IllustrationThe hip strap is fraying like several others have stated unclaimed. The clip that goes into the crotch buckle has plastic that pokes out a bit, and it’s not smooth where the hip tether passes through which which I believe is the cause for the fraying on the belt.
2018 Toyota RAV4
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2018 Toyota RAV4 do not stand out strongly from the model-year median of 258.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAV4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
970–25K
2125–50K
1650–75K
475–100K
4100–150K
2150K+
144 reports with mileage · 187 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports32 fire reports13 injury reports
What owners actually said
331 reportsThe contact owns a 2018 Toyota Rav4. The contact stated that while attempting to enter the truck, she became aware that the trunk had failed to close properly, after which the contact was unable to open the trunk. The door ajar warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the t…
Read full complaint
The contact owns a 2018 Toyota Rav4. The contact stated that while attempting to enter the truck, she became aware that the trunk had failed to close properly, after which the contact was unable to open the trunk. The door ajar warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the trunk hinges. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 35,000.
The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed the parts were not yet available. The contact stated that the manufacturer had exceeded a rea…
Read full complaint
The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Had issue with intermittant engine light and all warning lights going on with certain maneuvers. When lights on, car would turn off, while driving, if washers turned on. Dealer replaced alternator and thermostat, supposedly fixing, however, 3 days later same problem recurred and car turned off while traveling 70+ mph on major…
Read full complaint
Had issue with intermittant engine light and all warning lights going on with certain maneuvers. When lights on, car would turn off, while driving, if washers turned on. Dealer replaced alternator and thermostat, supposedly fixing, however, 3 days later same problem recurred and car turned off while traveling 70+ mph on major highway. Luckily, despite harrowing "near death" experience, we were able to maneuver off the road to await a tow.
The contact owns a 2018 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the…
Read full complaint
The contact owns a 2018 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirm parts not available.
The contact owns a 2018 Toyota Rav4. The contact stated that after entering the vehicle, she became aware that the front passenger’s side seat was wet. The contact stated that it was raining, and she thought that she had left the front passenger’s side window slightly open. The contact stated that as she was drying the front pas…
Read full complaint
The contact owns a 2018 Toyota Rav4. The contact stated that after entering the vehicle, she became aware that the front passenger’s side seat was wet. The contact stated that it was raining, and she thought that she had left the front passenger’s side window slightly open. The contact stated that as she was drying the front passenger’s side seat and became aware that water was leaking from the where the passenger’s side handle attached to roof of the vehicle. The contact stated that water had saturated the pillar and the front passenger’s side door covering. The contact was concerned that using the door or locking the door could result in a short circuit. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 75,000.
I have recently attempted to exchange my current vehicle for another. However, I have discovered through a thorough examination of the carfax report that there is a recall on this particular vehicle. Unfortunately, no solution has been provided for this issue. As a result, the value of my car has been significantly impacted and …
Read full complaint
I have recently attempted to exchange my current vehicle for another. However, I have discovered through a thorough examination of the carfax report that there is a recall on this particular vehicle. Unfortunately, no solution has been provided for this issue. As a result, the value of my car has been significantly impacted and the offer I have been given is considerably lower than its true value. In an effort to address this matter, I have reached out to Toyota and was informed that they are unable to take any action on this vehicle at the present time. This car is regularly used by my wife to transport our daughter to school, thus its safety and reliability are of utmost importance. Consequently, I am in urgent need of replacing this vehicle with a suitable alternative.
The contact owns a 2018 Toyota Rav4. The contact stated while driving 40 MPH, the vehicle was transmitting heat and a foul odor. The contact stated that the heat and odor entered the cabin of the vehicle even though the air condition was not activated. The contact stated that the heat was coming from the engine compartment. No w…
Read full complaint
The contact owns a 2018 Toyota Rav4. The contact stated while driving 40 MPH, the vehicle was transmitting heat and a foul odor. The contact stated that the heat and odor entered the cabin of the vehicle even though the air condition was not activated. The contact stated that the heat was coming from the engine compartment. No warning lights were illuminated. The vehicle was not taken to the dealer. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 55,000.
The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was not yet available. The contact drove the vehicle to the residence and while attempting to leave, the vehicle had no electrical power. The contact took the ba…
Read full complaint
The contact owns a 2018 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was not yet available. The contact drove the vehicle to the residence and while attempting to leave, the vehicle had no electrical power. The contact took the battery to be tested and the battery tested to be in proper working order. The battery was replaced in the vehicle and the contact became aware that the wires were damaged. The vehicle was diagnosed but not repaired due to parts not being available. The contact stated that the wires should be replaced after seeing sparks coming from under the hood of the vehicle. The manufacturer was made aware of the issue. The failure mileage was approximately 136,000. VIN tool confirms parts not available.
Airbags malfunctioned "SRS Airbag System Malfunction Visit Your Dealer" error message after head on collision. No warning lights before crash. Car is transferred ownership to progressive.
Official recalls
323V734000 · Electrical SYSTEM:12V/24V/48V Battery
Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
19V503000 · Equipment:other:labels
Jun 28, 2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
17V831000 · Equipment:other:labels
Dec 20, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.