IllustrationHAVE TO REPLACE BRAKES ONLY AFTER 20K MILES. BATTERY BECOME DEAD AFTER 25K MILES
2016 Toyota RAV4
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2016 Toyota RAV4 do not stand out strongly from the model-year median of 258.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAV4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
810–25K
3625–50K
1450–75K
1075–100K
8100–150K
2150K+
151 reports with mileage · 88 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports12 fire reports21 injury reports
Unknown Or Other complaints
33 reportsTHE NAVIGATION DISPLAYS, RADIO AND ALL EQUIPMENT THAT USES IT QUITS AND SHUTS DOWN AND WILL GO OFF AND ON 3-8 TIMES AND THEN IT SEEMS TO BE OK. I WAS DRIVING THE VEHICLE DOWN THE HIGHWAY WHEN IT HAPPENS. THIS HAS HAPPEN MANY TIMES.
WHILE DRIVING ON A LOCAL ROAD I STARTED TO LOSE ELECTRICAL POWER. AT FIRST I LOST POWER STEERING AND SHORTLY AFTER THE HEAT STOPPED WORKING AND ALL THE LIGHTS ON THE DASHBOARD LIT UP. WHEN I BROUGHT THE CAR TO BE DIAGNOSED THE FUSE BOX HAD BEEN BURNED AND WIRES MELTED AND THERE WAS SMOKE INDICATING THERE HAD BEEN A FIRE AROUND T…
Read full complaint
WHILE DRIVING ON A LOCAL ROAD I STARTED TO LOSE ELECTRICAL POWER. AT FIRST I LOST POWER STEERING AND SHORTLY AFTER THE HEAT STOPPED WORKING AND ALL THE LIGHTS ON THE DASHBOARD LIT UP. WHEN I BROUGHT THE CAR TO BE DIAGNOSED THE FUSE BOX HAD BEEN BURNED AND WIRES MELTED AND THERE WAS SMOKE INDICATING THERE HAD BEEN A FIRE AROUND THE FUSE/ELECTRICAL AREA
IT SAYS IS SOMETHING WRONG WITH THE ECO OR PCM
HAVE BARELY HAD MY 2016 TOYOTA RAV4 A YEAR, WHEN LAST WEEK JUST LEFT WORK AND TURNED ONTO THE HWY ABOUT 10 MIN GOING ABOUT 65 MPH ON A STRAIGHT STRETCH. ALL OF A SUDDEN I HEARD A BLAST. FIRST I THOUGHT SOMEONE SHOT THE CAR, THEN THOUGHT MUST HAVE BLOWN A TIRE, BUT IT WAS STEERING FINE. I HEARD AIR AND LOOKED UP AT THE SUNROOF AN…
Read full complaint
HAVE BARELY HAD MY 2016 TOYOTA RAV4 A YEAR, WHEN LAST WEEK JUST LEFT WORK AND TURNED ONTO THE HWY ABOUT 10 MIN GOING ABOUT 65 MPH ON A STRAIGHT STRETCH. ALL OF A SUDDEN I HEARD A BLAST. FIRST I THOUGHT SOMEONE SHOT THE CAR, THEN THOUGHT MUST HAVE BLOWN A TIRE, BUT IT WAS STEERING FINE. I HEARD AIR AND LOOKED UP AT THE SUNROOF AND IT HAD SHATTERED AND EXPLODED, BIG CHUNK HAD BLOWN OUT. MORE LITTLE PIECES WERE BLOWING OUT SO I SHUT THE COVER. TOOK A PICTURE OF MY DISPLAY SHOWING TEMP, SPEED ETC. WASN'T SURE WHAT TO DO, I WAS 30 MILES FROM TOWN, SO I DROVE TO GAS STATION FOR GAS, AND TOOK PICTURES. NEXT MORNING CALLED TOYOTA AND TOLD THEM WHAT HAPPENED. HE MADE ME AN APPT. FOR LATER THAT DAY. I SAID IT SHOULD BE NO COST TO ME AS IT'S OBVIOUSLY A DEFECT IN THE SUNROOF. HE SAID WE WILL TAKE A LOOK AT IT AND SEE IF A ROCK HIT IT OR SOMETHING. I SAID "NO ROCK HIT IT, IT JUST EXPLODED FOR NO REASON". WENT TO APPT AND SERVICE GUY HAD ONLY BEEN ON THE JOB FOR A COUPLE OF WEEKS, THEY SENT OUT MAINTENANCE MANAGER. SHE TRIED TO TELL ME A ROCK MUST HAVE HIT IT, I ARGUED THAT NOTHING HIT IT, IT JUST EXPLODED. THEN SERVICE DIRECTOR CAME OUT, HE SAID THERE'S NO WAY TO PROVE WHAT HAPPENED AND THAT IT SHOULD BE COVERED UNDER MY INSURANCE COMPREHENSIVE FOR GLASS REPAIR. I SAID SURE WITH A $500 DEDUCTIBLE THAT I WILL HAVE TO PAY. HE SAID WELL THERE'S NOTHING THAT WE CAN DO. THEY WROTE UP A REPAIR QUOTE AND GAVE THAT TO ME. THEN A COUPLE GUYS COVERED THE SUNROOF WITH STICKY PLASTIC TO KEEP THE RAIN AND OTHER STUFF OUT. OTHER THAN THAT THEY WERE NO HELP, THEY SAID THEY HAD NEVER HEARD OF THIS HAPPENING, WHICH I FIND HARD TO BELIEVE, SO WHEN I GOT HOME I RESEARCHED EXPLODING SUNROOFS AND FOUND THAT THERE ARE HUNDREDS OF COMPLAINTS. I FEEL IT IS A DEFECTIVE SUNROOF AND TOYOTA SHOULD PAY FOR THE REPAIRS.
PLEASE BE AWARE THAT NEWER TOYOTA CAR AND TRUCK MODELS ARE NOT COMPATIBLE FOR THE MOST PART, WITH THE LATEST TO SERIES OF APPLE IPHONES, THE 11 AND THE JUST RELEASED 12 SERIES. THIS HAS BEEN A KNOWN ISSUE FOR OVER A YEAR, YET NO RESOLUTION HAS BEEN PROVIDED. THIS IS A POTENTIAL SAFETY HAZARD ESPECIALLY IN STATES THAT REQUIRE HA…
Read full complaint
PLEASE BE AWARE THAT NEWER TOYOTA CAR AND TRUCK MODELS ARE NOT COMPATIBLE FOR THE MOST PART, WITH THE LATEST TO SERIES OF APPLE IPHONES, THE 11 AND THE JUST RELEASED 12 SERIES. THIS HAS BEEN A KNOWN ISSUE FOR OVER A YEAR, YET NO RESOLUTION HAS BEEN PROVIDED. THIS IS A POTENTIAL SAFETY HAZARD ESPECIALLY IN STATES THAT REQUIRE HANDS FREE USE OF A CELL PHONE WHILE OPERATING A VEHICLE. HOW CAN TWO LARGE COMPANIES NOT WORK TOGETHER TO PROVIDE THE NECESSARY INTEGRATION BETWEEN THEIR PRODUCTS TO ALLOW SAFE OPERATION OF THEIR VEHICLES AND PHONE. I ASK TO NHTSA TO INVESTIGATE THIS MATTER AND TAKE PROPER ACTIONS TO MITIGATE THIS RISK ASAP.
ALL FOUR DOOR LOCKS HAVE MALFUNCTIONED. EACH HAVE BEEN REPLACED. NOW THE REPLACEMENTS ARE ALSO FAILING. THE DOORS DO NOT LOCK OR UNLOCK WITH THE KEY FOB. MAKING IT IMPOSSIBLE TO GET INTO THE CAR WHEN I START THE CAR, THE DOORS ARE SUPPOSED TO LOCK AUTOMATICALLY, WHICH DOES NOT HAPPEN. MAKING IT INCREDIBLY UNSAFE ALL OF THE INF…
Read full complaint
ALL FOUR DOOR LOCKS HAVE MALFUNCTIONED. EACH HAVE BEEN REPLACED. NOW THE REPLACEMENTS ARE ALSO FAILING. THE DOORS DO NOT LOCK OR UNLOCK WITH THE KEY FOB. MAKING IT IMPOSSIBLE TO GET INTO THE CAR WHEN I START THE CAR, THE DOORS ARE SUPPOSED TO LOCK AUTOMATICALLY, WHICH DOES NOT HAPPEN. MAKING IT INCREDIBLY UNSAFE ALL OF THE INFORMATION IS AT NORTH HOLLYWOOD TOYOTA IT HAS BEEN GOING ON SINCE 2018.
I WAS DRIVING ON A CITY STREET AND I HEARD A LOUD CRACKING SOUND. MY SUNROOF CRACKED AND THE GLASS SHATTERED. I WAS NOT UNDER ANY SORT OF UNDERPASS OR TREE.
NEW APPLE IPHONE 11PROMAX. NO LONGER CAN GET HANDS FREE TEXTING SO SAFETY COMPROMISED. STATIONARY ,IN MOTION ALL ROADS
RAV4 HYBRID LIMITED WITH NAVIGATION. THE NAVIGATION CONTROL [MAPS / RADIO / VOLUME CONTROL] FREEZES SUDDENLY AND SCREEN IS NOT MANAGEABLE UNTIL THE CAR STOPS, ENGINE TURNED OFF AND BACK ON. ONE TIME, RADIO WAS LOUD, AND COULD NOT TURN IT DOWN AS THE SCREEN WAS FROZEN. HAS HAPPENED ABOUT ONCE EVERY TWO WEEKS.
Official recalls
323V734000 · Electrical SYSTEM:12V/24V/48V Battery
Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
16V236000 · Equipment:other:labels; Tires
Apr 22, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Additional source detail variants (2)
Equipment:other:labels
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Tires
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
16V198000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Apr 7, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Additional source detail variants (2)
Electronic Stability Control (esc)
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.