The hands free feature over the cars microphone/stereo is unusable; leaving vehicle owners frustrated, and more likely to operate cellphones outside of standard hands free practices. I have been on numerous phone calls where people have told me that they were unable to hardly hear a thing I was saying. To remedy this problem…
Read full complaint
The hands free feature over the cars microphone/stereo is unusable; leaving vehicle owners frustrated, and more likely to operate cellphones outside of standard hands free practices. I have been on numerous phone calls where people have told me that they were unable to hardly hear a thing I was saying. To remedy this problem I have 1. Tried speaking up (even yelling) 2. Turning off HVAC systems 3. Positioning my body closer to the microphone 4. Bringing the car to a slow or stop to reduce road noise. 5. Calling myself to see if I can hear myself. 6. Talked with someone who owns the same car (year/model/spec/trim) and they were hardly audible as they called me over their hands free system.
NHTSA ODI #11749459
Mileage unknown · Mar 21, 2026
Unknown Or Other
Iam having transmission issues. I have been to 3 different Mechanic shops, 2 being transmission specialist. Going to a Toyota dealership on 3/26/26 to confirm. Was told I need a whole new transmission, My rav4 is a 2018 with only 115k for miles No engine light on or have any codes. I have spent a bit of money trying to address t…
Read full complaint
Iam having transmission issues. I have been to 3 different Mechanic shops, 2 being transmission specialist. Going to a Toyota dealership on 3/26/26 to confirm. Was told I need a whole new transmission, My rav4 is a 2018 with only 115k for miles No engine light on or have any codes. I have spent a bit of money trying to address this issue. and was told that this particular year has a lot of transmission issues and have over 100 on back order. why is this not a recall?
NHTSA ODI #11726041
Mileage unknown · Oct 27, 2025
Unknown Or OtherFire
I had just gotten off my vehicle, we were at a shopping center specifically Marshall’s, the employee announced a blue Toyota, I went outside and my car was in flames, the Fire Department said it was an electrical fire. I had never received a letter of a recall let alone Toyota calling me to tell my car was defective. Not only un…
Read full complaint
I had just gotten off my vehicle, we were at a shopping center specifically Marshall’s, the employee announced a blue Toyota, I went outside and my car was in flames, the Fire Department said it was an electrical fire. I had never received a letter of a recall let alone Toyota calling me to tell my car was defective. Not only until after my vehicle was damaged I received a call from them which made it suspicious.
NHTSA ODI #11695777
Mileage unknown · Oct 3, 2025
Unknown Or Other
I purchased my 2018 Toyota RAV4 Limited Hybrid in June 2018. The automatic liftgate has been a consistent issue with this vehicle since January 2024. It either fails to close completely or takes an unusually long time to shut. I followed the official Toyota dealership videos and performed the recommended recalibration steps, but…
Read full complaint
I purchased my 2018 Toyota RAV4 Limited Hybrid in June 2018. The automatic liftgate has been a consistent issue with this vehicle since January 2024. It either fails to close completely or takes an unusually long time to shut. I followed the official Toyota dealership videos and performed the recommended recalibration steps, but the problem remains unresolved. This is not just a matter of convenience. It presents a safety concern, particularly when loading items at night. Living in the Pacific Northwest, where it gets dark around 5 p.m., makes this even more concerning. I’m aware there is existing litigation related to this issue.
NHTSA ODI #11691142
Mileage unknown · Sep 11, 2025
Unknown Or Other
On September 3, 2025, I was driving down the I-10 in Biloxi, MS, at 6:45 a.m. It was around 75-80 degrees and the sun was just barely coming up. All of the sudden the glass in my sunroof completely shattered. There were no cars around me and it was an open portion of the road, so no rocks were flung up by nearby vehicles. Luckil…
Read full complaint
On September 3, 2025, I was driving down the I-10 in Biloxi, MS, at 6:45 a.m. It was around 75-80 degrees and the sun was just barely coming up. All of the sudden the glass in my sunroof completely shattered. There were no cars around me and it was an open portion of the road, so no rocks were flung up by nearby vehicles. Luckily, my kids were not with me, because a majority of the glass ended up in my backseat, ranging from huge chunks of about 3-4 inches in diameter to smaller shards being everywhere. I cut myself several times while trying to clean it up, so I can only imagine what it could have done to my kids! Luckily, I was able to keep my cool and not swerve off the road, as it was quite startling.
NHTSA ODI #11686505
Mileage unknown · Aug 31, 2025
Unknown Or Other
The tailgate does not lift all the way. The hinges are intact. I believe its a pistón or sensor problem.
NHTSA ODI #11684195
Mileage unknown · May 25, 2025
Electrical SystemUnknown Or Other
The recall (Manufacturer Recall # 23TB13; NHTSA Recall # 23V734) has been un-repaired since 1 Nov 2023. The un-repaired recall did not cause a safety issue in this case, but I have moved to Canada and the recall has prevented me from registering and using the vehicle (it is not possible to complete the import process or regist…
Read full complaint
The recall (Manufacturer Recall # 23TB13; NHTSA Recall # 23V734) has been un-repaired since 1 Nov 2023. The un-repaired recall did not cause a safety issue in this case, but I have moved to Canada and the recall has prevented me from registering and using the vehicle (it is not possible to complete the import process or register any vehicle that has an outstanding recall).
NHTSA ODI #11663001
Mileage unknown · May 19, 2025
Unknown Or Other
The recall was for the battery size. This issues has been repaired by the Toyota Dealership 6969 Tyee Dr. SW Tumwater, Wa 98512 360 539-4000. Customer# [XXX] and invoice # [XXX]. I do not understand why I am getting notified of this recall from 2023 stating it has not been taken care of as of this date. INFORMATION REDACTED …
Read full complaint
The recall was for the battery size. This issues has been repaired by the Toyota Dealership 6969 Tyee Dr. SW Tumwater, Wa 98512 360 539-4000. Customer# [XXX] and invoice # [XXX]. I do not understand why I am getting notified of this recall from 2023 stating it has not been taken care of as of this date. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11661930
Mileage unknown · May 17, 2025
Unknown Or Other
The recall (Manufacturer Recall # 23TB13; NHTSA Recall # 23V734) has been un-repaired since 1 Nov 2023. The un-repaired recall has not caused a safety issue in my case, but I have moved to Canada and the recall has prevented me from registering and using the vehicle for over a year (it is not possible to complete the import pr…
Read full complaint
The recall (Manufacturer Recall # 23TB13; NHTSA Recall # 23V734) has been un-repaired since 1 Nov 2023. The un-repaired recall has not caused a safety issue in my case, but I have moved to Canada and the recall has prevented me from registering and using the vehicle for over a year (it is not possible to complete the import process or register any vehicle that has an outstanding recall).
NHTSA ODI #11661595
Mileage unknown · May 10, 2025
Electrical SystemEngineUnknown Or Other
The recall (NHTSA Recall # 23V734) has been un-repaired since 1 Nov 2023. The un-repaired recall did not cause a safety issue in my case, but I have moved to Canada and the recall has prevented me from registering and using the vehicle for the last for the past year (it is not possible to complete the import process or registe…
Read full complaint
The recall (NHTSA Recall # 23V734) has been un-repaired since 1 Nov 2023. The un-repaired recall did not cause a safety issue in my case, but I have moved to Canada and the recall has prevented me from registering and using the vehicle for the last for the past year (it is not possible to complete the import process or register any vehicle that has an outstanding recall).
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect load information label can result in the operator overloading the vehicle and increasing the risk of a crash.
Remedy: Toyota will notify owners and provide them with corrected labels, free of charge. The recall began on January 23, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are H0Z for Toyota vehicles, and HLF for Lexus vehicles.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration