Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

16 crash reports4 fire reports11 injury reports

Engine complaints

11 reports

Clear category filter

34,000 miles · Oct 10, 2012

Air BagsEngineCrashFireInjury

Read full complaint

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH AND ATTEMPTING A LEFT TURN WHEN ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE DOOR OF THE CONTACT'S VEHICLE. THE VEHICLE SLID FORWARD AND PROCEEDED TO CRASH OVER A CURB AND INTO A POLE. THE SIDE CURTAIN AIR BAGS FAILED TO DEPLOY. IMMEDIATELY AFTER THE CRASH, SMOKE BEGAN EMITTING FROM THE ENGINE COMPARTMENT. THE DRIVER WAS ABLE TO EXIT THE VEHICLE AND NOTICED FLAMES COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. THE CONTACT SUSTAINED BRUISING AND PAIN TO THE LOWER BACK. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL VIA AMBULANCE AND WAS LATER DISCHARGED WITH NO MAJOR INJURIES. THE VEHICLE WAS TOWED TO AN AUTO BODY LOT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND SENT AN ENGINEER TO INSPECT THE VEHICLE. THE ENGINEER ADVISED THAT THE CRASH DID NOT OCCUR IN BETWEEN BOTH DOORS SO THE CURTAIN AIR BAGS WOULD NOT HAVE DEPLOYED. ADDITIONALLY, THE ENGINEER STATED THAT THE FRONT BUMPER PUSHED THE ENGINE BACK AND FRACTURED THE TRANSMISSION LINES, CAUSING TRANSMISSION FLUID TO LEAK INTO THE ENGINE MANIFOLD. AS A RESULT, THE FAILURE RESULTED IN A FIRE WHICH CAUSED THE ENGINE TO MELT. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 34,000.

NHTSA ODI #10479545

Official recalls

19V741000 · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

Oct 17, 2019

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Additional source detail variants (2)

Air Bags:frontal:passenger Side:inflator Module

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Air Bags:frontal:driver Side:inflator Module

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

15V284000 · Air Bags:frontal:driver Side:inflator Module

May 13, 2015

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2005 Toyota RAV4 vehicles manufactured May 13, 2003, to October 25, 2005. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify owners, and dealers will replace the driver's frontal air bag, free of charge. Owners were mailed an interim notice June 17, 2015. The recall began on August 21, 2015. Owners may contact Toyota customer service at 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.

Go deeper into Toyota RAV4 problems

Toyota RAV4 transmission problems →Toyota RAV4 electrical problems →