NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
12 reportsClear category filterMileage unknown · Aug 18, 2025
Power TrainSteeringUnknown Or Other
While driving on or around 6/5/25, an active recall on my vehicle caused damage to my battery connections causing my vehicle to completely shut off while driving on an highway exit ramp. I almost lost complete control of the vehicle. Thankfully, the vehicle turned back on and I was able to get the vehicle to safety. I had to get…
Read full complaint
While driving on or around 6/5/25, an active recall on my vehicle caused damage to my battery connections causing my vehicle to completely shut off while driving on an highway exit ramp. I almost lost complete control of the vehicle. Thankfully, the vehicle turned back on and I was able to get the vehicle to safety. I had to get the car towed and repaired. The repair was directly related to the damage from an active recall issue being open without remedy for over 3 years on my vehicle. When I asked Toyota for reimbursement of under $200 they refused. This is a safety issue beyond the recall and I am concerned this is going to happen to someone else and there are going to be deaths. Toyota needs to stand by their recall too and may the financial aspect correct with me. Other members of the public need to be aware of the issues beyond their recall that can affect their cars and that Toyota is requiring them to be responsible for the damage that was caused while waiting on a remedy to the recall.
NHTSA ODI #11681378
Mileage unknown · May 7, 2025
Steering
The EPS system light came up creating a very dangerous driving situation, unable to turn the wheel. Car was taken to the dealer. Replaced computer assy.. Replaced negative terminal voltage sensor. Dealer stated that problem was taken care off. Problem persisted, brought car back three times. Keeps doing the same thing , warnin…
Read full complaint
The EPS system light came up creating a very dangerous driving situation, unable to turn the wheel. Car was taken to the dealer. Replaced computer assy.. Replaced negative terminal voltage sensor. Dealer stated that problem was taken care off. Problem persisted, brought car back three times. Keeps doing the same thing , warning light coming on , wheel no moving. First time it happened was on November 2024. At this time and date ( 5/6/2025) the car is located at the Toyota dealer in Hollywood Florida, being evaluated again.
NHTSA ODI #11659619
Mileage unknown · Apr 15, 2024
SteeringSuspensionUnknown Or Other
I PURCHASED THIS VEHICLE USED IN JULY OF 2023. THERE HAD BEEN A PERSISTANT CLUNKING NOISE IN THE REAR WHEN THE ROAD IS BUMPY ALONG WITH SOME STABILTY OR SWAYING FEELING. I HAD IT INSPECTED BY INDEPENDANT MECHANICAL SHOPS. I WAS ADVISED TO REPLACE THE SHOCK ABSORBERS AND THE STABILIZER LINKS WHICH I DID. THE RT REAR SHOCK ABOSBOR…
Read full complaint
I PURCHASED THIS VEHICLE USED IN JULY OF 2023. THERE HAD BEEN A PERSISTANT CLUNKING NOISE IN THE REAR WHEN THE ROAD IS BUMPY ALONG WITH SOME STABILTY OR SWAYING FEELING. I HAD IT INSPECTED BY INDEPENDANT MECHANICAL SHOPS. I WAS ADVISED TO REPLACE THE SHOCK ABSORBERS AND THE STABILIZER LINKS WHICH I DID. THE RT REAR SHOCK ABOSBORBER WAS BAD. MARCH OF 2024 I TOOK A ROAD TRIP TO FLORIDA. FIRST LONG TRIP SINCE REPLACING THE PARTS. ON THE DRIVE DOWN I WAS BY MYSELF AND FELT AS THOUGH THE REAR OF THE VEHICLE WAS SWAYING BACK AND FORTH A LOT WORSE THAN BEFORE CHANGING THE PARTS LISTED ABOVE. I THOUGHT MAYBE IT WAS THE CONDITION OF THE ROADS. ON THE WAY HOME MY SON WAS FOLLOWING ME IN HIS VEHCLE. HE HAD TOLD ME THAT WHEN THE "SWAYING" FEELING IS HAPPENING THE REAR OF THE VEHICLE IS MOVING SEPARATE TO THE FRONT. THE CLUNKING SOUND IS STILL THERE AND THAT STABILITY ISSUE SEEMS TO HAVE WORSEN SINCE CHANGING THE SUSPENSION PARTS PREVIOUSLY LISTED. THERE WAS A POINT IN DRIVING HOME IN THE RAIN WHERE I DEFINITELY FELT THE ABITLITY TO CONTROL THE VEHICLE WAS DIFFICULT AND DANGEROUS. I WILL BE TAKING THE VEHICLE TO BE INSPECTED FURTHER. I'VE READ INFORMATION ON A TOYOTA FORUM THAT THERE ARE OTHER OWNERS EXPERIENCING THIS ISSUE. I DO HAVE VIDIO AND YOU CAN SEE MY BODY ROCKING BACK AND FORTH IN THE DRIVER SEAT WHILE IT'S HAPPENING AND THE HOOD SWAYING BUT AM UNABLE TO UPLOAD IT.
NHTSA ODI #11582995
Mileage unknown · Aug 28, 2023
Steering
POWER STEERING IS LOCKING UP, NOT WANTING TO TURN.
NHTSA ODI #11541236
Mileage unknown · May 5, 2023
Service BrakesSteeringVehicle Speed Control
As I drive about 70 MPH, the ABS and the brake lights come on and the car is momentarily out of control. As I grabbed the tearing and reduce the speed dramatically, the system correct itself and I am able to continue driving at a very low speed.
NHTSA ODI #11520601
Mileage unknown · Feb 26, 2023
Electrical SystemSteering
Car will not start. Doesn't seem to be the battery. Got a jump start but same warning light illuminated.
NHTSA ODI #11509205
Mileage unknown · Sep 15, 2022
Steering
Although just aligned, steering consistently pulls to the right.
NHTSA ODI #11484726
76,000 miles · May 20, 2022
EngineSteeringCrashInjury
The driver owned a 2017 Toyota Rav4. The contact called on behalf of her son who was driving approximately 35 MPH when he lost control of the steering due to the functionality of the steering wheel and accidentally crashed into a pole. There were no warning lights. The 2 front and 1 side air bag deployed. The police and fire and…
Read full complaint
The driver owned a 2017 Toyota Rav4. The contact called on behalf of her son who was driving approximately 35 MPH when he lost control of the steering due to the functionality of the steering wheel and accidentally crashed into a pole. There were no warning lights. The 2 front and 1 side air bag deployed. The police and fire and ambulance arrived on the scene. The driver was transported to the hospital where he received a CT scan for his injury. There was a police report. The vehicle was destroyed and towed to a salvage yard. The manufacturer was notified of the failure. The approximate failure mileage was 76,000
NHTSA ODI #11465436
30,000 miles · Dec 27, 2021
Electrical SystemSteering
The contact owns a 2017 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the instrument cluster failed, which caused the speedometer and RPM gauge to be inoperable. Additionally, the power steering assist failed, and the steering wheel was locked up. The failure occurred on four separate occasions. The…
Read full complaint
The contact owns a 2017 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the instrument cluster failed, which caused the speedometer and RPM gauge to be inoperable. Additionally, the power steering assist failed, and the steering wheel was locked up. The failure occurred on four separate occasions. The vehicle was taken to the dealer and Toyota of Brookfield (20655 W Capitol Dr, Brookfield, WI 53045) however, the dealers could not duplicate the failure. Toyota of Brookfield informed the contact that there was a Manufacturer's Campaign Number: 21TG01 (Electrical System) associated with the VIN. The vehicle was not repaired and remained at Toyota of Brookfield. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.
NHTSA ODI #11445128
Mileage unknown · May 21, 2020
EngineService BrakesSteering
WATER PUMP LEAK I BELIEVE STARTED AROUND 21,000 MILES.ALONG WITH THE REPLACEMENT OF FRONT BRAKE PADS I COMPLAINED OF RIGHT FRONT SIDE OF CAR WITH SQUEALING NOISE POSSIBLE DRIVE BELT OR DIRTY ROTOR. AT ONE POINT BOTH FRONT ROTORS SLIGHTLY WARM TO TOUCH AFTER 45 MIN CITY DRIVE HOME, ANOTHER TIME RIGHT ROTOR HOT AND LEFT SLIGHTLY …
Read full complaint
WATER PUMP LEAK I BELIEVE STARTED AROUND 21,000 MILES.ALONG WITH THE REPLACEMENT OF FRONT BRAKE PADS I COMPLAINED OF RIGHT FRONT SIDE OF CAR WITH SQUEALING NOISE POSSIBLE DRIVE BELT OR DIRTY ROTOR. AT ONE POINT BOTH FRONT ROTORS SLIGHTLY WARM TO TOUCH AFTER 45 MIN CITY DRIVE HOME, ANOTHER TIME RIGHT ROTOR HOT AND LEFT SLIGHTLY WARM. THEY REPLACED FRONT BRAKE PADS NOT CHECKING CALIPERS OR HOSE AND JUST PUT ON BRAKE PADS AND SAID RIGHT TIRE WORN AND REPLACED BOTH AND SAID IT WILL SOLVE THE PROBLEM. AFTER A FEW DAYS TOYOTA REP AND TOLD HIM THE SAID INTERMITTENT SQUEALING SOMEWHAT GRIND NOISE WAS BACK. NOT TAKEN SERIOUSLY I REPORTED TO CORPORATE AND WENT TO ANOTHER DEALER TO DO DIAGNOSTIC CHECKING CALIPERS AND FOUND NOTHING. AROUND 50,000 MILES I FOUND POWDER NEXT TO DRIVE BELT. THEY DISCOVERED IT WAS A LEAKING WATER PUMP AND REPLACED MY PUMP AND DRIVE BELT. 41/2 MONTHS LATER THE CAR HAD SAME SQUEALING NOW RUBBER SOUND ADDED, STEERING STIFFER AND HISSING SOUND CAME FROM FRONT OF ENGINE AT LIGHT. TOOK IN AND COULDN'T FIND ANYTHING WRONG IN ENTIRE DAY 8 HRS. I DROVE AWAY AND BY THIRD LIGHT SQUEALING FOR 25 MINS AND NEIGHBORS HEARD ME COMING,ONE COUPLE REPORTED LOUD AT FRONT RIGHT TIRE. I REPORTED THAT IMMEDIATELY TO [XXX] AT PRECISION THAT MY CAR WAS WORSE AND TURNING STEERING WHEEL RIGHT AND LEFT IS NOW HAPPENING AS NEIGHBOR REPORTED BUT NO RETURN CALL. THIS CAR SOUND TYPICALLY HAPPENS AT BRAKING AT LIGHT AND HITTING GAS AT LIGHT ON CITY STREETS DRIVE AT 40-50 MILES PER HR.BUT USUALLY AT LIGHTS CAN HEAR. CALLED [XXX] AFTER LEFT SHOP CAR RIGHT AND LEFT TURNS SQUEAK WHEN TURNING STEERING WHEEL ONLY ONE DAY DID I HEAR TWO DIFFERENT SOUNDS WHIRRING NOISE AND HISSING SOUND 3 DAYS APART AT LIGHT STOPPED 3 WEEKS MY CAR, JUMPED FORWARD AT A STOP I'VE HAD IT ALIGNED NEW TIRES & STILL INTERMITTENT NOISE NOW WORSE DEC 2019 CHANGED WATER PUMP AND DRIVE BELT /SPRAYED ENGINE DOWN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #11325390
Official recalls
3Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Jun 28, 2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.
May 2, 2017
Gulf States Toyota, Inc. (Gulf States) is recalling certain 2017 4Runner , 86, Avalon, Camry, Camry Hybrid, Corolla, Corolla iM, Highlander, Highlander Hybrid, Prius, Prius C, RAV4, RAV4 Hybrid, Sienna and Yaris vehicles. The spare tire air pressure was not adjusted to the proper pressure as stated on the Tire Pressure Label.
Consequence & remedy
Consequence: A spare tire that is not inflated to the proper value may not perform as intended, increasing the risk of a crash.
Remedy: Gulf States will notify owners, and dealers will inspect the spare tires, adjusting their pressure as necessary, free of charge. The recall began June 15, 2017. Owners may contact Gulf States customer service at 1-800-444-1074. Toyota's number for this recall is 17R2.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration