NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
62 reportsClear category filterMileage unknown · Jun 2, 2024
Unknown Or Other
Hinge failed on the back lift gate, which in turn damaged the cylinder as well. Back lift gate would not close as a result of this failure. Back lift gate could have fallen off of vehicle, possibly resulting in injury or death to others. Multiple failure issues with the lift gate are common on internet sites and are known to d…
Read full complaint
Hinge failed on the back lift gate, which in turn damaged the cylinder as well. Back lift gate would not close as a result of this failure. Back lift gate could have fallen off of vehicle, possibly resulting in injury or death to others. Multiple failure issues with the lift gate are common on internet sites and are known to dealers. The repair facility acknowledged this was a common problem with the 2017 Toyota RAV4. The vehicle was inspected and repaired by an authorized service center, as advised by Hendrick Toyota of Wilmington (NC). The repair was performed by Jeff Gordon Chevrolet/Hendrick Collision Center in Wilmington NC. There were no warning signs of this failure. The lift gate failure occurred on [XXX]. The dealer was notified and vehicle inspected by Hendrick Toyota on [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11592033
Mileage unknown · May 24, 2024
Unknown Or Other
About two months ago (March 2024), a smell started to appear in the vehicle cabin whenever the vehicle is being driven. It became stronger over time and is particularly strong when the HVAC system was being used. I took the vehicle to a reputed independent repair shop who diagnosed the problem as leaking AC coolant within the …
Read full complaint
About two months ago (March 2024), a smell started to appear in the vehicle cabin whenever the vehicle is being driven. It became stronger over time and is particularly strong when the HVAC system was being used. I took the vehicle to a reputed independent repair shop who diagnosed the problem as leaking AC coolant within the passenger cabin. They gave a printed diagnosis that I then shared with Toyota because the vehicle mileage is under 35,000, for assistance in fixing this problem. However, Toyota North America manager Michael from their Corporate Headquarters in Plano, Texas informed me today (May 24, 2024) that Toyota does not want to help me with the repair because I had been using an independent repair shop instead of the Toyota dealership for regular maintenance on my vehicle. I am stuck with a vehicle that cannot be used due to a strong odor of AC coolant which is potentially hazardous. An internet search reveals numerous others who have experienced similar issues with their RAV4 vehicles, so it would be in the interests of the general public to report this to the NHTSA so that action can be taken if this problem is found to be widespread.
NHTSA ODI #11590668
Mileage unknown · Apr 20, 2024
Unknown Or Other
Toyota RAV4 sunroof shattered for no reason. Car was sitting all day under my carport. I opened driver door. Needed to go back in the house. I closed the driver door. Sunroof shattered. If I had been in the car, or driving, it could have caused very serious cuts, or a deadly accident. No warning signs at all. Car is presently at…
Read full complaint
Toyota RAV4 sunroof shattered for no reason. Car was sitting all day under my carport. I opened driver door. Needed to go back in the house. I closed the driver door. Sunroof shattered. If I had been in the car, or driving, it could have caused very serious cuts, or a deadly accident. No warning signs at all. Car is presently at Clearwater Toyota being fixed. Insurance (State Farm) has been contacted and is taking care of my claim.
NHTSA ODI #11584205
Mileage unknown · Apr 15, 2024
SteeringSuspensionUnknown Or Other
I PURCHASED THIS VEHICLE USED IN JULY OF 2023. THERE HAD BEEN A PERSISTANT CLUNKING NOISE IN THE REAR WHEN THE ROAD IS BUMPY ALONG WITH SOME STABILTY OR SWAYING FEELING. I HAD IT INSPECTED BY INDEPENDANT MECHANICAL SHOPS. I WAS ADVISED TO REPLACE THE SHOCK ABSORBERS AND THE STABILIZER LINKS WHICH I DID. THE RT REAR SHOCK ABOSBOR…
Read full complaint
I PURCHASED THIS VEHICLE USED IN JULY OF 2023. THERE HAD BEEN A PERSISTANT CLUNKING NOISE IN THE REAR WHEN THE ROAD IS BUMPY ALONG WITH SOME STABILTY OR SWAYING FEELING. I HAD IT INSPECTED BY INDEPENDANT MECHANICAL SHOPS. I WAS ADVISED TO REPLACE THE SHOCK ABSORBERS AND THE STABILIZER LINKS WHICH I DID. THE RT REAR SHOCK ABOSBORBER WAS BAD. MARCH OF 2024 I TOOK A ROAD TRIP TO FLORIDA. FIRST LONG TRIP SINCE REPLACING THE PARTS. ON THE DRIVE DOWN I WAS BY MYSELF AND FELT AS THOUGH THE REAR OF THE VEHICLE WAS SWAYING BACK AND FORTH A LOT WORSE THAN BEFORE CHANGING THE PARTS LISTED ABOVE. I THOUGHT MAYBE IT WAS THE CONDITION OF THE ROADS. ON THE WAY HOME MY SON WAS FOLLOWING ME IN HIS VEHCLE. HE HAD TOLD ME THAT WHEN THE "SWAYING" FEELING IS HAPPENING THE REAR OF THE VEHICLE IS MOVING SEPARATE TO THE FRONT. THE CLUNKING SOUND IS STILL THERE AND THAT STABILITY ISSUE SEEMS TO HAVE WORSEN SINCE CHANGING THE SUSPENSION PARTS PREVIOUSLY LISTED. THERE WAS A POINT IN DRIVING HOME IN THE RAIN WHERE I DEFINITELY FELT THE ABITLITY TO CONTROL THE VEHICLE WAS DIFFICULT AND DANGEROUS. I WILL BE TAKING THE VEHICLE TO BE INSPECTED FURTHER. I'VE READ INFORMATION ON A TOYOTA FORUM THAT THERE ARE OTHER OWNERS EXPERIENCING THIS ISSUE. I DO HAVE VIDIO AND YOU CAN SEE MY BODY ROCKING BACK AND FORTH IN THE DRIVER SEAT WHILE IT'S HAPPENING AND THE HOOD SWAYING BUT AM UNABLE TO UPLOAD IT.
NHTSA ODI #11582995
Mileage unknown · Mar 7, 2024
Unknown Or Other
I received this recall notice several months ago, and the letter stated that the remedy would be available in middle of 2024. I have had an inspection that confirmed I have a replacement battery, not an original. If there is a potential that the vehicle could catch on fire, it seems as though waiting until the middle of 2024 is …
Read full complaint
I received this recall notice several months ago, and the letter stated that the remedy would be available in middle of 2024. I have had an inspection that confirmed I have a replacement battery, not an original. If there is a potential that the vehicle could catch on fire, it seems as though waiting until the middle of 2024 is an unreasonable amount of time.
NHTSA ODI #11576038
Mileage unknown · Feb 22, 2024
SeatsUnknown Or OtherCrashInjury
I would like to report my safety concerns from the crash accident. Feb.14 Wednesday I drove my wife’s car 2017 Toyota RAV4 XLE. On intersection l stop completely on red stop lights.l was first, had no car up front of me.Than from behind other car Ford Focus fit me with a full speed 45. I was only in the car. On the hit my seat s…
Read full complaint
I would like to report my safety concerns from the crash accident. Feb.14 Wednesday I drove my wife’s car 2017 Toyota RAV4 XLE. On intersection l stop completely on red stop lights.l was first, had no car up front of me.Than from behind other car Ford Focus fit me with a full speed 45. I was only in the car. On the hit my seat slid forward causing my knees to hit the dashboard. Then the seat flattened causing me to fall backward.Also the cover of moonroof got opened. While lying back on flat seat l saw sky.I was able to self extricate.l was in shock from what just happened.3 hours after the accident l had gradual onset neck pain, shoulder pain, back pain, and a generalized headache.After 5 hours l Went to ER on same day , than again ER next Monday , than l saw my primary care doctor a week later-next Wednesday. Now if l will have a child in baby seat or teenager or adult seating behind driver , for sure they will get hurt badly or injured or killed. I have reported this situation to Toyota HQ. They responded that this accident will be under investigation. P.S. Takata airbags did not blow out
NHTSA ODI #11573287
Mileage unknown · Feb 9, 2024
Unknown Or Other
Fuel pump has small leak causing evaporative emissions codes and fuel to accumulate on top of the pump. This is the same concern which there is a recall for the 2018 models and beyond. They equipment is the same between the years and 2017 should be included in the recall as well.
NHTSA ODI #11571029
Mileage unknown · Jan 23, 2024
Electrical SystemFuel/propulsion SystemUnknown Or OtherCrashFireInjury
This vehicle was involved in a T-Bone crash, where the battery came out and the vehicle caught fire. The driver of this vehicle died at the scene. This involves NHTSA recall number 23V734 & Manufacturer Recall number 23TB13.
NHTSA ODI #11567168
Mileage unknown · Dec 29, 2023
Electrical SystemUnknown Or Other
Battery became disabled without any warning. Safety of driving down the road and battery stop working is an issue. I replaced battery through no help of Toyota. Only person to inspect was person replacing battery.
NHTSA ODI #11562641
Mileage unknown · Sep 25, 2023
Electrical SystemStructureUnknown Or OtherFire
The car was sitting in the driveway and caught fire around 11:29am. The car had not been driven or moved from the driveway for at least 2 days, and is up to date on all maintenance. The fire inspectors hypothesize the fire began from the battery and spread. After Googling, I have learned that Toyota Rav 4s from 2013 to 2018 had …
Read full complaint
The car was sitting in the driveway and caught fire around 11:29am. The car had not been driven or moved from the driveway for at least 2 days, and is up to date on all maintenance. The fire inspectors hypothesize the fire began from the battery and spread. After Googling, I have learned that Toyota Rav 4s from 2013 to 2018 had a large recall; 1.8 million vehicles taken because of the battery catching fire randomly. The remains of the vehicle are in the driveway of the residence. Both the police and fire department came to the scene. The safety of others was put at risk because it is only luck that nobody was in the car, or going to drive the vehicle as it caught fire randomly, bringing the residents of the home and owner of the car in extreme risk from both the fire and any explosions, damage to the house, and damage to others.
NHTSA ODI #11546441
Official recalls
3Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Jun 28, 2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
May 2, 2017
Gulf States Toyota, Inc. (Gulf States) is recalling certain 2017 4Runner , 86, Avalon, Camry, Camry Hybrid, Corolla, Corolla iM, Highlander, Highlander Hybrid, Prius, Prius C, RAV4, RAV4 Hybrid, Sienna and Yaris vehicles. The spare tire air pressure was not adjusted to the proper pressure as stated on the Tire Pressure Label.
Consequence & remedy
Consequence: A spare tire that is not inflated to the proper value may not perform as intended, increasing the risk of a crash.
Remedy: Gulf States will notify owners, and dealers will inspect the spare tires, adjusting their pressure as necessary, free of charge. The recall began June 15, 2017. Owners may contact Gulf States customer service at 1-800-444-1074. Toyota's number for this recall is 17R2.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration