IllustrationHELLO, MY SUNROOF SHATTERED WITHOUT WARNING. ONE MORNING, I DECIDED TO OPEN MY SUNROOF. WHEN I PRESSED THE OPEN BUTTON, THE SUNROOF MADE A CRACKING NOISE THAT GOT WORSE AS THE SUNROOF OPENED. I WAS ON A RESIDENTIAL STREET AT THE TIME. TEMP: ABOUT 65 DEGREES.,OVERCAST.
2016 Toyota RAV4
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2016 Toyota RAV4 do not stand out strongly from the model-year median of 258.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAV4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
810–25K
3625–50K
1450–75K
1075–100K
8100–150K
2150K+
151 reports with mileage · 88 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports12 fire reports21 injury reports
Structure complaints
15 reportsWHEN IT RAINS THE DRIVER SIDE FLOORING AND MATS ARE COMPLETELY SOAKED ABSORBING UP TO 1 INCH OF WATER. THE CAR ISN'T DRIVEN MUCH SO THE PROBLEM ONLY STRUCK A BELL THIS YEAR. *JS
TL* THE CONTACT OWNS A 2016 TOYOTA RAV4. WHILE THE VEHICLE WAS STATIONARY, THE AUTOMATIC LIFTGATE CRASHED DOWN ONTO THE CONTACT, WHICH CAUSED INJURY AND DISCOLORATION TO THE CONTACT'S SPINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000. ..UPDATED 03/0…
Read full complaint
TL* THE CONTACT OWNS A 2016 TOYOTA RAV4. WHILE THE VEHICLE WAS STATIONARY, THE AUTOMATIC LIFTGATE CRASHED DOWN ONTO THE CONTACT, WHICH CAUSED INJURY AND DISCOLORATION TO THE CONTACT'S SPINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000. ..UPDATED 03/09/17 *BF CONSUMER STATED SHORTLY AFTER INJURY TOYOTA ISSUED A "LIMITED SERVICE CAMPAIGN" TO REMEDY OR REPLACE THE POWER BACK DOOR ECU (ELECTRONIC CONTROL UNIT). UPDATED 7/16/18*JB *TR
THIS SAFETY ISSUE WHICH I HAVE SEEN MENTIONED BY MANY OTHER BUYERS ONLINE AND HAVE PERSONALLY SEEN ON A 2015 RAV4 CONSISTS OF TWO PIECES OF PLASTIC MOLDING ON THE DASH BOARD WHICH APPEAR TO BE DESIGNED TO LOOK LIKE SHINY METAL MOLDINGS BUT EXHIBIT A VERY DANGEROUS GLARE FROM BOTH THE FRONT AND SIDE REFLECTIONS FROM THE SUN. EVEN…
Read full complaint
THIS SAFETY ISSUE WHICH I HAVE SEEN MENTIONED BY MANY OTHER BUYERS ONLINE AND HAVE PERSONALLY SEEN ON A 2015 RAV4 CONSISTS OF TWO PIECES OF PLASTIC MOLDING ON THE DASH BOARD WHICH APPEAR TO BE DESIGNED TO LOOK LIKE SHINY METAL MOLDINGS BUT EXHIBIT A VERY DANGEROUS GLARE FROM BOTH THE FRONT AND SIDE REFLECTIONS FROM THE SUN. EVEN WHEN WEARING SUNGLASSES IT CAN MAKE IT DIFFICULT TO SEE WHERE YOU ARE GOING. I SHOWED THIS ISSUE TO THE SALESMEN AND HE COULD SEE IT TOO. HE SAID THAT HE WOULD TRY AND FIND THE PHONE NUMBER FOR A TOYOTA REPRESENTATIVE AND CALL HIM ABOUT THE PROBLEM. AFTER NOT HEARING BACK FROM HIM I RETURNED A FEW DAYS LATER AND HE TOLD ME THAT NO ONE AT THE DEALERSHIP COULD LOCATE HIS NUMBER. HE THEN TALKED TO HIS MANAGER AND RETURNED TO TELL ME THAT HIS MANAGER WOULD SEND AN EMAIL TO THE REGIONAL REPRESENTATIVE TO SEE IF ANYTHING COULD BE DONE ABOUT THE PROBLEM. IT HAS BEEN MANY WEEKS NOW AND I HAVE NOT HEARD BACK FROM ANYONE ABOUT RESOLVING THIS SAFETY ISSUE.
THE SUNROOF EXPLODED WHILE DRIVING DOWN THE HIGHWAY. NO ROCK WAS SEEN BEFORE IT HAPPENED AND THE GLASS WAS CURVED OUTWARD WHEN WE STOPPED TO LOOK AT IT. FORTUNATELY, THE VISOR/COVER WAS BELOW IT SO THE GLASS SHARDS DID NOT SPRAY INTO OUR FACES. IT SOUNDED LIKE A BOMB WENT OFF. THIS IS EXTREMELY DANGEROUS AND WE HAVE NO OPTIO…
Read full complaint
THE SUNROOF EXPLODED WHILE DRIVING DOWN THE HIGHWAY. NO ROCK WAS SEEN BEFORE IT HAPPENED AND THE GLASS WAS CURVED OUTWARD WHEN WE STOPPED TO LOOK AT IT. FORTUNATELY, THE VISOR/COVER WAS BELOW IT SO THE GLASS SHARDS DID NOT SPRAY INTO OUR FACES. IT SOUNDED LIKE A BOMB WENT OFF. THIS IS EXTREMELY DANGEROUS AND WE HAVE NO OPTION BUT TO HAVE THE SUNROOF REPLACED. IT WOULD BE WISE TO ALWAYS DRIVE WITH THE SUNROOF COVER OVER THE GLASS TO PROTECT YOURSELF.
Official recalls
323V734000 · Electrical SYSTEM:12V/24V/48V Battery
Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
16V236000 · Equipment:other:labels; Tires
Apr 22, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence & remedy
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Additional source detail variants (2)
Equipment:other:labels
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
Tires
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2016 Toyota Yaris, Rav4, Land Cruiser and 4Runner vehicles, and Scion FR-S, iM, and TC vehicles manufactured January 28, 2016, to March 14, 2016. The Load Carrying Capacity Modification Label may not reflect the correct added weight of the installed accessories. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims for Passenger Cars."
Consequence: An incorrect label may result in the vehicle being overloaded, increasing the risk of a crash.
Remedy: SET will notify owners, and provide them a corrected label to be installed over the inaccurate label, free of charge. The recall began on June 3, 2016. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET16A.
16V198000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Apr 7, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Additional source detail variants (2)
Electronic Stability Control (esc)
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.