traffic lights. Was told by Toyota technician that it was due to extremely low oil. I asked why no low oil light came on and he stated it must be damaged but too expensive to repair. My wife and I had our safety at risk due to stalling in traffic and being stranded due to dead batteries. One night we had to sleep in a grocery store parking lot as a tow truck wasn’t available that night. Toyota states they test the batteries and find nothing wrong even after at least two of them exploded and leaked acid. This could have created a fire and/or engine damage. They just keep replacing them over and over. I have estimate from independent repair shop of possible diagnosis for battery issue. I can not have an independent repair shop even move a bolt or warranties will be voided. During the second overheating was told by Geico insurance inspector no codes were found despite overheating had occurred and severe enough to cause engine damage. Never receive any warning lights for any problems that occurred; the problems happen with no warnings. The second overheating issue left us almost freezing to death as we could not make it back home and had to pull over; tow truck was unavailable that night. Have all service records; too many to upload here; files too big. Please contact via email overtherainbow0126@gmail.com.
Since I bought the car in 2018, the car has stalled two times while I am driving on the road. That was very dangerous because other drivers almost hit me from behind. The first time I had the problem, the Toyota dealer told me that it was likely caused by bad gas. It happened again this time today. I am bringing it to the deale…
Read full complaint
Since I bought the car in 2018, the car has stalled two times while I am driving on the road. That was very dangerous because other drivers almost hit me from behind. The first time I had the problem, the Toyota dealer told me that it was likely caused by bad gas. It happened again this time today. I am bringing it to the dealer again, but likely not able to get a solution. At the same time, I am scared of driving it, yet I need to drive it for work and other necessities. Happened at 32k in August 2020, and 55k in January 9, 2022.
NHTSA ODI #11500948
Mileage unknown · Dec 29, 2022
Steering
Power steering failed in April 2022, fixed by dealer in May 2022. Failed again in December 2022. Electric power steering system was replaced, contacting dealer today to have system checked. Very dangerous when steering goes out. It’s like manual steering from the old days.
NHTSA ODI #11499318
Mileage unknown · Dec 23, 2022
Electrical SystemSteeringCrash
During a turn... The steering locked up and a julting from all wheel drive system. No warning, slammed into road railing.
NHTSA ODI #11498691
Mileage unknown · Dec 7, 2022
Electrical SystemUnknown Or OtherFire
UNKNOWN since insurance or fire department does not want to investigate. However car randomly caught on fire when driving. Could be due to a new battery installed a week prior. Driver and daughter claim as well an electrical issue with AC turning on by itself the morning of car fire which it has never done before. Driver suspe…
Read full complaint
UNKNOWN since insurance or fire department does not want to investigate. However car randomly caught on fire when driving. Could be due to a new battery installed a week prior. Driver and daughter claim as well an electrical issue with AC turning on by itself the morning of car fire which it has never done before. Driver suspects faulty battery since a new battery installed by dealer a week prior and the year before and it is not the first case late model RAV4s are caught on fire due to battery issues.
NHTSA ODI #11496455
Mileage unknown · Oct 3, 2022
Electrical System
At approximately 65K miles on my 2018 vehicle, my alternator and battery have malfunctioned. The car has routine maintenance done on it, the battery had a dead cell according to the repair shop with the battery reader. The car started fine and while driving the battery picture came on dash and said malfunction to park in a safe …
Read full complaint
At approximately 65K miles on my 2018 vehicle, my alternator and battery have malfunctioned. The car has routine maintenance done on it, the battery had a dead cell according to the repair shop with the battery reader. The car started fine and while driving the battery picture came on dash and said malfunction to park in a safe location all lights on dash came on. I tried to turn my car off in a drive thru, it wouldn’t start. The repair shop says it’s only charging at 12.5 volts and needs to be replaced. I only have manufactured items in my car and seems puzzling to why a 2018 with way less than 100k miles on would have a battery and alternator just die.
NHTSA ODI #11487677
Mileage unknown · Sep 9, 2022
Service BrakesVehicle Speed ControlCrash
On 8/31/2022 I was turning into the driveway of a friend. All of a sudden my car accelerated. There was another car in the driveway in front of me. I was trying not to hit it, so turned my steering wheel sharply to the right. I left the driveway, turning into a side yard, and then it seemed the brakes wouldn't work. I hit a tree…
Read full complaint
On 8/31/2022 I was turning into the driveway of a friend. All of a sudden my car accelerated. There was another car in the driveway in front of me. I was trying not to hit it, so turned my steering wheel sharply to the right. I left the driveway, turning into a side yard, and then it seemed the brakes wouldn't work. I hit a tree, and went over a large rock, which stopped my car. As it happened, I did hit the other car. its back right bumper was hit, and my front left was crushed. My car was towed to an auto shop on 9/6/2022. It is not drivable. Incident was reported to my insurance that evening. My local agent told me to report to you on 9/9/2022.
NHTSA ODI #11483738
Mileage unknown · Sep 3, 2022
Electrical System
Toyota etunes systems are apparently fatally flawed or are exquisitely attuned to planned obsolescence. My bluetooth began initializing 6 weeks ago and has not stopped since. This is a safety concern because, as a 67 year old driver, it is important to have my hands free to drive. I purchased this vehicle because of this fea…
Read full complaint
Toyota etunes systems are apparently fatally flawed or are exquisitely attuned to planned obsolescence. My bluetooth began initializing 6 weeks ago and has not stopped since. This is a safety concern because, as a 67 year old driver, it is important to have my hands free to drive. I purchased this vehicle because of this feature. Toyota maintains the only solution to my problem is to purchase a new $1,500 radio. Because this is not just my problem but one experienced by a majority of Toyota owners, Toyota should bear the cost for replacement
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration