NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
239 reports47,000 miles · Jul 27, 2019
Electrical SystemService BrakesUnknown Or Other
STARTED MY 2016 RAV4 LIMITED ON 7/27/2019. AFTER STARTING IT NONE OF THE SAFETY FEATURES ARE WORKING. THIS APPEARS TO BE A KNOWN ISSUE AMONG OTHER TOYOTA OWNERS. THE VEHICLE WAS FINE WHEN I SHUT IT OFF THE NIGHT BEFORE. NOW ANTI LOCK BRAKING, LANE DEPARTURE ALERT, PRE-COLLISION SYSTEM, AND ADAPTIVE CRUISE CONTROL ARE ALL F…
Read full complaint
STARTED MY 2016 RAV4 LIMITED ON 7/27/2019. AFTER STARTING IT NONE OF THE SAFETY FEATURES ARE WORKING. THIS APPEARS TO BE A KNOWN ISSUE AMONG OTHER TOYOTA OWNERS. THE VEHICLE WAS FINE WHEN I SHUT IT OFF THE NIGHT BEFORE. NOW ANTI LOCK BRAKING, LANE DEPARTURE ALERT, PRE-COLLISION SYSTEM, AND ADAPTIVE CRUISE CONTROL ARE ALL FAILING.
NHTSA ODI #11235293
41,000 miles · Jun 19, 2019
Unknown Or Other
MOONROOF DRAIN CLOGGED AND CAUSED WATER TO RUN DOWN A FRAME AND SEEP UNDER CARPET. VEHICLE IS NOW FULL OF MOLD DUE TO THE LEAK. AT THIS TIME THE LEAK IS FIXED BUT THE MOLD ISSUE PERSISTS. THIS BEEN CONFIRMED BY DEALER AND TOYOTA NATIONAL OFFICE. THERE IS NO MENTION OF THE DRAIN OR DRAIN MAINTENANCE IN THE MANUAL. THE MOLD IS A S…
Read full complaint
MOONROOF DRAIN CLOGGED AND CAUSED WATER TO RUN DOWN A FRAME AND SEEP UNDER CARPET. VEHICLE IS NOW FULL OF MOLD DUE TO THE LEAK. AT THIS TIME THE LEAK IS FIXED BUT THE MOLD ISSUE PERSISTS. THIS BEEN CONFIRMED BY DEALER AND TOYOTA NATIONAL OFFICE. THERE IS NO MENTION OF THE DRAIN OR DRAIN MAINTENANCE IN THE MANUAL. THE MOLD IS A SERIOUS HEALTH HAZARD. MY CURTAIN AIR BAG IS ALSO PROBABLY DAMAGED DUE TO WATER RUNNING DOWN THE FRAME. THE WATER MUST HAVE BEEN LEAKING FOR A WHILE BUT I DID NOT BECOME AWARE OF THE PROBLEM UNDER THE MOLD STARTED TO SMELL WHEN THE WEATHER GOT WARM. THE WATER ALSO HAS THE POTENTIAL TO DAMAGE CRUCIAL ELECTRICAL EQUIPMENT. NATIONAL TOYOTA OFFICE AND THE DEALER ARE DISMISSIVE ABOUT THE ISSUE. TOYOTA'S SOLUTION TO THIS PROBLEM IS "CALL YOUR INSURANCE" INSTEAD OF TAKING RESPONSIBILITY FOR NOT INFORMING THE CONSUMER ABOUT THE DRAINS. I WOULD NOT HAVE THIS ISSUE IF I WAS INFORMED TO PERIODICALLY CHECK THE DRAINS FOR DEBRIS. MY RAV4 FOR 41K MILES ON IT. USE IS NORMAL.
NHTSA ODI #11221319
21,000 miles · Jun 18, 2019
Service Brakes
MY BRAKES SEEM TO SCRAPE ABOUT THE FIRST 5 TIMES I USE THEM THEN THE SOUND GOES AWAY
NHTSA ODI #11220945
22,700 miles · May 20, 2019
Service Brakes
MY CAR HAS ONLY 22,700 MILES. FRONTS END BRAKES AND ROTOR ARE TOTALLY WORN OUT. THE CAR WAS DRIVEN NORMALLY.
NHTSA ODI #11208842
36,100 miles · Mar 30, 2019
Vehicle Speed Control
2016 TOYOTA RAV4 WAS STOPPED AT RED LIGHT AND SUDDENLY ACCELERATED AT HIGH RPM CAUSING THE VEHICLE TO LUNG FORWARD. HOLDING THE BRAKE PEDAL HARD DID NOT KEEP THE VEHICLE FROM GOING FORWARD. THERE WAS NO TRAFFIC AT THE TIME, WAS STOPPED AT A RED LIGHT WITH BRAKE ENGAGED, AT INTERSECTION ON US17, JACKSONVILLE, FL. VERY SERIOUS SA…
Read full complaint
2016 TOYOTA RAV4 WAS STOPPED AT RED LIGHT AND SUDDENLY ACCELERATED AT HIGH RPM CAUSING THE VEHICLE TO LUNG FORWARD. HOLDING THE BRAKE PEDAL HARD DID NOT KEEP THE VEHICLE FROM GOING FORWARD. THERE WAS NO TRAFFIC AT THE TIME, WAS STOPPED AT A RED LIGHT WITH BRAKE ENGAGED, AT INTERSECTION ON US17, JACKSONVILLE, FL. VERY SERIOUS SAFETY DISCREPANCY THAT HAS POTENTIAL TO CAUSE SEVERE ACCIDENT AND OR FATALITY.
NHTSA ODI #11192558
36,100 miles · Mar 30, 2019
Service Brakes
WHILE STOPPED AT A RED LIGHT THE VEHICLE ACCELERATED AND LUNGED FORWARD. BRAKES WOULD NOT HOLD THE VEHICLE FROM GOING FORWARD. HAD TO TURN THE VEHICLE OFF.
NHTSA ODI #11192556
1,000 miles · Mar 5, 2019
Electrical SystemEngine
TL* THE CONTACT OWNS A 2016 TOYOTA RAV4. WHILE ATTEMPTING TO MAKE A TURN FROM A STOP, THE VEHICLE LOST POWER. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE RESTARTED WITHIN TWO SECONDS, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO GETTEL TOYOTA OF LAKEWOOD (941-567-1080, LOCATED AT 5959 E. STATE RD 64, BRADENTON,…
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA RAV4. WHILE ATTEMPTING TO MAKE A TURN FROM A STOP, THE VEHICLE LOST POWER. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE RESTARTED WITHIN TWO SECONDS, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO GETTEL TOYOTA OF LAKEWOOD (941-567-1080, LOCATED AT 5959 E. STATE RD 64, BRADENTON, FL 34208) WHERE IT WAS DETERMINED THAT THE VEHICLE WAS PERFORMING AS DESIGNED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND DID NOT ASSIST. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE WAS APPROXIMATELY 1,000.
NHTSA ODI #11184350
30,000 miles · Feb 1, 2019
Power Train
I HAVE PROBLEM WITH CV JOINT LESS 30,000 MILES, TOYOTA TELL ME EVERYTHING IS GOOD WITH THE SUV, BUT HAVE SOME NOISE, NOW DON'T HAVE GOOD STABILITY WHEN A DRIVE
NHTSA ODI #11173443
22,000 miles · Dec 29, 2018
Service Brakes
I HAD A GRINDING NOISE IN THE FRONT BRAKES AND TOOK IT TO THE DEALER A COUPLE OF TIMES FINALLY THEY REPLACED THE BRAKES AND TURN THE ROTORS THAT WAS ABOUT SEVEN MONTHS AGO THAT NOISE STARTED AND THEY REPLACE THEM ABOUT A MONTH AGO AND NOW THEY'RE MAKING NOISE AGAIN I DON'T KNOW THERE'S A PROBLEM OR A DEFECT
NHTSA ODI #11163907
2 miles · Dec 3, 2018
Structure
HELLO, MY SUNROOF SHATTERED WITHOUT WARNING. ONE MORNING, I DECIDED TO OPEN MY SUNROOF. WHEN I PRESSED THE OPEN BUTTON, THE SUNROOF MADE A CRACKING NOISE THAT GOT WORSE AS THE SUNROOF OPENED. I WAS ON A RESIDENTIAL STREET AT THE TIME. TEMP: ABOUT 65 DEGREES.,OVERCAST.
NHTSA ODI #11155604
Official recalls
3Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Apr 22, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Additional source detail variants (2)
Equipment:other:labels
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Tires
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Apr 7, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Additional source detail variants (2)
Electronic Stability Control (esc)
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration