Suspension. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

57 crash reports3 fire reports23 injury reports

Suspension complaints

101 reports

Clear category filter

100,393 miles · Oct 15, 2019

Suspension

Read full complaint

WE TOOK OUR TOYOTA RAV4 TO PRINCIPLE TOYOTA FOR THE SUSPENSION RECALL ON 10/16/2019. UPON A TIRE INSPECTION TODAY (AT A LOCAL TIRE STORE) IT WAS INDICATED TO US THAT PRINCIPLE TOYOTA DID NOT INSTALL THE APPROPRIATE ARMS ON THE CAR. I AM ATTACHING A COPY OF THE SERVICE RECORD (WHICH SHOWS WHAT APPEARS TO BE THE CORRECT REPLACEMENT PARTS) BUT THAT IS NOT WHAT WAS INSTALLED ON OUR VEHICLE. I FEEL THAT THIS WAS DONE IN RETALIATION BECAUSE UPON ARRIVING FOR MY PRE-SCHEDULED SERVICE APPOINTMENT PRINCIPAL TOYOTA STAFF SAID THEY DID NOT HAVE THE PARTS OR "SPECIAL TOOL" TO HANDLE THE RECALL. I AM ATTACHING AN EMAIL I SENT TO PRINCIPLE TOYOTA EXPRESSING MY DISGUST ON HOW THE "RECALL" WAS BEING HANDLED. ALONG WITH THE EMAIL IS THE PARTS "SUPPOSEDLY" PUT ON MY VEHICLE. I AM ATTACHING DOCUMENTATION SUPPORTING OUR STORY.

NHTSA ODI #11268695

186,181 miles · Jul 18, 2019

Suspension

Read full complaint

INSTALLED REAR LOWER SUSPENSION ARMS (NON-ADJUSTABLE REAR TOES) IN 2014 PER RECALL CAMPAIGN #16V596000. TIRE VENDOR SAID REAR ALIGNMENT WAS OFF IN 2016 (WHEN REPLACING NEW TIRES) AND COULD NOT BE ADJUSTED OR REPLACED WITH ADJUSTABLE TOE DUE TO RECALL STICKER. DEALER INSPECTED TOES 2016 AND SAID SPECS ARE RIGHT AND TIRE VENDOR DOES NOT HAVE RIGHT SPECS. SINCE 2016 I HAVE REPLACED 4 TIRES TWICE WITHIN 50,000 MILES EVEN THOUGH TIRES HAVE LONGER 50,000 MILE WARRANTIES. THE TIRES HAVE LASTED LESS THAN HALF OF THEIR EXPECTED LIFETIME. IN 2019, TIRE VENDOR SAID REAR ALIGNMENT IS OFF AGAIN WHEN REPLACING TIRES AND CAN'T BE ADJUSTED DUE TO RECALL STICKER. THIS SUGGESTS THAT THE REAR TOES INSERTED IN 2014 FOR SAFETY RECALL CREATED A NEW PROBLEM - POOR ALIGNMENT WHICH CAUSES PREMATURE WEARING OF TIRES. I'M REQUESTING PERMISSION TO REPLACE NON-ADJUSTABLE REAR TOES WITH ADJUSTABLE ONES SO THAT I DON'T HAVE TO KEEP PREMATURELY REPLACING MY TIRES.

NHTSA ODI #11233101

122,000 miles · Apr 26, 2019

Suspension

Read full complaint

SOMETIMES WHEN I AM PULLING OUT OR PULLING IN TO PARK MY CAR I HEAR THIS BANG ON MY RIGHT REAR SIDE. SOMETIMES WHEN I AM TURNING LEFT OR RIGHT AND THE RIGHT REAR TIRE GETS MOST OF THE WEIGHT OF THE VEHICLE I HEAR THE SAME HARD BANG. I TOOK IT TO MY MECHANIC AND HE RODE WITH ME AND HE HEARD IT TOO. MY MECHANIC THOUGHT IT WAS THE STRUTS AND REPLACED THEM, BUT THAT WAS NOT THE PROBLEM. I STILL HAVE THIS PROBLEM. PLEASE HELP. MY MECHANIC SAID THAT UNDER THE CAR IN THE REAR THERE IS A BAR THAT HAS A STAMP THAT INDICATES RECALL ITEM.

NHTSA ODI #11203907

Mileage unknown · Dec 17, 2018

Suspension

Read full complaint

TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE MECHANIC FOUND THAT THE VEHICLE WAS NOT AFFECTED BY THIS RECALL, BUT IT WAS REPAIRED ANYWAY AT TOYOTA OF PORTLAND (55 NE BROADWAY ST, PORTLAND, OR 97232, (503) 284-1105). AT NO COST. TOYOTA?S PRESCRIBED RECALL REPAIR INVOLVES APPLYING AN EPOXY TO THE ADJUSTMENT NUTS ON THE REAR LOWER SUSPENSION ARMS (TOYOTA PART # 4871042020), PER THE INSTRUCTIONS SPECIFIED BY TOYOTA (SAFETY RECALL ?CSJ?). IN DECEMBER 2018, A TIRE SERVICE CENTER NOTED THE CONTACT?S REAR WHEELS WHERE OUT OF ALIGNMENT BUT THAT THEY COULD NOT PERFORM AN ALIGNMENT DUE TO THE APPLICATION OF THE EPOXY ? WHICH SEIZED THE ADJUSTMENT NUTS IN PLACE. THE CONTACT IS NOW UNABLE TO HAVE A REAR ALIGNMENT PERFORMED. CONTACT RETURNED THE VEHICLE TO THE DEALER, WHO STATED THAT THE SUSPENSION ARMS MUST BE ENTIRELY REPLACED IN ORDER TO REALIGN THE REAR WHEELS ? WITH TOYOTA INSISTING THE RECALL WORK (APPLYING EPOXY) IS PERFORMED AGAIN AT CONTACT?S EXPENSE. CONTACT WAS QUOTED $1050 BY TOYOTA DEALERSHIP TO PERFORM THE WORK. PRIOR TO THE RECALL, A REAR ALIGNMENT COULD BE PERFORMED AT THE SAME DEALERSHIP (OR ANY INDEPENDENT MECHANIC) ? UTILIZING THE ADJUSTMENT NUTS ? FOR APPROXIMATELY $85. IN SUMMARY, THE CONTACT BELIEVES TOYOTA?S PRESCRIBED RECALL REPAIR HAS INTRODUCED A SAFETY ISSUE DUE TO REMOVING THE ABILITY TO HAVE INDEPENDENT MECHANIC PERFORM A REAR ALIGNMENT.*DT *JB *TR

NHTSA ODI #11162072

Mileage unknown · Oct 31, 2018

Suspension

Read full complaint

TOYOTA ISSUED A SAFETY RECALL G0V A FEW YEARS AGO THAT SEALED THE REAR SUSPENSION ARMS WITH AN EPOXY. MY REAR ALIGNMENT IS OUT, AND I CANNOT NO LONGER ADJUST MY REAR SUSPENSION UNLESS I REPLACED BOTH REAR SUSPENSION ARMS. TOYOTA SAYS THIS IS MY OWN PROBLEM, AND ANY REPAIR ASSOCIATED WITH THIS SAFETY RECALL HAS TO COME FROM MY POCKET. HOW CAN THE SAFETY RECALL LEAD TO ANOTHER PROBLEM? I AM PROBABLY NOT THE ONLY ONE WHO HAS EXPERIENCED THIS ISSUE AS I READ SEVERAL OTHER FOLKS WHO VOICED THEIR CONCERNS ONLINE. IS THERE ANYTHING THAT NHTSA CAN DO?

NHTSA ODI #11144521

100,000 miles · Sep 24, 2018

Suspension

Read full complaint

TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR A WHEEL ALIGNMENT. WHEN THE MECHANIC PLACED THE VEHICLE ON THE LIFT, IT WAS NOTICED THAT THE REAR PASSENGER SIDE CONTROL ARM WAS BOLTED AND EPOXIED. THE CONTACT STATED THAT THE REAR PASSENGER SIDE CONTROL ARM WAS REPAIRED ON DECEMBER 21, 2014 BY TOYOTA OF MORRISTOWN (169 RIDGEDALE AVENUE, MORRISTOWN, NJ 07960) PER NHTSA CAMPAIGN NUMBER: 16V383000 (SUSPENSION). IMMEDIATELY AFTER THE REPAIRS WERE PERFORMED, THE REAR PASSENGER TIRE STARTED TO WEAR UNEVENLY AND HAD TO BE REPLACED FIVE TIMES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ODI #11130949

99,000 miles · Jul 31, 2018

Suspension

Read full complaint

REAR TOE ALLINEMENNT ADJUSTERS RECALL. THE PART IS NOW BEING EPOXIED DUE TO A TOYOTA MANUFACTURING FLAW. NOW THE CUSTOMERS HAVE TO SUFFER THE COST AT $600.00 TO HAVE A SIMPLE ALLINEMENT DONE ON THE REAR OF THE CAR. THE ONLINE CAR REVIEWS FROM OTHER CUSTOMERS ARE REALLY PISSED FOR BEING PLAYED SUCKERS FROM TOYOTA. THERE IS A LOT OF LOYAL TOYOTA CUSTOMERS GOING TO DROP TOYOTA AND GO WITH HONDA. AND AFTER GETTING RID OF THESE FLAWED CARS TO THE OPEN MARKET AND OTHER PEOPLE GET TO OWN FLAWED JUNK 'TOYOTA'S', THEIR VIEW WILL BE THE SAME AS THE CURRENT TOYOTA OWNERS. THEN THE SNOWBALL EFFECT KICKS IN PLUS ALL THE NEWS ABOUT TOYOTA'S NOW BEING JUNK CARS I'M SURE WILL HURT THE COMPANY WHERE IT SHOULD, IN THEIR BANK ACCOUNTS. I WAS A BIG LOYAL TOYOTA OWNER FOR YEARS, TAKING A LOT OF HEAT FROM MY NASCAR FRIENDS FOR OWNING A TOYOTA, WAIT TILL THEY HEAR ABOUT THIS, THIS WILL MAKE THEIR DAY AND A I TOLD YOU SO WILL BE NEXT. TOYOTA HAS OR HAD A CHANCE TO DO IT RIGHT AND THEY ARE BLOWING IT BIG TIME. 2006-2011 YEARS HAVE BEEN RECALLED ON THE RAV4, OVER 200,000 CARS. AT THIS NUMBER TOYOTA WILL GO DOWN QUICK. I ALSO HAVE BEEN THROUGH 2 SETS OF EXPENSIVE TIRES DUE TO THIS PROBLEM TO FIND OUT IT'S A SHODDY WAY FOR TOYOTA TO DO BUSINESS LIKE THIS. WE, THE CUSTOMER HAVE BEEN PLAYED OFF AS STUPID, I DON'T SEE IT THAT WAY ALONG WITH A LOT OF OTHERS. I HEAR HONDA'S ARE STILL DOING IT RIGHT, IF SOMETHING DON'T HAPPEN SOON, I WILL BE FINDING IT OUT MYSELF. OH I ALMOST FORGOT, THE TIRES NOW GOING BAD WAY TO SOON IS A SAFETY ISSUE AND NOW VERY HARD TO AFFORD THE COST OF OPERATION FOR THIS VEHICLE, YOU THINK IT'S THE SHOCKS, THEY CHECK GOOD, SHAME ON YOU TOYOTA.

NHTSA ODI #11114724

Mileage unknown · Jul 1, 2018

Suspension

Read full complaint

MY COMPLAINT IS ABOUT THE REAR SUSPENSION RECALL ENACTED IN 2012. I HAD THE RECALL PERFORMED AT MY LOCAL TOYOTA DEALER IN 2014. RECENTLY I PURCHASED NEW TIRES AT A FIRESTONE DEALER AND PURCHASED A A LIFETIME ALIGNMENT. WHEN THEY PERFORMED THE ALIGNMENT FOR FRONT AND REAR, BOTH NEEDED A LITTLE ADJUSTMENT. I WAS INFORMED THAT IT COULD NOT BE DONE AND THEY CAN ONLY ADJUST THE FRONT AS THE REAR HAD A TAG THAT STATES "ONLY TO BE SERVICED BY AN AUTHORIZED TOYOTA DEALER." FURTHERMORE, WHEN TOYOTA SERVICED THE RECALL, THEY PAINTED EPOXY OVER THE ENTIRE ARM. NOW THIS LEAVES FOR A VERY EXPENSIVE FIX. THE RECALL SOLUTION MADE BY TOYOTA DISABLED THE ABILITY TO ADJUST THE TOE IN TOE OUT FUNCTION TO ALIGN THIS VEHICLE PROPERLY. I CALLED THE TOYOTA DEALERSHIP AND THEY TOLD ME THE WHOLE SUSPENSION NEEDS TO BE REDONE WITH NEW PARTS AND NEW KITS COSTING 200 DOLLARS PLUS LABOR. I BELIEVE THIS TO BE A ENGINEERING PROBLEM. THE RECALL FIX DID NOT ALLOW AN ADJUSTABLE ARM AND THIS WILL CAUSE AN UNEVEN WEAR ON MY BRAND NEW TIRES. THIS IS WRONG AND TOYOTA FEELS THEY HAVE NO RESPONSIBILITY ON THIS MATTER AND IS LAYING THIS BLAME ON THE NATIONAL HIGHWAY SAFETY RECALLS. IN MY OPINION ANOTHER RECALL SHOULD BE IN ORDER. PEOPLE THAT OWN THESE VEHICLES SHOULD NOT HAVE TO PAY EXPENSIVE REPLACEMENT CHARGES TO FIX AN ALREADY RECALLED REAR SUSPENSION PROBLEM. WITH ALL THE ROAD HAZARDS ALIGNMENT PROBLEMS HAPPENING ALL THE TIME OR ANYTIME, AN ALIGNMENT IS BOUND TO OCCUR. WHAT CAN BE DONE TO GET THE MANUFACTURES TO OWN UP TO THE INADEQUACY OF THE RECALL SOLUTION THEY PERFORMED. P.S. SOME OF US CONSUMERS KEEP OUR CARS FOR A LIFETIME OF THE VEHICLE. AND I KNOW TOYOTA LIKES TO BRAG ABOUT THE LONGEST LASTING MOST DEPENDABLE CAR ON THE ROAD. I AM ONE OF THOSE PEOPLE THAT KEEP MY CARS MAINTAINED AT I'S MAXIMUM DRIVING CAPACITY.

NHTSA ODI #11104952

Mileage unknown · Jun 11, 2018

Suspension

Read full complaint

TL* THE CONTACT OWNS A 2010 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (PARKWAY TOYOTA, 50 SYLVAN AVE, ENGLEWOOD CLIFFS, NJ 076320, (201) 944-3300) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS UNABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI #11101122

Mileage unknown · May 25, 2018

Suspension

Read full complaint

I HAVE MY REAR TIRES WEARING UNEVEN. TOOK MY VEHICLE TO GET AN ALIGNMENT BUT TOYOTA HAS A STICKER ON IT SAYING NO ONE CAN ADJUST DUE TO RECALL. TOYOTA APPARENTLY PUT APOXY ON THEIR SUSPENSION RECALL AND NOW MY CAR NEEDS AN ALIGNMENT AND NO ONE CAN FIX IT. TOYOTA SAYS FOR 850.00 THEY WILL FIX IT. SERIOUSLY, IT ONLY NEEDS AN ALIGNMENT BUT BECAUSE THEY DID A HORRIBLE JOB IN THE FIRST PLACE I AM UNABLE TO MAINTAIN MY OWN CAR. THEY REFUSE TO FIX IT WITHOUT CHARGING ME. HOW CAN THEY GET AWAY WITH THIS. THIS IS THEIR FAULT

NHTSA ODI #11097943

Official recalls

16V596000 · Suspension:rear

Aug 12, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.

Consequence & remedy

Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.

16V396000 · Seats:front Assembly:seat Heater/cooler

Jun 2, 2016

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence & remedy

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

16V096000 · Seat Belts:rear/other

Feb 19, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.

Consequence & remedy

Consequence: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.

Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.

15V689000 · Visibility:power Window Devices And Controls

Oct 22, 2015

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Consequence & remedy

Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

15V577000 · Visibility/wiper

Sep 18, 2015

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.

Consequence & remedy

Consequence: Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.

14V743000 · Seats:front Assembly:seat Heater/cooler

Nov 19, 2014

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence & remedy

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

13V383000 · Suspension:rear

Aug 28, 2013

Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.

Consequence & remedy

Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.

13V123000 · Equipment:other:labels

Apr 9, 2013

Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

13V014000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seats

Jan 16, 2013

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence & remedy

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Additional source detail variants (2)

Air Bags:frontal:sensor/control MODULE-INACTIVE

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Seats

12V373000 · Suspension:rear

Aug 2, 2012

Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.

Consequence & remedy

Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.

11V113000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

10V035000 · Equipment:other:labels

Feb 3, 2010

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

10V017000 · Vehicle Speed Control:accelerator Pedal

Jan 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.

Consequence & remedy

Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal

Go deeper into Toyota RAV4 problems

Toyota RAV4 transmission problems →Toyota RAV4 electrical problems →