NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
60 reportsClear category filter70,000 miles · Jul 10, 2020
Unknown Or Other
REAR HATCH STRUT SEIZED AND BROKE CAUSING REAR HATCH DOOR TO NOT CLOSE COMPLETELY, REMOTE AND DOOR RELEASE IN CAR INOPERABLE. I HAD MY CAR SERVICED AND ADVISOR EXPLAINED THAT WATER (FROM WEATHER) CAUSED RUST AND LEFT STRUT BROKE. THE RIGHT STRUT IS CORRODED BADLY AND RECOMMENDED TO REPLACE AS WELL. TOTAL COST WOULD BE 1386.00 …
Read full complaint
REAR HATCH STRUT SEIZED AND BROKE CAUSING REAR HATCH DOOR TO NOT CLOSE COMPLETELY, REMOTE AND DOOR RELEASE IN CAR INOPERABLE. I HAD MY CAR SERVICED AND ADVISOR EXPLAINED THAT WATER (FROM WEATHER) CAUSED RUST AND LEFT STRUT BROKE. THE RIGHT STRUT IS CORRODED BADLY AND RECOMMENDED TO REPLACE AS WELL. TOTAL COST WOULD BE 1386.00 INCLUDED LEFT STRUT PART (427.00), RIGHT STRUT PART (739.00) AND ABOUT 200.00 IN LABOR. I CALLED TOYOTA CORPORATE FOR COMPLAINS AND THEY SAID THAT THERE WAS NO RECALLS AND THEIR WARRANTY WAS 3YR/3000 MILES WHICH DID NOT APPLY TO MY SITUATION. I CALLED MULTIPLE TOYOTA PARTS DEPTS, SOME OUT OF STATE TO COMPARE PRICES AND THEY REMAINED THE SAME. ONE PARTS EMPLOYEE INFORMED ME THAT THIS PART I NEEDED TO PROVIDE MY VIN NUMBER BECAUSE THESE STRUTS SUPPLY IS SPARSE AND THEY NEEDED TO SUPPLY LOCAL CUSTOMERS. I ASKED WHY THERE WASN'T A RECALL AND HE AGREED THAT THERE SHOULD BE ONE. AGREED THAT THE DESIGN IS POOR AND EXPECTATION TO LUBRICATE JOINTS TO PREVENT WATER DAMAGE ( WHICH WAS NOT IN ANY OF MY MAINTENANCE MANUELS.). I HAVE THE EXTENDED WARRANTY WHEN I PURCHASED MY NEW RAV4 AND ADVISOR CALLED AND PRESENTED PICTURES, THE CLAIM WAS DENIED.
NHTSA ODI #11338536
57,000 miles · May 7, 2020
Electrical SystemElectronic Stability Control (esc)Unknown Or Other
NUMEROUS TIMES OVER THE LAST COUPLE OF MONTHS MY CARS EPS LIGHT WILL COME ON AFTER PUTTING MY CAR INTO REVERSE THE CAR DOES NOT CONNECT AND GOES INTO NEUTRAL INSTEAD CAUSING THE CAR TO ROLL FORWARD CREATING HAZARDS BECAUSE IT HAPPENS ON HILLS AND FLAT AREAS. I THEN HAVE TO PUT MY CAR INTO PARK, TURN IT OFF AND RESTART THE CAR T…
Read full complaint
NUMEROUS TIMES OVER THE LAST COUPLE OF MONTHS MY CARS EPS LIGHT WILL COME ON AFTER PUTTING MY CAR INTO REVERSE THE CAR DOES NOT CONNECT AND GOES INTO NEUTRAL INSTEAD CAUSING THE CAR TO ROLL FORWARD CREATING HAZARDS BECAUSE IT HAPPENS ON HILLS AND FLAT AREAS. I THEN HAVE TO PUT MY CAR INTO PARK, TURN IT OFF AND RESTART THE CAR TO GET THE CAR TO GO INTO THE CORRECT GEAR. I HAVE TAKEN THE CAR TO TOYOTA BUT THEY WON?T DO ANYTHING BECAUSE MY VIN IS NOT UNDER RECALL. STARTING IN 2019 I STARTED NOTICING FLAKES OF PAINT IN CRACKS OF DOORWAYS AND CREASES OF THE CAR. LAST MONTH A BIG PIECE OF PAINT STARTED COMING OFF THE TOP OF MY CAR IN FRONT OF MY SUNROOF. *TR
NHTSA ODI #11323615
58,000 miles · Mar 3, 2020
Electrical SystemEngineUnknown Or OtherFire
SHORTLY AFTER DRIVING WITH NO ISSUES, THE PARKED CAR STARTED TO SMOKE FROM UNDERNEATH THE HOOD. WITHIN SECONDS, A LARGE FIRE HAD STARTED WHICH COMPLETELY CONSUMED THE CAR AND ALSO SPREAD TO MY WIFE'S CAR AND THE HOUSE'S CARPORT. INSURANCE INVESTIGATOR INFORMED US THAT THE FIRE LIKELY STARTED IN/NEAR THE ENGINE TOWARDS THE DRIV…
Read full complaint
SHORTLY AFTER DRIVING WITH NO ISSUES, THE PARKED CAR STARTED TO SMOKE FROM UNDERNEATH THE HOOD. WITHIN SECONDS, A LARGE FIRE HAD STARTED WHICH COMPLETELY CONSUMED THE CAR AND ALSO SPREAD TO MY WIFE'S CAR AND THE HOUSE'S CARPORT. INSURANCE INVESTIGATOR INFORMED US THAT THE FIRE LIKELY STARTED IN/NEAR THE ENGINE TOWARDS THE DRIVERS SIDE BASED ON WHERE THE HOTTEST PARTS OF THE FIRE APPEARED TO HAVE BEEN. HOWEVER, NO CONCLUSIVE DETERMINATION WAS MADE REGARDING THE CAUSE. THE CAR WAS IN GOOD CONDITION AND HAD NOT HAD ANY MAINTENANCE WORK PERFORMED ON IT RECENTLY. THERE WERE ALSO NO SIGNS OF INTRUSION BY RODENTS OR OTHER ANIMALS. THIS HAPPENED WITH NO WARNING. I'VE ALSO SINCE LEARNED THIS HAD HAPPENED ONLY ONE MONTH BEFORE TO THE PARENTS OF ONE OF OUR CHILDRENS' FRIENDS. THEY ALSO HAD A RAV4, ALTHOUGH NOT THE SAME MODEL YEAR (I BELIEVE IT WAS A 2013). I HAVE ALSO SEEN MANY OTHER REPORTS WHILE RESEARCHING THIS ISSUE. IF THERE IS A DEFECT OR DESIGN FLAW CONTRIBUTING TO THESE FIRES, IT SHOULD BE ADDRESSED QUICKLY!
NHTSA ODI #11315799
55,000 miles · Jan 3, 2020
Unknown Or Other
TWO DOORS (FRONT DRIVER AND PASSENGER SIDE DOORS) NO LONG LOCK AND UNLOCK USING THE KEY FOB OR THE AUTOMATIC BUTTONS ON THE DRIVER SIDE DOOR. ACCORDING TO OUR MECHANIC, THIS IS A KNOWN ISSUE (THE LOCK ACTUATOR) WITH TOYOTAS, ESPECIALLY SUVS AROUND 2015 LIKE RAV4S AND HIGHLANDERS. ON A COUPLE OF OCCASIONS, THE DOOR LOCK ITSELF GO…
Read full complaint
TWO DOORS (FRONT DRIVER AND PASSENGER SIDE DOORS) NO LONG LOCK AND UNLOCK USING THE KEY FOB OR THE AUTOMATIC BUTTONS ON THE DRIVER SIDE DOOR. ACCORDING TO OUR MECHANIC, THIS IS A KNOWN ISSUE (THE LOCK ACTUATOR) WITH TOYOTAS, ESPECIALLY SUVS AROUND 2015 LIKE RAV4S AND HIGHLANDERS. ON A COUPLE OF OCCASIONS, THE DOOR LOCK ITSELF GOT STUCK AND I HAD TO FIDDLE WITH IT SIMPLE TO OPEN THE DOOR MANUALLY. SURPRISED THIS HASN'T BEEN RECALLED SINCE IT HAS THE POTENTIAL FOR A SAFETY HAZARD. COST TO REPAIR EACH DOOR'S ACTUATOR (BY MECHANIC) IS OVER $500.
NHTSA ODI #11296842
68,000 miles · Nov 19, 2019
Unknown Or Other
DRIVING DOWN THE INTERSTATE WHEN THERE WAS A LOUD EXPLOSION. WHEN WE WERE ABLE TO STOP, WE SAW THAT OUR SUNROOF HAD EXPLODED. WE WERE VERY LUCKY THAT THE SHADE WAS CLOSED ON THE WINDOW. THERE WAS NOTHING AROUND US (VEHICLES, BRIDGES, ETC) TO CAUSE DEBRIS TO HIT THE SUNROOF TO CAUSE THE INCIDENT. THIS WAS AN EXTREMELY SCARY T…
Read full complaint
DRIVING DOWN THE INTERSTATE WHEN THERE WAS A LOUD EXPLOSION. WHEN WE WERE ABLE TO STOP, WE SAW THAT OUR SUNROOF HAD EXPLODED. WE WERE VERY LUCKY THAT THE SHADE WAS CLOSED ON THE WINDOW. THERE WAS NOTHING AROUND US (VEHICLES, BRIDGES, ETC) TO CAUSE DEBRIS TO HIT THE SUNROOF TO CAUSE THE INCIDENT. THIS WAS AN EXTREMELY SCARY THING THAT I HAVE FOUND OUT IS NOT UNCOMMON.
NHTSA ODI #11281075
26,859 miles · Nov 16, 2019
Unknown Or Other
WE WERE SIMPLY PULLING OUT OF OUR SUBDIVISION AND THE SUNROOF EXPLODED. IT WAS AROUND 6PM AND THE TEMPERATURE WAS ABOUT 28 DEGREES F.
NHTSA ODI #11280473
Mileage unknown · Oct 7, 2019
Unknown Or Other
AIR CONDITIONING SMELLS LIKE MOLD OR MILDEW WHEN TURNING IT ON ALL THE TIME.
NHTSA ODI #11266927
41,500 miles · Jun 1, 2019
Power TrainUnknown Or OtherCrash
THE POWER STICK SHIFT MOVES TO EASILY OUT OF GEAR. IT REQUIRES ONLY A LIGHT DEPRESSING OF THE BREAK TO DISENGAGE IT. ON MAY 17 2019, I HAD BEEN PARKED WITH THE CAR ON. I HAD DROPPED SOMETHING ON THE FLOOR AND WENT TO PICK IT UP. MY FOOT WAS LIGHTLY TOUCHING THE BREAK AS I BENT DOWN. THE BREAK WAS DEPRESSED JUST ENOUGH TO ALL…
Read full complaint
THE POWER STICK SHIFT MOVES TO EASILY OUT OF GEAR. IT REQUIRES ONLY A LIGHT DEPRESSING OF THE BREAK TO DISENGAGE IT. ON MAY 17 2019, I HAD BEEN PARKED WITH THE CAR ON. I HAD DROPPED SOMETHING ON THE FLOOR AND WENT TO PICK IT UP. MY FOOT WAS LIGHTLY TOUCHING THE BREAK AS I BENT DOWN. THE BREAK WAS DEPRESSED JUST ENOUGH TO ALLOW MY SHOULDER OR BACK TO HIT THE STICK SHIFT AND PUSH IT INTO REVERSE. UNBENOUNCED TO ME, AS I WAS STILL BENDING OVER TO PICK SOMETHING UP, THE CAR WAS PUSHED INTO REVERSE AND MOVED BACKWARDS INTO TWO CARS BEHIND ME. THIS COULD HAVE BEEN A REALLY TRAGIC SITUATION HAD SOMEONE BEEN BEHIND ME IN THE PARKING LOT. OR WORSE, IF I HAD A CHILD IN THE CAR AND I HAD GOTTEN OUT TO GET SOMETHING FROM THE TRUNK AND THE CHILD JUMPED INTO THE DRIVERS SEAT. I AM NOT VERY TALL, AND SO A CHILD COULD EASILY DEPRESS THE BRAKE JUST ENOUGH TO RELEASE THE STICK SHIFT AND COULD HAVE RUN ME OVER. THERE SHOULD BE A SECONDARY RELEASE BUTTON ON ALL STICK SHIFTS OR THE BRAKE PEDDLE SHOULD NEED TO BE DEPRESSED ALL THE WAY. THIS INCIDENT DAMAGED THREE CARS. AND WHILE NOT MY FAULT AS IT WAS A DEFECT OR SAFTEY ISSUE WITH THE CAR, MY INSURANCE HAS NOW BEEN DINGED FOR IT. I HAVE REPORTED IT TO TOYOTA BUT THEY DO NOT SEEM TO CARE.
NHTSA ODI #11217264
62,000 miles · May 25, 2019
Power TrainUnknown Or Other
WHINNING NOISE FROM REAR OF VEHICLE. HAPPENS IN ALL DRIVE MODES INCLUDING NEUTRAL
NHTSA ODI #11209907
85,000 miles · Jan 10, 2019
Unknown Or OtherInjury
MYSELF, MY DAUGHTER AND MY DAUGHTER'S FATHER WERE TRAVELING SOUTHBOUND ON INTERSTATE 89 TOWARDS BURLINGTON, VT. WE HEARD AN EXTREMELY LOUD BANG. IT SOUNDED LIKE AN EXPLOSION OR A GUN SHOT. THE SUNROOF HAD EXPLODED, NOT FROM ANY DEBRIS OR ROCK'JUST EXPLODED. IT WAS A TERRIFYING EXPERIENCE. LUCKILY WE ONLY GOT MINOR CUTS FROM…
Read full complaint
MYSELF, MY DAUGHTER AND MY DAUGHTER'S FATHER WERE TRAVELING SOUTHBOUND ON INTERSTATE 89 TOWARDS BURLINGTON, VT. WE HEARD AN EXTREMELY LOUD BANG. IT SOUNDED LIKE AN EXPLOSION OR A GUN SHOT. THE SUNROOF HAD EXPLODED, NOT FROM ANY DEBRIS OR ROCK'JUST EXPLODED. IT WAS A TERRIFYING EXPERIENCE. LUCKILY WE ONLY GOT MINOR CUTS FROM THE GLASS. THIS HAPPENED ON A BUSY HIGHWAY. THANKFULLY I MAINTAINED CONTROL OF THE CAR DESPITE THE EXPLOSION AND PULLED TO THE SIDE OF THE HIGHWAY. WE COULD HAVE BEEN KILLED OR KILLED SOMEONE ELSE IN ANOTHER CAR. NOW I AM FINDING OUT HOW OFTEN THIS TYPE OF THING HAPPENS AND WHY IS NOTHING BEING DONE ABOUT THIS. SUNROOFS NEED TO BE RECALLED. IT IS HORRIFYING THAT THIS HAS NOT BEEN ADDRESSED. IN ALL HONESTY, THIS PROBABLY WON'T CHANGE UNTIL SOMEONE DIES AS A RESULT OF THIS.
NHTSA ODI #11166239
Official recalls
4Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Mar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Dec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration