NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
303 reports123,000 miles · Jul 15, 2021
Electrical SystemEngineFire
The contact owned a 2015 Toyota Rav4. The contact stated that after pulling into the driveway after driving for approximately 30 minutes, the contact parked and exited the vehicle. The contact stated that approximately 10 minutes later there was a loud explosion heard. The contact looked out to see the vehicle on fire. The fire …
Read full complaint
The contact owned a 2015 Toyota Rav4. The contact stated that after pulling into the driveway after driving for approximately 30 minutes, the contact parked and exited the vehicle. The contact stated that approximately 10 minutes later there was a loud explosion heard. The contact looked out to see the vehicle on fire. The fire department was called and extinguished the fire. The contact was unsure if a fire report was filed. The vehicle was deemed a total loss. The cause of the failure was unknown. There were no injuries sustained. Neither the dealer nor the manufacturer was made aware of the failure. The approximate failure mileage was 123,000. The VIN was not provided.
NHTSA ODI #11424912
79,000 miles · Jun 28, 2021
Air BagsCrashInjury
The contact owns a 2015 Toyota Rav4. The contact stated that while driving at 30 MPH through an intersection, another vehicle had run a red light and hit the vehicle's passenger side. The air bags did not deploy upon impact. The contact's son was injured as a result of the accident but did not seek medical attention at the scene…
Read full complaint
The contact owns a 2015 Toyota Rav4. The contact stated that while driving at 30 MPH through an intersection, another vehicle had run a red light and hit the vehicle's passenger side. The air bags did not deploy upon impact. The contact's son was injured as a result of the accident but did not seek medical attention at the scene. The contact took his son to a local hospital after the accident where he was treated for a fractured right collar bone and fractured right sternum. A police report was not filed. The contact was able to drive the vehicle away from the scene and took the vehicle to an independent body shop for a diagnostic. The manufacturer was notified of the failure and informed him that they would investigate the failure. The vehicle had yet to be repaired. The failure mileage was approximately 79,000.
NHTSA ODI #11422599
Mileage unknown · Jun 23, 2021
Fuel/propulsion SystemUnknown Or Other
A. Mileage indicator: Full thank gives any where from 325-365 miles. But indicator goes down precipitously. If it indicates 20 miles, it will go down to 0 or 8 miles after only a 5 miles drive. B: The only safety I feel is put at risk is where it can leave me when my anticipated mileage suddenly goes below what was indicated. C:…
Read full complaint
A. Mileage indicator: Full thank gives any where from 325-365 miles. But indicator goes down precipitously. If it indicates 20 miles, it will go down to 0 or 8 miles after only a 5 miles drive. B: The only safety I feel is put at risk is where it can leave me when my anticipated mileage suddenly goes below what was indicated. C: Have reported to dealer a couple of times but always informed nothing defective could be detected D: Never received any warning signals. Just happens.
NHTSA ODI #11421998
50,493 miles · May 7, 2021
Fuel/propulsion SystemUnknown Or Other
ONGOING ISSUES WITH MY FUEL SYSTEM. CAR WILL DISPLAY ONE OF THESE MANY SYMPTOMS: -MISFIRE, HARD START, STALL OR SHUTOFF. OTHER SYMPTOMS INCLUDE CAR STUTTERING AND STALLING OUT WHILE DRIVING. THIS LAST SYMPTOM IS VERY DANGEROUS AS IT OFTEN COMES WITH NO WARNING. WHEN THE CAR STALLS OUT, THE CAR IS DRIVING UP STRAIGHT UP A MEDIUM…
Read full complaint
ONGOING ISSUES WITH MY FUEL SYSTEM. CAR WILL DISPLAY ONE OF THESE MANY SYMPTOMS: -MISFIRE, HARD START, STALL OR SHUTOFF. OTHER SYMPTOMS INCLUDE CAR STUTTERING AND STALLING OUT WHILE DRIVING. THIS LAST SYMPTOM IS VERY DANGEROUS AS IT OFTEN COMES WITH NO WARNING. WHEN THE CAR STALLS OUT, THE CAR IS DRIVING UP STRAIGHT UP A MEDIUM GRADE HILL. I HAVE EXPERIENCED THIS ON SEVERAL DIFFERENT DATES AND TIMES ALONG W 24TH ST. AUSTIN, TX NEAR 1106 W 24TH ST. THIS WILL HAPPEN IF I'M EITHER STOPPING AT A LIGHT OR WHILE IN MOTION. I DON'T HAVE THE EXACT MPH I AM DRIVING, BUT IT WOULD BE AROUND 20 - 40 MPH WHEN THIS OCCURS. IVE TAKEN THE CARE TO BOTH ROUND ROCK TOYOTA AND CHRISTIAN AUTO BROTHERS TO ADDRESS THE ISSUE. SO FAR, NEITHER HAVE BEEN ABLE TO DIAGNOSE THE PROBLEM. ON 5/22/20, CHRISTIAN AUTO BROTHERS REPLACED THE EVAPORATIVE EMISSIONS SYSTEM LEAK DETECTION UNIT R&R, THE FUEL EVAPORATIVE CANISTER R&R, THE EVAPORATIVE EMISSIONS SYSTEM LEAK DETECTION PUMP, AND THE VAPOR CANISTER PURGE SOLENOID. THIS DID NOT RESOLVE THE ISSUE. CURRENT CODES: P0441, P0455, P1604, P1605, P0171. WHILE NO DIAGNOSTIC PROOF HAS BEEN ESTABLISHED, IT IS HYPOTHESIZED BY THE MECHANICS THAT THERE IS AN ISSUE WITH EITHER THE FUEL PUMP OR THE FUEL LINE. AFTER READING ABOUT THE 2020 TOYOTA FUEL PUMP RECALL, I BELIEVE MY 2015 RAV4 HAS BEEN EXPERIENCING SIMILAR ISSUES. HOWEVER, IT IS NOT PART OF THE RECALL. THEREFORE I AM SUBMITTING THIS INCIDENT INFO TO DOCUMENT THE CURRENT SITUATION. IF I LEARN MORE, I WILL TRY TO UPDATE.
NHTSA ODI #11415574
95,000 miles · Apr 15, 2021
Structure
THE ROOF'S COLOR IS PEELING OFF.
NHTSA ODI #11408326
55,000 miles · Apr 11, 2021
Electrical SystemFire
CAR STALLED WHILE DRIVING AND BATTERY SET ON FIRE. BATTERY WAS LAST REPLACED IN OCTOBER 2020 AT TOYOTA DEALERSHIP.
NHTSA ODI #11407511
Mileage unknown · Apr 8, 2021
Electrical SystemSuspension
WHILE ON HIGHWAY OR CITY STREET AT TIMES THE RADIO AND PANEL LIGHTS FLICKER AND THE SOUND SYSTEM GOES OFF AND WILL NOT RETURN TILL I STOP THE VEHICLE AND TURN IT OFF THEN ONCE I START THE ENGINE THE SOUND SYSTEM WILL COME ON ONCE AGAIN. ALSO AT TIMES THE HIGH BEAMS WILL TAKE A WHILE TO COME ON. THE REAR DIIR WILL NOT OPEN IN AUT…
Read full complaint
WHILE ON HIGHWAY OR CITY STREET AT TIMES THE RADIO AND PANEL LIGHTS FLICKER AND THE SOUND SYSTEM GOES OFF AND WILL NOT RETURN TILL I STOP THE VEHICLE AND TURN IT OFF THEN ONCE I START THE ENGINE THE SOUND SYSTEM WILL COME ON ONCE AGAIN. ALSO AT TIMES THE HIGH BEAMS WILL TAKE A WHILE TO COME ON. THE REAR DIIR WILL NOT OPEN IN AUTOMATIC MUST BE HAND FORCED. THE REAR SUSPENSION IS AS IT DOES NOT EXIST
NHTSA ODI #11407137
55,234 miles · Mar 20, 2021
Structure
THE PAINT IS PEELING MY 2015 BLUE RAV, I HAVE VISITED MARK JACOBSEN TOYOTA IN DURHAM NC. SPOKE TO THE BODY SHOP, THEY SAID THIS IS THE SAME ISSUE THEY ARE SEEING ON THE WHITE CARS THAT ARE BEING REPAINTED PER THE LETTER ON YOUR WEBSITE HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2019/MC-10170749-9999.PDF THEY SAID AT THIS TIME TOYOTA…
Read full complaint
THE PAINT IS PEELING MY 2015 BLUE RAV, I HAVE VISITED MARK JACOBSEN TOYOTA IN DURHAM NC. SPOKE TO THE BODY SHOP, THEY SAID THIS IS THE SAME ISSUE THEY ARE SEEING ON THE WHITE CARS THAT ARE BEING REPAINTED PER THE LETTER ON YOUR WEBSITE HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2019/MC-10170749-9999.PDF THEY SAID AT THIS TIME TOYOTA IS NOT FIXING MY PEELING PAINT BECAUSE IT ISN'T WHITE. HE SUGGESTED I CALL THE NATIONAL HOTLINE, WHICH I DID AND FILE A CLAIM 21031900209 BUT THEY ALSO SAID THEY ARE ONLY FIXING WHITE PEELING PAINT. I THINK THEM FOR THEIR TIME AND REQUESTED TO SPEAK TO A SUPERVISOR- THEY HAVE NOT CALLED ME BACK YET.
NHTSA ODI #11404020
77,600 miles · Mar 17, 2021
Electrical SystemFire
THE VEHICLE STALLED WHILE I WAS DRIVING ON A HIGHWAY AT APPROXIMATELY 55 MPH. I HAD BEEN DRIVING FOR 15 MINUTES. I LOST POWER AT THE DASHBOARD, LOST POWER STEERING, AND THE ENGINE STOPPED RUNNING. I COASTED TO A SIDE STREET AND STOPPED THE CAR. I OPENED THE HOOD, AND DISCOVERED A FIRE IN THE ENGINE COMPARTMENT. THE BATTERY CABLE…
Read full complaint
THE VEHICLE STALLED WHILE I WAS DRIVING ON A HIGHWAY AT APPROXIMATELY 55 MPH. I HAD BEEN DRIVING FOR 15 MINUTES. I LOST POWER AT THE DASHBOARD, LOST POWER STEERING, AND THE ENGINE STOPPED RUNNING. I COASTED TO A SIDE STREET AND STOPPED THE CAR. I OPENED THE HOOD, AND DISCOVERED A FIRE IN THE ENGINE COMPARTMENT. THE BATTERY CABLE CLOSEST TO THE ENGINE WAS ON FIRE, AND HAD MELTED ONE CORNER OF THE BATTERY. A PASSERBY HELPED EXTINGUISH THE FIRE, AND THE FIRE DEPARTMENT WAS CALLED TO INSPECT AND MAKE SURE THE FIRE WAS OUT. EARLIER THAT DAY, THE VEHICLE STALLED IN THE SAME WAY WHILE DRIVING APPROXIMATELY 5 MPH IN A PARKING LOT, BUT THE POWER CAME BACK IN A FEW SECONDS. IMMEDIATELY PRECEDING THAT WAS A 1-HOUR DRIVE AT INTERSTATE HIGHWAY SPEEDS WITH NO TROUBLES.
NHTSA ODI #11403613
5,000 miles · Mar 9, 2021
EngineFire
I WAS DRIVING WITH MY 2 SONS FROM JFK AIRPORT TO WOODSIDE, QUEENS IN NEW YORK. WE JUST GOT OFF THE VAN WYKE HIGHWAY AND WERE TRAVELING WEST ON QUEENS BOULEVARD. THE SPEED LIMIT ON QUEENS BOULEVARD IS 25. WE WERE APPROACHING A RED LIGHT WHEN WE NOTICED SMOKE COMING FROM THE UNDER THE HOOD. I PULLED OVER AND TURNED OFF THE CAR,…
Read full complaint
I WAS DRIVING WITH MY 2 SONS FROM JFK AIRPORT TO WOODSIDE, QUEENS IN NEW YORK. WE JUST GOT OFF THE VAN WYKE HIGHWAY AND WERE TRAVELING WEST ON QUEENS BOULEVARD. THE SPEED LIMIT ON QUEENS BOULEVARD IS 25. WE WERE APPROACHING A RED LIGHT WHEN WE NOTICED SMOKE COMING FROM THE UNDER THE HOOD. I PULLED OVER AND TURNED OFF THE CAR, WHEN WE GOT OUT OF THE CAR WE NOTICED THERE WERE FLAMES STARTING TO COME OUT FROM UNDER THE HOOD. WE IMMEDIATELY GRABBED OUR ITEMS, PURSE, PHONE, COATS AND GOT AWAY SAFELY FROM THE CAR. WE CALLED 911 AND WITHIN A FEW MINUTES THE FIRE DEPARTMENT ARRIVED AND PUT OUT THE CAR. THE WHOLE FRONT OF OUR CAR AND DASH WERE BURNED AS WELL AS PART OF THE DRIVERS SEAT. OUR INSURANCE STATED THE CAR WAS TOTALED. OUR CAR WAS INSPECTED IN DECEMBER AND HAD LESS THAN 5,000 MILES. WE PURCHASED THE CAR NEW FROM TOYOTA IN 2015 AND HAD IT SERVICED BY THE DEALER EVERY 6 MONTHS. THE FIRE DEPARTMENT SAID LEAVES HAD CAUGHT FIRE, BUT IT HAD RAINED THAT DAY AND THE ENGINE SHOULD NOT GET HOT ENOUGH TO LIGHT LEAVES ON FIRE. AN ENGINE FIRE ON A 2015 CAR WITH LESS THAN 5000 MILES SHOULD NOT HAPPEN.
NHTSA ODI #11400064
Official recalls
4Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Mar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Dec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration