NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
37 reportsClear category filterMileage unknown · Jul 24, 2021
Electrical SystemEngineFire
Driver was driving on the highway when the screen turned off and on and the steering wheel seized momentarily. Approximately 5 minutes later, screen went blank again and could not accelerate. Driver pulled over to the side of the road. Strange noises were coming from under the hood and the car starting smoking and then caught on…
Read full complaint
Driver was driving on the highway when the screen turned off and on and the steering wheel seized momentarily. Approximately 5 minutes later, screen went blank again and could not accelerate. Driver pulled over to the side of the road. Strange noises were coming from under the hood and the car starting smoking and then caught on fire.
NHTSA ODI #11426275
123,000 miles · Jul 15, 2021
Electrical SystemEngineFire
The contact owned a 2015 Toyota Rav4. The contact stated that after pulling into the driveway after driving for approximately 30 minutes, the contact parked and exited the vehicle. The contact stated that approximately 10 minutes later there was a loud explosion heard. The contact looked out to see the vehicle on fire. The fire …
Read full complaint
The contact owned a 2015 Toyota Rav4. The contact stated that after pulling into the driveway after driving for approximately 30 minutes, the contact parked and exited the vehicle. The contact stated that approximately 10 minutes later there was a loud explosion heard. The contact looked out to see the vehicle on fire. The fire department was called and extinguished the fire. The contact was unsure if a fire report was filed. The vehicle was deemed a total loss. The cause of the failure was unknown. There were no injuries sustained. Neither the dealer nor the manufacturer was made aware of the failure. The approximate failure mileage was 123,000. The VIN was not provided.
NHTSA ODI #11424912
5,000 miles · Mar 9, 2021
EngineFire
I WAS DRIVING WITH MY 2 SONS FROM JFK AIRPORT TO WOODSIDE, QUEENS IN NEW YORK. WE JUST GOT OFF THE VAN WYKE HIGHWAY AND WERE TRAVELING WEST ON QUEENS BOULEVARD. THE SPEED LIMIT ON QUEENS BOULEVARD IS 25. WE WERE APPROACHING A RED LIGHT WHEN WE NOTICED SMOKE COMING FROM THE UNDER THE HOOD. I PULLED OVER AND TURNED OFF THE CAR,…
Read full complaint
I WAS DRIVING WITH MY 2 SONS FROM JFK AIRPORT TO WOODSIDE, QUEENS IN NEW YORK. WE JUST GOT OFF THE VAN WYKE HIGHWAY AND WERE TRAVELING WEST ON QUEENS BOULEVARD. THE SPEED LIMIT ON QUEENS BOULEVARD IS 25. WE WERE APPROACHING A RED LIGHT WHEN WE NOTICED SMOKE COMING FROM THE UNDER THE HOOD. I PULLED OVER AND TURNED OFF THE CAR, WHEN WE GOT OUT OF THE CAR WE NOTICED THERE WERE FLAMES STARTING TO COME OUT FROM UNDER THE HOOD. WE IMMEDIATELY GRABBED OUR ITEMS, PURSE, PHONE, COATS AND GOT AWAY SAFELY FROM THE CAR. WE CALLED 911 AND WITHIN A FEW MINUTES THE FIRE DEPARTMENT ARRIVED AND PUT OUT THE CAR. THE WHOLE FRONT OF OUR CAR AND DASH WERE BURNED AS WELL AS PART OF THE DRIVERS SEAT. OUR INSURANCE STATED THE CAR WAS TOTALED. OUR CAR WAS INSPECTED IN DECEMBER AND HAD LESS THAN 5,000 MILES. WE PURCHASED THE CAR NEW FROM TOYOTA IN 2015 AND HAD IT SERVICED BY THE DEALER EVERY 6 MONTHS. THE FIRE DEPARTMENT SAID LEAVES HAD CAUGHT FIRE, BUT IT HAD RAINED THAT DAY AND THE ENGINE SHOULD NOT GET HOT ENOUGH TO LIGHT LEAVES ON FIRE. AN ENGINE FIRE ON A 2015 CAR WITH LESS THAN 5000 MILES SHOULD NOT HAPPEN.
NHTSA ODI #11400064
20 miles · Mar 3, 2021
Electrical SystemEngineSteering
CAR RANDOMLY SHUT OFF ON MONDAY OF THIS YEAR.ALSO THE RADIO IS DEFECTIVE AND CAR TRY'S TO SWITCH GEARS WHILE DRIVING
NHTSA ODI #11398917
25 miles · Jan 24, 2021
Electrical SystemEngineSteering
DRIVING NORMAL, MADE A RIGHT TURN AND CAR SUDDENLY RESTARTS, STEERING WHEEL LOCKS UP DURING TURN FOR A COUPLE SECONDS. ELECTRIC RESTART ENGINE AND TURNS OFF THE CAR AND CAN'T GAS IT, ONLY BRAKE. CAR COMES BACK ON WITHOUT ME TURNING IT ON AND DOES NOT HAPPEN AGAIN REST OF THE DRIVE. DRIVING NORMAL FOR 2 DAYS AND ON THE 3RD DAY, E…
Read full complaint
DRIVING NORMAL, MADE A RIGHT TURN AND CAR SUDDENLY RESTARTS, STEERING WHEEL LOCKS UP DURING TURN FOR A COUPLE SECONDS. ELECTRIC RESTART ENGINE AND TURNS OFF THE CAR AND CAN'T GAS IT, ONLY BRAKE. CAR COMES BACK ON WITHOUT ME TURNING IT ON AND DOES NOT HAPPEN AGAIN REST OF THE DRIVE. DRIVING NORMAL FOR 2 DAYS AND ON THE 3RD DAY, ENGINE RESTARTS AGAIN RANDOMLY WHILE MAKING A RIGHT TURN, SAME EXACT DESCRIPTION AS DESCRIBED PREVIOUSLY. DRIVEN CAR FOR A DAY AND INCIDENT HASN'T REPEATED YET. BUT, NOW NOT SURE IF THIS AFFECTED IT, SENSORS OF CAR DOOR OPEN SIGN IS ON WHEN CAR IS TURNED OFF AND ALL DOORS AND WINDOWS ARE IN PLACE FOR LOCKING. ONLY WHEN CAR IS OFF AND I CANNOT FIX IT.
NHTSA ODI #11389673
58,000 miles · Mar 3, 2020
Electrical SystemEngineUnknown Or OtherFire
SHORTLY AFTER DRIVING WITH NO ISSUES, THE PARKED CAR STARTED TO SMOKE FROM UNDERNEATH THE HOOD. WITHIN SECONDS, A LARGE FIRE HAD STARTED WHICH COMPLETELY CONSUMED THE CAR AND ALSO SPREAD TO MY WIFE'S CAR AND THE HOUSE'S CARPORT. INSURANCE INVESTIGATOR INFORMED US THAT THE FIRE LIKELY STARTED IN/NEAR THE ENGINE TOWARDS THE DRIV…
Read full complaint
SHORTLY AFTER DRIVING WITH NO ISSUES, THE PARKED CAR STARTED TO SMOKE FROM UNDERNEATH THE HOOD. WITHIN SECONDS, A LARGE FIRE HAD STARTED WHICH COMPLETELY CONSUMED THE CAR AND ALSO SPREAD TO MY WIFE'S CAR AND THE HOUSE'S CARPORT. INSURANCE INVESTIGATOR INFORMED US THAT THE FIRE LIKELY STARTED IN/NEAR THE ENGINE TOWARDS THE DRIVERS SIDE BASED ON WHERE THE HOTTEST PARTS OF THE FIRE APPEARED TO HAVE BEEN. HOWEVER, NO CONCLUSIVE DETERMINATION WAS MADE REGARDING THE CAUSE. THE CAR WAS IN GOOD CONDITION AND HAD NOT HAD ANY MAINTENANCE WORK PERFORMED ON IT RECENTLY. THERE WERE ALSO NO SIGNS OF INTRUSION BY RODENTS OR OTHER ANIMALS. THIS HAPPENED WITH NO WARNING. I'VE ALSO SINCE LEARNED THIS HAD HAPPENED ONLY ONE MONTH BEFORE TO THE PARENTS OF ONE OF OUR CHILDRENS' FRIENDS. THEY ALSO HAD A RAV4, ALTHOUGH NOT THE SAME MODEL YEAR (I BELIEVE IT WAS A 2013). I HAVE ALSO SEEN MANY OTHER REPORTS WHILE RESEARCHING THIS ISSUE. IF THERE IS A DEFECT OR DESIGN FLAW CONTRIBUTING TO THESE FIRES, IT SHOULD BE ADDRESSED QUICKLY!
NHTSA ODI #11315799
6,000 miles · Jan 20, 2020
Engine
TEMPORARY LOSS OF POWER. ON A TRIP FROM SAN FRANCISCO TO CYPRESS, CA ON THE I-5 FREEWAY CRUISING AT 70 MPH A SUDDEN TEMPORARY LOSS OF POWER OCCURRED AT LEAST 30 TIMES (THIS WITH ODOMETER IN 6,000 MILE RANGE). I HAD REPORTED THIS PROBLEM TO MY TOYOTA DEALER AT APPROXIMATELY 3000 MILES. THEY SAID THEIR TECHNICIAN COULD NOT FIND AN…
Read full complaint
TEMPORARY LOSS OF POWER. ON A TRIP FROM SAN FRANCISCO TO CYPRESS, CA ON THE I-5 FREEWAY CRUISING AT 70 MPH A SUDDEN TEMPORARY LOSS OF POWER OCCURRED AT LEAST 30 TIMES (THIS WITH ODOMETER IN 6,000 MILE RANGE). I HAD REPORTED THIS PROBLEM TO MY TOYOTA DEALER AT APPROXIMATELY 3000 MILES. THEY SAID THEIR TECHNICIAN COULD NOT FIND ANY PROBLEM. AROUND 1/3/2020 I TOOK IT TO DEALER AND SAID I WOULD LEAVE IT THERE UNTIL THEY REPAIRED IT. I PURCHASED AN 8 YEAR EXTENDED WARRANTY IN OCT., 2014. AFTER. 4 DAYS DEALER CALLED FOR ME TO PICK IT UP. WAS TOLD THERE WAS NO PROBLEM, THEIR COMPUTER READ MY CAR COMPUTER AND FOUND THAT WHILE RIGHT FOOT WAS ON GAS AND LEFT FOOT EITHER NEAR OR ON THE BRAKE PEDAL WHEN IT OCCURRED. SINCE MY LEFT FOOT WAS RESTING ON MAT WITHOUT ANY MOVEMENT WHY DIDN'T THE LOSS OF POWER HAPPEN CONSTANTLY! THEY SAID IT WAS A SAFETY FEATURE. I SAY IT IS A DANGER.. I HAVE HAD IT HAPPEN MAKING RIGHT OR LEFT TURNS & STARTING WHEN SIGNAL TURNS GREEN. ON LINE I HAVE SEEN SAME COMPLAINTS. ONE MECHANIC SUGGESTED IT COULD BE A MASS AIR FLOW CIRCUIT MALFUNCTION. ANOTHER SAID IT COULD BE AIR FUEL RATIO SENSOR INTERMITTENTLY FAILING WHICH COULD TEST OK. NOTICE WE ONLY HAVE AROUND 6,000 MILES ON CAR WE BOUGHT IN OCT. 2014 BECAUSE PROBLEM CANNOT BE PREDICTED.
NHTSA ODI #11300449
Mileage unknown · Sep 28, 2019
Engine
PINK COOLANT KEPT DISAPPEARING. HAVE TO REFILL ONCE EVERY 6 MONTHS. FILL TO FULL AND 6 MONTHS LATER COOLANT WILL BE AT LOW LEVEL. CAR ONLY 4 YEARS OLD. IT HAD HAPPENED SINCE DAY 1.
NHTSA ODI #11258695
40,000 miles · Oct 19, 2018
EngineVehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2015 TOYOTA RAV4. WHEN THE CONTACT STARTED THE VEHICLE AND ATTEMPTED TO DRIVE FORWARD, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. AS A RESULT, THE VEHICLE CRASHED INTO THE FRONT PASSENGER TIRE OF A PARKED AND UNOCCUPIED VEHICLE. AFTERWARDS, THE ENGINE RPMS INCREASED AND THE VEHICLE CONTINUED TO REV …
Read full complaint
TL* THE CONTACT OWNS A 2015 TOYOTA RAV4. WHEN THE CONTACT STARTED THE VEHICLE AND ATTEMPTED TO DRIVE FORWARD, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. AS A RESULT, THE VEHICLE CRASHED INTO THE FRONT PASSENGER TIRE OF A PARKED AND UNOCCUPIED VEHICLE. AFTERWARDS, THE ENGINE RPMS INCREASED AND THE VEHICLE CONTINUED TO REV EVEN THOUGH THE CONTACT WAS DEPRESSING THE BRAKE PEDAL WITH BOTH FEET. THE CONTACT STATED THAT THE VEHICLE PROCEEDED TO MOVE BACKWARDS WHILE THE BRAKE PEDAL WAS STILL DEPRESSED. THE PASSENGER WAS ABLE TO REACH THE GEAR SHIFT AND PLACE IT IN THE PARK POSITION TO STOP THE VEHICLE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 40,000.
NHTSA ODI #11141402
70,000 miles · Oct 7, 2018
Electrical SystemEngineStructureFire
CAR STALLED SO I PULLED OVER. THERE WAS SMOKING UNDER THE HOOD. WITHIN MINUTES IT TURNED INTO A BIG FIRE. FIRE DEPARTMENT HAD TO BE CALLED.
NHTSA ODI #11138884
Official recalls
4Nov 1, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Dealers will replace the battery clamp sub-assembly, battery tray, and positive terminal cover, free of charge. Owner letters were mailed December 27, 2024, to 2013-2014 RAV4 owners. Additional owner notification letters will be mailed in phases, phase 2 will begin on May 14, 2025, and phase 3 in late July 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB13 and 23TA13.
Mar 13, 2015
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.
Consequence & remedy
Consequence: An unexpected loss of power steering increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
Jan 16, 2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence & remedy
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Additional source detail variants (2)
Trailer Hitches
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Exterior Lighting
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2013-2015 Toyota Rav4 vehicles manufactured June 1, 2013, to December 29, 2014, and equipped with an accessory trailer light module. The software within the module may incorrectly detect an electrical short and preventively turn off the electrical current and the trailer lights.
Consequence: If the system incorrectly detects an electrical short and turns off the trailer lights while the trailer is being towed at night, there is an increased risk of a crash.
Remedy: SET will notify owners, and dealers will replace the trailer light module with a new unit with corrected software, free of charge. The recall began on March 17, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-15A.
Dec 30, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2014-2015 Toyota 4Runner, Tacoma, FJ Cruiser, Land Cruiser, RAV4, Scion FRS, and XB vehicles. The affected vehicles may have accessories installed by SET, such as running boards or other items, that were incorrectly installed. The accessory attaching fasteners were not tightened with the proper torque, possibly causing the accessory to detach from the vehicle.
Consequence & remedy
Consequence: Accessories that detach from a vehicle may result in a vehicle crash and/or personal injury.
Remedy: SET will notify owners, and dealers will inspect and tighten the affected bolts, free of charge. The recall began February 23, 2015. Owners may contact SET customer service at 1-866-405-4226. SET's number for this recall is SET-14B.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21005 · Battery Hold Down Bracket Thermal Events
Opened Feb 25, 2021 · Closed Aug 12, 2024
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of opening, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration