Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into To…
Read full complaint
Before o had taken my RAV4 into Toyota for the recall a AAA tech. had replaced the battery after jump starting it. There was nothing wrong with the sensors or anything else but after the battery was replaced all the electric sensors that are for lane change warnings and cruise control etc. stopped working. I took vehicle into Toyota of Santa Maria and was told that I needed to pay for the sensors that had failed. They told me that I was responsible and I do not believe I am when AAA had just replaced my battery and only after that did the sensors have an issue. I do not feel safe driving my car now because all the sensors aren’t working anymore.
NHTSA ODI #11754574
Mileage unknown · Nov 29, 2025
Electrical SystemSteering
While picking up my son from school, my 2018 Toyota RAV4 Hybrid suddenly experienced a complete steering failure. The steering wheel locked without warning and became impossible to move, making the vehicle inoperable and creating an immediate safety hazard. My son and I were stranded for over 7 hours in a public area. AAA was di…
Read full complaint
While picking up my son from school, my 2018 Toyota RAV4 Hybrid suddenly experienced a complete steering failure. The steering wheel locked without warning and became impossible to move, making the vehicle inoperable and creating an immediate safety hazard. My son and I were stranded for over 7 hours in a public area. AAA was dispatched twice, but they were unable to resolve the issue. The vehicle ultimately had to be towed to a Toyota dealership. Toyota dealership diagnosed the car with a failed steering lock ECU, a critical safety component that should not malfunction under normal conditions. I was quoted over $2,000 for the repair. This issue aligns with multiple known recalls and technical service bulletins related to steering and electronic control failures in RAV4 Hybrid models, suggesting a potential manufacturer defect. This sudden steering failure placed me and my child at significant risk. There were no warning lights, no prior steering issues, and no indicators of malfunction before the event occurred. I am submitting this report because a steering lock ECU failure can lead to sudden loss of steering control, which poses a serious danger to vehicle occupants and others on the road.
NHTSA ODI #11702009
Mileage unknown · Dec 29, 2022
Steering
Power steering failed in April 2022, fixed by dealer in May 2022. Failed again in December 2022. Electric power steering system was replaced, contacting dealer today to have system checked. Very dangerous when steering goes out. It’s like manual steering from the old days.
NHTSA ODI #11499318
Mileage unknown · Dec 23, 2022
Electrical SystemSteeringCrash
During a turn... The steering locked up and a julting from all wheel drive system. No warning, slammed into road railing.
NHTSA ODI #11498691
Mileage unknown · Dec 4, 2021
SteeringSuspension
I had been noticing since November 2020 a strange noise from the rear on the driver side anytime I parked the car, as it goes over a step about 2 inches in height when entering it. I took it to the dealer an explained them that it wasn't just the noise but that I could move with my hands the rear tire on the driver side back and…
Read full complaint
I had been noticing since November 2020 a strange noise from the rear on the driver side anytime I parked the car, as it goes over a step about 2 inches in height when entering it. I took it to the dealer an explained them that it wasn't just the noise but that I could move with my hands the rear tire on the driver side back and forth. They told me NO PROBLEM FOUND. Also, that day I did have a wheel alignment done just in case. But I returned days later as it was not balance, the steering felt incorrect pulling right and left. And they tell me that the right front lower control arm needs replacement when the car has been driven 23,062 miles; I replaced it but the steering was still incorrect. I called TOYOTA (800) 331-4331 a case #210730001337 was opened. I was told to buy 3 new tires to correct the problem, I did it, yet the problem continues. I expected the dealer to do a wheel alignment after replacing the tires yet they lie about and they wanted me to drive away, I refused to do it and called TOYOTA and offered to pay for it and finally they agreed on doing it free and they found out that the rear alignment was off. Poor craftsmanship of the rear suspension parts for sure. That weird noise on the rear continues, the steering pulls right and left which increases risk of losing control and eventual crash and injury. I do trust the NHTSA to make things right do not be like BOEING and the FAA.
NHTSA ODI #11442693
Mileage unknown · Aug 12, 2021
Steering
The Electric Power System warning light came on for the first time and my car will not start.
NHTSA ODI #11428858
Mileage unknown · May 19, 2021
Electrical SystemService BrakesSteeringFire
We were driving when I made a right turn and suddenly the steering wheel locked on me and at the same time various warning lights lit up on my dashboard. The car slowed and I was able to regain control of the steering wheel to pull over. After driving a few miles further we once again came to a right turn and everything happen…
Read full complaint
We were driving when I made a right turn and suddenly the steering wheel locked on me and at the same time various warning lights lit up on my dashboard. The car slowed and I was able to regain control of the steering wheel to pull over. After driving a few miles further we once again came to a right turn and everything happened as before except with greater intensity. We tried to straighten the steering wheel for control and were able to pull over into an empty parking lot. By the time we came to a stop, which took all of just one or two minutes, smoke was coming out from under our hood. We quickly got out of our car and opened the hood to see the battery in flames. I called 911 while my husband poured his cup of water over the flames. It stalled the fire but it continued to spark until help arrived. I am certain if we had not had water the whole car would have caught on fire. The car was towed to a Toyota dealership where we were told that their was an issue with battery installation. At present it is being worked on but I have lost confidence in this vehicle especially since we got no warning that there was a problem and we could have been badly injured or killed if the circumstances had been different and we had not been able to pull over and get out or have water with us. We have since learned that this is an issue for many people who own this 2018 RAV4 vehicle. I also learned there is no recall on this issue. I hope that Toyota isn't waiting for someone to be seriously injured or die before they fix this problem.
NHTSA ODI #11417783
Mileage unknown · Jan 16, 2021
Steering
STEERING WARNING LIGHT COMING ON WITH WARNING SOUND, THE DEALER CAN'T FIND THE PROBLEM TO REPAIR IT
NHTSA ODI #11388411
7 miles · May 22, 2019
SteeringUnknown Or Other
THE LINE DEPARTURE ALERT / STEERING ASSIST BUZZER IS NOT WORKING OR NOT LOUD ENOUGH TO BE HEARD. OCCASIONALLY WHEN DRIVING FOR HOURS ON FREEWAYS I MAY GET DROWSY, SO I BOUGHT THE NEW RAV4 AND SPECIFICALLY CHOSE A MODEL WITH LDA/SA HOPING THAT IT ASSISTS ME. AFTER DRIVING OVER 1000 MILES BETWEEN THE CITIES, I AM COMPLETELY DISAP…
Read full complaint
THE LINE DEPARTURE ALERT / STEERING ASSIST BUZZER IS NOT WORKING OR NOT LOUD ENOUGH TO BE HEARD. OCCASIONALLY WHEN DRIVING FOR HOURS ON FREEWAYS I MAY GET DROWSY, SO I BOUGHT THE NEW RAV4 AND SPECIFICALLY CHOSE A MODEL WITH LDA/SA HOPING THAT IT ASSISTS ME. AFTER DRIVING OVER 1000 MILES BETWEEN THE CITIES, I AM COMPLETELY DISAPPOINTED WITH THIS FEATURE. IT SUPPOSED TO ALERT ME WHEN THE CAR DRIVES OVER THE LINES WITH A BUZZER AND GENTLE NUDGE TO THE STEERING WHEEL. I CANNOT HEAR THE BUZZER AND FEEL ANY ACTION ON THE STEERING WHEEL. I WENT TO THE CULVER CITY TOYOTA DEALER TWO TIMES IN ATTEMPTING TO HAVE THIS PROBLEM FIXED. BOTH TIMES I HAVE BEEN TOLD THAT THE SYSTEM WORKS AS DESIGNED. DURING A TEST DRIVE WITH THE MASTER TECHNICIAN, WITH RADIO OFF, AT SPEED LESS 50MPH, SO WITH THE MINIMAL ROAD NOISE, I COULD NOT HEAR THE BUZZER. I DO CLEARLY HEAR THE BUZZER OF THE PARKING SONAR OR PRE-COLLISION WARNING. SO THIS IS AT BEST USELESS FEATURE, AT WORST IT IS A DISTRACTION WHEN TRYING TO MAKE IT WORK AT A HIGHWAY.
NHTSA ODI #11209342
181 miles · Apr 3, 2019
Service BrakesSteering
SINCE THE CAR WAS PURCHASED ON 11/25/2018, THE FRONT BRAKES CREAK WHILE ON DRIVE AND THE CAR PULLS TO THE LEFT. I TOOK IT TO THE DEALERSHIP AND THEY SAID NOTHING WAS WRONG WITH THE BRAKES. THEY ASKED THAT I WAIT UNTILL 500 MILES TO LOOK AT THE ALIGNMENT. I TOOK IT IN AGAIN FOR THE BRAKES AND THE SERVICE MANAGER SAT IN THE CAR A…
Read full complaint
SINCE THE CAR WAS PURCHASED ON 11/25/2018, THE FRONT BRAKES CREAK WHILE ON DRIVE AND THE CAR PULLS TO THE LEFT. I TOOK IT TO THE DEALERSHIP AND THEY SAID NOTHING WAS WRONG WITH THE BRAKES. THEY ASKED THAT I WAIT UNTILL 500 MILES TO LOOK AT THE ALIGNMENT. I TOOK IT IN AGAIN FOR THE BRAKES AND THE SERVICE MANAGER SAT IN THE CAR AND HE HEARD THE BRAKE NOISE. HE RAN IT THROUGH TESTS AND SAID NOTHING WAS FOUND. HE WAS GOING TO WAIT FOR A TOYOTA REPRESENTATIVE TO COME AND THEN THEY WOULD LOOK AT IT BEFORE ANYTHING WAS DONE. IT IS NOW APRIL AND THEY STILL HAVE NOT ADDRESSED THE BRAKE ISSUE. THEY DID ADJUST THE ALIGNMENT DURING THE TIME, BUT IT STILL PULLS TO THE LEFT. AFTER THE ALIGNMENT, THERE WAS A SLIDING GRINDING NOISE ON THE LEFT FRONT BRAKE. THE NOISES OCCUR WHEN YOU COME TO A STOP AND RELEASE THE BRAKES. BOTH ISSUES HAVE BEEN PRESENT SINCE THE CAR WAS PURCHASED HAVE NOT BEEN RESOLVED.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration